Русский dropdown-ico

Инструкция обслуживания Hearth and Home Technologies CASTLEWOOD 42

43 страниц 5.21 mb
Скачать

Перейти на страницу of 43

Summary
  • Hearth and Home Technologies CASTLEWOOD 42 - page 1

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 1 Owner ’ s Manual Installation and Operation Models: Outdoor Woodburning Castlewood 42 DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation. • Re ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 2

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 2 Read this manual before installing or operating this replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Outdoor Lifestyles wood burning replace. The Outdoor Lifestyles replace you have selected is desig ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 3

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certication . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started A. Design and Installation Considerations . . . . . . . . . . . . 5 B. Non-Combustible Materials . . . . . . . . . ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 4

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 4 1 L isting and Code Approv als A. Appliance Certication This replace system has been tested and listed in accor- dance with UL 127 and CAN/ULC-S610-M87 standards by Underwriters Laboratories Inc. for installation and operation in the United States and Ca ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 5

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 5 2 Gett ing Star ted A. Design and Installation Considerations Check building codes prior to installation. • Installation MUST comply with local, regional, state and national codes and regulations. • Consul t insura nce carri er , local building inspect or ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 6

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 6 F . Grate This replace is designed to be used with the grate sup- plied with this unit or one approved by HHT . The grate will deteriorate over time and will need occasional replace- ment.  ! Us ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 7

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 7 3 F raming and C learanc es A. Selecting Fireplace Location This outdoor replace will shed moderate amounts of water , but is not waterproof. Water and condensing water vapor may enter the chase under certain conditions. The replace will not perform as a ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 8

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 8 Figure 3.1 Fireplace Locations FREEST ANDING INST ALLA TION (Combustible Structure) (Enclosed Fireplace) 10 ft Min. Figure 3.2 Freestanding Fireplace Locations 95-1/2 2424 [ ] 54 1372 [ ] 1/2 13 [ ] 1-1/2 38 [ ] 67-1/2 1714 [ ] 53 1346 [ ] 1/2 13 [ ] 1-1/2 38 ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 9

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 9 B. Clearances Fire Risk • Comply with all minimum clearances to combustibles as specied. • Framing or nishing material used on the front of, or in front of, the appliance closer than the minimums listed, must be constructed entirely of noncombustible ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 10

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 10 2 in./51 mm minimum air space clearance to the enclosure. Use only noncombustible material below the top of the top standoffs. 28-3/8 in. 721 cm 74-1/2 in. 1892 cm 53- 7/8 in. 1368 cm C. Sidewalls/Surrounds • Locate adjacent combustible sidewalls a minimum ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 11

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 1 1 E. Chimney Requirements When planning your replace location, the chimney construc- tion and necessary clearances must be considered. The re- place system and chimney components have been tested to provide exibility in construction. The following  ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 12

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 12 4 Installation of F ireplace Position the Fireplace This replace may be placed on either a combustible or noncombustible continouous at surface. Follow the instructions for framing in Section 3.D. Slide the replace into position. Be sure to provide t ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 13

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 13 W ARNING! Cooling air must be provided when install- ing in combustible enclosure or on combustible surface. • Locate cooling air hoods to prevent blockage from leaves, snow/ice, or other debris. Blockages could cause the unit to overheat. • Recommended b ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 14

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 14 V ertical distances are measured from the base of the re- place. • Minimum overall straight height is 10 ft. if the replace is freestanding and a minimum of 10 ft from a combustible structure. • Chimney must extend 2 ft (.6 m) above any portion of t ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 15

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 15 B. Assemble the Chimney Sections         install substitute or dam- aged chimney components. • Use only those components described in this manual. Substitute or dam ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 16

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 16 C. Using Offsets/Returns T o bypass any overhead obstructions, the chimney may be offset using an of fset/return. An offset and return may be attached together or a chimney section(s) may be used between an offset and return. Perform the following steps to de ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 17

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 17 6 Complete th e Enclos ure B. Chase T op A metal chase top is required to seal the top of the chase around the chimney pipe. The top should include a turn- down and drip edge to prevent water from seeping into the chase. Provide a 1/8 in. (3 mm) gap around th ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 18

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 18 TCT1 175 T erra Cotta Cap Chimney Pipe Chase T op T ermination Cap Chase Collar 2 in. (51 mm) Minimum Height Remove 2 screws from front & back to lift the top off T ermination cap pipe and chimney section must overlap 1-1/2 in. (38 mm) Place waterproof se ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 19

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 19 7 Installation of Mold ed Brick Panel A. Install Hearth Molded Brick Panel 1. Put a level on replace to verify it is level side to side and front to back. 2. While the heart h is remov ed from the replace , measure all 4 corrners to determine the varian ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 20

