-
Agway AGF550A - page 1
190344 01.21.04 TR PRINTED IN U .S.A. • Assembly • Operation • Maintenance • Service and Adjustments • Storage • Troubleshooting • Repair Parts OWNER'S MANUAL MODEL NO . A GF550A 5.5 HP 26 Inc h Tiller F or Parts and Ser vice, contact our authorized distributor: call 1-800-849-1297 F or T echnical Assistance: call 1-800-829-5886 ...
-
Agway AGF550A - page 2
2 • K eep children and pets aw ay . • Do not overload the machine capacity by attempting to till too deep at too f ast a rate. • Ne ver oper ate the machine at high speeds on slipper y surf aces. Look behind and use care when bac king. • Ne ver allow b ystanders near the unit. • Use only attachments and accessories approv ed by the manuf ...
-
Agway AGF550A - page 3
3 PR ODUCT SPECIFICA TIONS Gasoline Capacity: 3 Quar ts (2.8L) Unleaded Regular Oil (API-SF-SJ): SAE 30 (Abov e 32°F/0°C) (Capacity: 20 oz./0.6L) SAE 5w-30(Below 32°F/0°C) Spark Plug: Champion RC12YC (Gap: .030"/0.76mm) CONGRA TULA TIONS on y our purchase of a new tiller . It has been designed, en gi neered and manu f ac tured to give you ...
-
Agway AGF550A - page 4
4 ASSEMBL Y OPERA T OR’S POSITION (See Fig. 1) When right or left hand is mentioned in this manual, it means when you are in the oper ating position (standing behind tiller handles). Y our new tiller has been assemb led at the factory with exception of those parts left unassembled f or shipping pur poses. T o ensure safe and proper operation of y ...
-
Agway AGF550A - page 5
5 UNP A CK CART ON & INST ALL HANDLE (See Fig. 2) CA UTION: Be careful of exposed sta ples when handling or disposing of cartoning material. IMPORT ANT : WHEN UNP ACKING AND AS SEM BLING TILLER, BE CAREFUL NO T TO STRETCH OR KINK CABLE(S). • Cut cable ties securing handles. • Slowly lift handle as sem bly up , route cable(s) as shown and al ...
-
Agway AGF550A - page 6
6 KNO W Y OUR TILLER READ THIS O WNER'S MANU AL AND SAFETY RULES BEFORE OPERA TING Y OUR TILLER. Compare the illustrations with y our tiller to familiarize y ourself with the location of various controls and adjustments. Save this manual f or future reference . REVERSE TINE CONTROL These symbols ma y appear on your Tiller or in literature supp ...
-
Agway AGF550A - page 7
7 handles _94 FOR W ARD TINE CON TROL IN “OFF ” (UP) POSITION REVERSE CONTROL e ngine_a rt_ 7 1 CHOKE CONTROL THRO TTLE CONTROL FOR W ARD TINE CON TROL IN “ON” (DO WN) POSITION TINE OPERA TION (See Fig. 5) FOR W ARD • Squeeze f orward tine control to handle . REVERSE • With f orward tine control “OFF” (up) position, pull back and ho ...
-
Agway AGF550A - page 8
8 T O TRANSPORT CA UTION: Before lifting or trans port ing, allow tiller engine and m uffl er to cool. Disconnect spark plug wire. Drain gasoline from fuel tank. AROUND THE Y ARD • Tip depth stake f orward until it is held by the stak e spring. • Push tiller handles down, raising tines off the g round. • Push or pull tiller to desired locati ...
-
Agway AGF550A - page 9
9 e ng in e_a rt_ 7 1 BREAKING IN Y OUR TILLER Break-in your belt(s), pulle ys and tine control before y ou actually begin tilling. • Star t engine, tip tines off ground b y pressing handles down and engage tine control to star t tine rotation. Allow tines to rotate f or fi ve min utes. • Check tine operation and adjust if necessary . See “T ...
