-
Haier RF-8888-193 - page 1
1 HAIER REFRIGERATOR Service Manual PART # RF-8888-193 HAIER AMERICA TRADING, L LC www.haieramerica.com ...
-
Haier RF-8888-193 - page 2
2 TABLE OF CONTENTS Specification Safety precautions Refrigerating Principle Principle Of Electrical Control Troubleshooting And Repairs 3 4 6 7 8 ...
-
Haier RF-8888-193 - page 3
3 SPECIFICATION MODEL HBF05EABB Capacity (gallons) 47.5 Power supply V/Hz 115V / 60Hz Rated power input W 100 Power consumption k*W*h / 24hrs 0.60 Net weight (lbs) 83.7 Gross weight (lbs) 93.6 Unit dimensions (D x W x H) in 23.6 x 23.6 x (33 x 3.4) Package dimensions (D x W x H) in 26.3 x 25.9 x 36 Container quantity 40’ 146 Container quantity 40 ...
-
Haier RF-8888-193 - page 4
4 SAFETY PRECAUTIONS Read all the instructions before using the appliance. When using this appliance, always exercise basic safety precautions, including the following: 1. Use this appliance only for its intended pur pose as described in this operation manual. 2. This appliance must be properly installed in accordance with the instruction before it ...
-
Haier RF-8888-193 - page 5
5 1. Always connect CO 2 gas cylinder to a regulator. Failure to do so could result in an explosion with possible death or injury when the cylinder valve is opened. 2. Never connect CO 2 gas cylinder directly to beer keg. 3. Always secure CO 2 gas cylinder in an upright position. 4. Always keep CO 2 cylinder away from heat. 5. Never drop or throw C ...
-
Haier RF-8888-193 - page 6
6 REFRIGERATING PRINCIPLE Schematic diagram of refrigerating principle • Brief Description of the Refrigeration Principle The refrigerating system of direct cooling single-system refriger ators belongs to the category of dual temperature and single-cont rol refrigerating system. T he heat conducting area of the corresponding evaporator determines ...
-
Haier RF-8888-193 - page 7
7 PRINCIPLE OF ELECTRIC CONTROL HBF05NABB RATED VOLTAGE 115V RATED CURRENT 1.3A RATED FREQUENCY 60Hz HIGH SIDE PRESSURE 280Psi LOW SIDE PRESSURE 130Psi REFRIGERANT R134a THERMOSTAT OVERLOAD PROTECTOR PLUG COMPRESSOR C PTC RUN CAPACITOR ...
-
Haier RF-8888-193 - page 8
8 TROUBLESHOOTING AND REPAIRS 1. NORMAL REFRIGERATOR FUNCTIONS A domestic refrigerator is comprised of an el ectric control system and a refrigerating system. Since both systems work together, it is di fficult to tell whether the refrigerating system is in good working condition. If any part of the refrigerating system or electric control does not ...
-
Haier RF-8888-193 - page 9
9 2. COMMON PROBLEMS OF A REFRIGERATOR AND THEIR SOLUTIONS Refrigerator problems are closely relat ed to the quality of components, level of workmanship, and owner maintenance. The parameters generally us ed to determine the working conditions of a refrigerator include the temperature inside the refrigerator, the operating rate, electrical power co ...
-
Haier RF-8888-193 - page 10
10 iii. Whistling sounds indic ate the release of high-pressure gas from a crack in the pressure tube inside the compressor. iv. Clucking sounds indicate that the suspended spring inside the compressor has broken v. Knocking sounds from inside the compressor indica tes that a large quantity of moist refrigerant vapor or refri gerating oil has linke ...
-
Haier RF-8888-193 - page 11
11 a. Poor Refrigerating Effect The “poor refrigerating effect “refers to w hen the refrigerator operates normally, but does not cool to the temperature indicated by t he thermostat. Possible causes are discussed and analyzed below: 1) Refrigerant leaks Analysis of Trouble The refrigerant leaks will result in an insuffici ent refrigerating capa ...
-
Haier RF-8888-193 - page 12
12 Analysis of Trouble Residual air in the refrigerat ing system will reduce its refrigerat ing efficiency. Major effects are an increase in temperature of the segment from the comp ressor outlet to the condenser inlet and an increase in gas suction and exh aust pressures. However, the gas exhaust pressure will not exceed its rated value. Due to th ...
-
Haier RF-8888-193 - page 13
13 temperature of discharged gas, and, for seve re cases, condensation and frosting may appear. Remedy Purge the tubing. After replacing the dry filter or cleaning it t horoughly, refill the system with refrigerant and seal the charging port. • No Refrigerating “No refrigerating” refers to a situation where the compressor runs normally, but t ...
-
Haier RF-8888-193 - page 14
14 - Water accumulates and gradually clogs the narrow part of the capillary, - Frost to melt at t he evaporator, there is no sound of gas flowing, - The gas suction pressure becomes a vacuum. Note that these phenomena will appear intermittently. In order to know whether the system is clogged with ice, heat the parts that are suspected with hot wate ...
-
Haier RF-8888-193 - page 15
15 Remedy It is quite difficult to differentiate this trouble from others because they have similar symptoms. When repairing, lis ten attentively for abnorma l sounds coming from the compressor. Oftentimes, broken pieces of valv e block strike against the cylinder. Check to see if the compressor casing is too hot. Sec ondly, measure the pressures a ...
-
Haier RF-8888-193 - page 16
16 in the system, you have to open the tubing, re-evacuate it and then charge it with refrigerant. Stoppage due to electrical troubles Thermostat is out of cont rol due to electric troubles Analysis of Trouble In case the thermostat does not work in it s good order or its temperature sensor has not been installed properly, frequent stoppage ...
-
Haier RF-8888-193 - page 17
17 In case the compressor cannot be started, you must find out the origins of this trouble through systematic checkup, because probably there are many causes, including the electrical and mechanical parts. a) Inspect the power supply to see whether it is connected to the compressor circuit. Analysis of Trouble In case the compressor cannot be start ...
-
Haier RF-8888-193 - page 18
18 temperature sensor. Try to turn the adjusting stem of this value in the direction of the lower temperature graduation, and then check the contacts to s ee whether they are closed. If they are still not closed, dismantle the temper ature-sensing disc and then immerse it into warm water to see whether the contacts actuat e. If not, it can be preli ...
-
Haier RF-8888-193 - page 19
19 This is normally caused by poor lubrication, insufficient quantity of lubricant, clogging in the lubricant oil’s line, or intermittent lubrican t oil supply. Dirt and ot her impurities in the lubricant will increase its visco sity and cause the shaft to be seized. Copper plating may also result in the seizure of the shaft. ii) Seizing of pisto ...
-
Haier RF-8888-193 - page 20
20 Analysis of Trouble Leakage of refrigerant and cloggin g in a refrigerating system will directly affect its refrigerating capacity. Due to the reduction in its refrigerati ng capacity, the refrigerator temperature cannot reach its rated value. The thermostat will not work, thus the compressor runs continuously. When the evaporation temperature i ...
-
Haier RF-8888-193 - page 21
21 A tingle sense will be experienced as soon as you touch the metal parts of the refrigerator with the hand. When you test them with a test pencil, its neon lamp will come on. In that case, the first thing y ou need to do is to determine whether the grounding is perfect. If the grounding has no problem, turn off the refrigerator immediately, then ...
У вас вопрос, касающийся Haier RF-8888-193?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Haier RF-8888-193, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Haier RF-8888-193 со всей вероятностью он захочет поделиться методом ее решения.