-
Panasonic M157594J - page 1
M157594J Installation, Operation, a nd Maintenance Manua l HOT WATER PRESSURE WAS HER : C leans d irty surfaces with high pressure hot water. To the Owner: Thank you fo r purchasing a NorthStar hot w ater pressure w asher. Your machine is designed f or long lif e, dependability, and th e top performance you dem and ! Take time now to read through t ...
-
Panasonic M157594J - page 2
2 Table of Contents Important Saf ety Instruction s 2 Maintenance Instructions 10 Specifications 3 Long Term /Winter Storage 12 Machine Com ponent Identification 4 T roubleshooting 13 Installation Instructi ons 5-6 Parts Breakdowns 14-16 Operation Instr uctions 7-9 Electrical Schem atic 17 Safety F eatures 9 Trailer A ssem bly Instructio ns (157595 ...
-
Panasonic M157594J - page 3
Specifications 3 Pressure Rating 4000 psi Flow Output 4 gpm Pump Type Cat 66DX W ater Supply Standard tap water @ 20 -75 psi or water feed ta nk Engine Horsepower 18 hp BTU Output 353,700 BTU Maximum Temperature 210 F Approved Fuels #1 or #2 Diesel, Ker osene, Fuel Oil Fuel Capacity 4 Gal Gasoline Capacity 4 Gal Discharge Hose 3/8” Dimensions ...
-
Panasonic M157594J - page 4
Machine Component Id entification 4 Ref # Description Ref # Description Ref # Description 1 Unloader 9 Ball Valve (feed tank ) 16 W ater Outlet 2 Lifting E ye 10 Ball Valve (c ity tap water) 17 Engine Ke y Switch 3 Engine (see e ngine manua l) 11 W ater Filter 18 Circuit Break er 4 Inlet Plum bing 12 W ater Inlet (city tap water) 19 Heat Switch 5 D ...
-
Panasonic M157594J - page 5
Installation Instructions 5 Installing a Batter y Warning: Sulfuric acid is a corrosive poiso n. Avoid contact w ith skin, e yes or clothing. Alwa ys wear safet y glasses. A lways wear s afety glass es when wo rking on or near the battery. The engine will not run a nd the burner wi ll not f ire without first inst alling a batt ery. The batter y box ...
-
Panasonic M157594J - page 6
Installation Instructions 6 Venting DANGER: Do not run machine indo ors or in an enclosed area w ithout adequate vent ilation, or in areas where flammab le vapors, (gasoline, solv ents, etc.) may be present. Do not v ent exhaust gases into a wall, a ceiling , or a con cealed place. CAUTION: All venting must be in accordance w ith applicable state a ...
-
Panasonic M157594J - page 7
Operating Instructions 7 Read and understand the entire manual before operating the pressure washer. Follow these instructions ev ery time you use the pressure washer. I.) Pre-Operation Read entire m anual, especially the important safet y instructions. 1.) Check hoses, fittings, wand, trigger gun a nd fuel connections for sig ns of wear, crack s a ...
-
Panasonic M157594J - page 8
Operating Instructions 8 V.) Turn Water Supply ON (city water tap only) Make sure the hose i s not “k inked”. A k inked hose will provide insuff icient water supply to the pump and will reduce its life. Make sure the h ose remains unk inked after moving th e pressure washer. VI.) Attach Nozzle Color of Noz zle: Spra y A ngle Used For: Red 0 Hig ...
-
Panasonic M157594J - page 9
Operating Instructions 9 X.) For Hot Water If HOT water is des ired, m ake sure there is f uel in the fuel tank, turn the heat switch ON, and adjust the thermos tat to the desired temperature. T he burner will fire when the trigger is squeeze d. You m ay need to initially adjust your burner f or peak perform ance. See the “Oil Burner” section u ...
-
Panasonic M157594J - page 10
Maintenance Instructions 10 WARNING: Unauthorized machi ne modification or use of non-approved re placement parts may cause pers onal injury and/or property damage and will void the ma nufacturer warranty . See Engine manual for engine maintenance . Maintenance Mode Before perform ing any maint enance on the press ure washer, it m ust be placed in ...
-
Panasonic M157594J - page 11
Maintenance Instructions 11 Coil Descaling In hard water areas, scale build-u p within the heating coil will occur. Scale deposits will decrease the wat er temperature ris e and m ay eventuall y clog the heat ing coil. 1. Mix c oil cleaner in a 5 g allon buck et and elevate t he bucket s o it is higher than t he unloader. 2. Attach th e high-pressu ...
-
Panasonic M157594J - page 12
Long Term / Winter Storage 12 During cold w eather, stor e the pressur e washer in doors and mov e it outdoors bef ore startin g the eng ine. Long T erm Storage and Freeze Protection 1.) Attach a feed ta nk or buc ket to the water i nlet (feed t ank). See Installation s ection for Attach ing a W ater Feed Tank instructions. 2.) Fill feed tank with ...
-
Panasonic M157594J - page 13
Troubleshooting Guide 13 Engine Will Not Start Causes Solutions Low Oil Shutdown Fill engine with the adequate a mount of oil. Cold Engine Choke engine to start. No Fuel Add gas t o engine, make sure fuel sh utoff valve is open. Dead Battery Recharge/Replace battery. Spark plug wire n ot attached Attach spark plu g wire to spark plug. Pressure Wash ...
-
Panasonic M157594J - page 14
Parts Breakdown 157594J 14 ...
-
Panasonic M157594J - page 15
Component List – 157594J 15 REF PA RT # DESCRIPTION Model QTY REF PART # DESCRIPTION Model QTY 777222 Honda engine 1 8hp All 1 55 777486 Heat shield, battery All 1 1 32842 Honda muffler kit All 1 56 777 485 Tank clamp All 1 2 3 0511 1/2npt plug All 1 57 777 666 Decal, gasoline All 1 3 777837 3/8npt plug A ll 1 58 7 77721 Decal, side panel All 2 4 ...
-
Panasonic M157594J - page 16
Parts Breakdown – 157595J 16 REF P ART # DESCRIPTION QTY REF PART # DESCRIPTION QTY 1 779257 Hose Reel 2 19 5318 Nipple ¾ NPT x ¾ Hose Barb 1 3 777903 Frame, Sk id 1 20 5370 Bulkhead ¾” N PT Fem ale 3 4 3019 8 200 Gal T ank 1 21 50NB R12 ½ Hose Barb x ¾ NPT Elbow 1 5 777707 Tank Strap 2 22 17141 Hose Clam p ¾ 1 6 8208 0 Eye Bolt, ¼” 4 ...
-
Panasonic M157594J - page 17
Wiring Diagram – Rev J 17 ...
-
Panasonic M157594J - page 18
Trailer Assembly Instructions (157595 only) 18 1.) Remove the top and four s ides of the ste el crate. 2.) Remove a-f rame f rom trailer fram e. (k eep fasteners f or step 7) 3.) Slide a-fram e into holders under trailer f rame (built into the f ront posts) . 4.) Install jack onto a-fram e with 3/8x1” bolts , Class G lock nuts, and washers pr ovi ...
-
Panasonic M157594J - page 19
19 This page has intentionally been left blank. ...
-
Panasonic M157594J - page 20
20 Manufactured by Northern Tool + Equipment Co., 2800 SouthCross Drive West P.O. Box 1499 Burnsville, MN 55337-0499 TM ...
У вас вопрос, касающийся Panasonic M157594J?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Panasonic M157594J, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Panasonic M157594J со всей вероятностью он захочет поделиться методом ее решения.