-
Agway AGF550A - page 10
10 MAINTENANCE SCHEDULE FILL IN DATES AS YOU COMPLETE REGULAR SERVICE Check Engine Oil Level Change Engine Oil Oil Pivot Points Inspect Air Screen Inspect Spark Arrester / Muffler Clean or Replace Air Cleaner Cartridge Clean Engine Cylinder Fins Replace Spark Plug BEFORE EACH USE EVERY 25 HOURS EVERY 5 HOURS EVERY 50 HOURS SERVICE DATES 2 1 - Chang ...
-
Agway AGF550A - page 11
11 FIG. 11 engine_ar t_12 FIG. 12 OIL DRAIN PLUG OIL FILLER PLUG OIL LEVEL TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE SAE VISCOSITY GRADES -20 0 30 40 80 100 -30 -20 0 20 30 40 F C 32 -10 10 60 5W-30 SAE 30 oil_visc_chart1_e MAINTENANCE AIR CLEANER SCREW CO V ER AIR CLEAN ER CAR TRIDGE FIG. 13 Disconnect spark plug wire before perf orming ...
-
Agway AGF550A - page 12
12 MAINTENANCE e ngine_a rt_ 7 1 BLO WER HOUSING AIR SCREEN CYLINDER FINS MUF FLER FIG. 14 COOLING SYSTEM (See Fig. 14) Y our engine is air cooled. F or proper engine performance and long lif e keep your engine clean. • Clean air screen frequently using a stiff-bristled- brush. • Remov e blo wer housing and clean as nec es sar y . • K eep cyl ...
-
Agway AGF550A - page 13
13 TILLER T O ADJUST HANDLE HEIGHT (See Fig. 15) F actor y assemb ly has provided low est handle height. Se lect handle height best suited f or your tilling conditions. Handle height will be diff erent when tiller digs into soil. • If a higher handle height is desired, loosen the f our nuts securing handle panel to engine brack ets. • Slide han ...
-
Agway AGF550A - page 14
14 TINE OPERA TION CHECK (See Fig. 19) W ARNING: Disconnect spark plug wire from spark plug to pre vent star ting while chec king tine operation. F or proper tine operation, forw ard tine control lev er must be against control body and all slack remo ved from inner wire of control cable when control is in the “OFF” (up) position. If le ver and ...
-
Agway AGF550A - page 15
15 belts_10 FIG. 22 FOR W ARD MOTION (INSIDE) V -BEL T ENGINE PULLEY REVERSE IDLER ARM REVERSE IDLER PULLEY IDLER ARM PIN FIG. 21 FOR W ARD IDLER PULLEY REVERSE IDLER PULLEY ENGINE PUL- LEY FRONT VIEW REFERENCE REVERSE (OUTSIDE) V -BEL T FOR W ARD MO TION (INSIDE) V -BEL T TRANS MIS SION PUL LEY BEL T GU ARD BOL T BEL T GUIDE REVERSE IDLER PULLEY I ...
-
Agway AGF550A - page 16
16 ST ORA GE ENGINE OIL Drain oil (with engine warm) and replace with clean oil. (See “ENGINE” in the Maintenance section of this man ual). CYLINDER(S) • Remov e spark plug. • P our 1 ounce (29 ml) of oil through spar k plug hole into cylinder . • Pull starter handle slowly se veral times to distribute oil. • Replace with new spark plug ...
-
Agway AGF550A - page 17
17 Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “TO ST ART ENGINE” in the Operation section. 3. Engine fl ooded. 3. Wait se veral min utes before attempting to star t. 4. Dir ty air cleaner . 4. Clean or replace air cleaner cartr idge . 5. Water in fuel. 5. Empty fuel tank and carb uretor, and ...
-
Agway AGF550A - page 18
18 1 187820X505 Brac ket Handle 2 72140512 Bolt, Carr iage 5/16-18 unc x 1-1¦2 3 9266R Grip , Handle 4 166376 Handle, L.H. 5 73680500 Locknut, Cro wn 5/16-18 6 19111116 Washer 11/32 x 11/16 x 16 Ga. 7 19121414 Washer 3/8 x 7/8 x 14 Ga. 8 74760516 Bolt, Hex Hd. 5/16-18 x 1 9 74760512 Bolt, Hex Hd 5/16-18 x 3/4 10 10040500 Washer , Lock 5/16 11 7322 ...
-
Agway AGF550A - page 19
19 KEY P ART NO . NO. DESCRIPTION 19 188502 Bolt, Belt Guard 20 12000036 Ring, Klip 21 73350600 Nut, Hex, J am 3/8-16 22 161806 Pulley , Idler 23 175377 Ar m, Idler 24 74760620 Bolt, Hex 3/8-16 x 1-1/4 25 106968X Shaft, Idler Arm 26 73350500 Nut, Hex, J am 5/16-18 27 73220400 Nut, Fin Hex 1/4-20 28 10040400 Washer LK Hvy Helical 1/4 29 109227X P ad ...
-
Agway AGF550A - page 20
20 6 7 8 13 9 10 11 22 15 3 24 5 4 7 4 5 17 16 18 18 21 17 16 2 2 1 3 24 19 19 20 20 wheel_d.stake_2 1 9194R Pin, Cle vis 2 74760520 Bolt, Hex 5/16-18 x 1-1/4 3 74760512 Bolt, Hex 5/16-18 x 3/4 4 73220500 Nut, Hex 5/16-18 5 10040500 Washer , Lock 5/16 6 73800600 Locknut, w/w asher 3/8-16 7 4921H Clip , Hair pin 8 1952J Suppor t, Depth Stak e, R.H. ...
-
Agway AGF550A - page 21
21 REP AIR P AR TS TILLER - - MODEL NUMBER A GF550A TINE ASSEMBL Y KEY P ART NO . NO. DESCRIPTION 1 156934 Tine, Outer , R.H. 2 3146R Retainer , Spr ing 3 156932 Tine, Inner , R.H. 4 156931 Tine, Inner , L.H. 5 156933 Tine, Outer , L.H. 6 4929H Pin, Cle vis KEY P ART NO . NO. DESCRIPTION 3 1 6 4 5 6 2 2 tine_ipb_3 ...
-
Agway AGF550A - page 22
22 REP AIR P AR TS TILLER - - MODEL NUMBER A GF550A TRANSMISSION KEY P ART NO . NO. DESCRIPTION 14 9173R Spacer , Split 16 19091412 Washer 9/32 x 7/8 x 12 Ga. 17 19092016 Washer 9/32 x 1-1/4 x 16 Ga. 18 10040400 Washer , Lock 1/4 19 74610412 Bolt, Hex 1/4-28 x 3/4 Gr . 5 20 - - - - - - - Engine, Briggs Model 126302 Order par ts from engine manuf ac ...
-
Agway AGF550A - page 23
23 REP AIR P AR TS TILLER - - MODEL NUMBER A GF550A DECALS KEY P ART NO . NO. DESCRIPTION 1 186258 Decal, Logo 2 190488 Decal, Logo 3 139936 Decal, Control Panel 5 141907 Decal, Hand Placement 6 176392 Decal, Eng. Tiller 7 171077 Decal, OHV . N-I/C 8 141906 Decal, W ar ning, Rotating Tines 9 186245 Decal, Tine Shield 10 171078 Decal, Rewind Intek 1 ...
-
Agway AGF550A - page 24
LIMITED W ARRANTY The Manuf acturer warrants to the original consumer purchaser that this product as manuf actured is free from de- f ects in mater ials and w or k man ship . F or a per iod of two (2) y ears from date of purchase by the original consumer purchaser , we will repair or replace , at our option, without charge for par ts or labor incur ...
У вас вопрос, касающийся Agway AGF550A?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Agway AGF550A, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Agway AGF550A со всей вероятностью он захочет поделиться методом ее решения.