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 20 E. Mortar (Optional) The non-combustible finishing material across the top of fireplace opening will be even with lower edge of metal face. Non-combustible finishing materials MUST overlap side faces by 1 1/4 in. (32 mm) to cover the edges of the panels. Fini ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 21

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 21 8 Accessories Figure 8.1 Gas Line Installation A. Gas Log/Lighter Provisions A certied gas log lighter or decorative gas log set can be installed in this replace. This replace was not tested and listed for use with an un- vented gas log heater . Do n ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 22

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 22 9 Fin ishing A. Non-combustible Materials • Materials which will not ignite and burn, composed of any combination of the following: - Steel - Iron - Brick - T ile - Concrete - Slate - Glass - Plasters • Materials reported as passing ASTM E 136, Standard T ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 23

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 23 D. Raised Hearth Extension Framing The hearth framing must be constructed of non-combustible materials (Figure 12.2) and placed on 1/2 in. Durock and 1 in. Micore (or equivalent material) (Figure 12.4). When cre- ating the platform, allow for the thickness of ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 24

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 24 E. Non-combustible Sealant After completing the framing and applying the facing ma- terials over the framing, a bead of 300° F minimum non- combustible sealant or motar must be used to close of f any gaps at the top and sides between the replace and heart ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 25

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 25 F . Finishing Material Refer to Sections 9.A. and Sections 9.B. for combustible/ non-combustible materials. Refer to Figure 9.2 for non-com- bustible zone if cooling air hoods are installed.  ? ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 26

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 26 G. Mantel Figure 9.3 Clearance to Mantel or other non-combustilbes above replace • Refer to the shaded areas of Figure 9.3 for the location and dimensions of a combustible mantel. • A combustible mantel may be positioned no lower than 22 in. (508 mm) a ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 27

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 27 1 0 Op erating Instruc tions Fire Risk • Do not operate  replace before reading an d und ers tan din g ope rat ing in str uct ion s. Failure to operate  replace properly may cause  re. W ARNING A. General Information Fireplaces, as well as other wo ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 28

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 28 C. Clear Space Near the Fireplace Combustible materials must not be stored on the hearth ex- tension. Outdoor room furnishings such as chairs or other combustibles must be at least 4 ft (1.22 m) from the open front of the  replace. D. Firescreen A  resc ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 29

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 29 F . Wood Fuel Firewood Y our replace performance depends on the quality of the rewood you use. All seasoned wood, regardless of spe- cies, contains about 8,000 BTU’s per pound, and hard- woods have a greater density than soft woods. A piece of hardwoo ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 30

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 30 G. Starting a Fire Place crumpled or twisted paper under the replace grate. Loosely arrange kindling or small pieces of wood to form a layer above the paper . The res must be built on the replace grate, without danger of the burning fuel falling out ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 31

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 31 1 1 T roubleshooting A. Diagnostics and Problem Solving I can’t get a good re going. What am I doing wrong? Diagnostic Questions Possible Causes of Condition Solutions Is the damper open? • No draft Open damper . Is there enough paper/starter? • Insu ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 32

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 32 1 2 Maintenance and Ser vicing the F ireplace A. Disposal of Ashes Ashes should be placed in a metal container with a tight- tting lid. The closed container of ashes should be placed on a noncombustible oor or on the ground, well away from all combustib ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 33

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 33 Handle glass assembly with care. When cleaning glass door: • Avoid striking, scratching or slamming glass. • Do NOT use abrasive cleaners. • Use a hard water deposit glass cleaner on white lm. • Do NOT clean glass when it is hot. CAUTION Fire Risk ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 34

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 34 1 3 Reference Mater ials A. Fireplace Dimensions ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 35

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 35 B. Optional Components ODGF42-BZ Glass Doors (optional) See your Hearth & Home dealer for a complete list of optional components. ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 36

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 36 C. Chimney Components The following pictures show only those chimney components which may be safely used with this replace. A 1 1 in. (279 mm) 13 in. (330 mm) B Chimney Sections Catalog # A B in mm in mm SL1 106 6 152 4-3/4 121 SL1 1 12 12 305 10-3/4 273 S ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 37

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 37 21 in. (533 mm) Inside Diameter 1 1 in. (279 mm) Outside Diameter 13 in. (330 mm) SL1 130 Offset/Return A B 17 in. (432 mm) 2 in. (51 mm) 13 in. (330 mm) JB577 Chimney Joint Band 13 in. (330 mm) CB576 Chimney Joint Band Catalog # A B FS538 0-deg. 17 in. 432 m ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 38

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 38 15-3/4 in. (400 mm) 32-3/8 in. (822 mm) 34-3/8 in . (873 mm) TR1 1T - Round T elescoping T ermination Cap ST1 175 - Square T ermination Cap 9-3/8 in. (238 mm) 10-1/4 in. (260 mm) 17 in. (432 mm) 20 in. (508 mm) TCT1 175 - T erra Cotta Cap 31-3/4 in. (806 mm) ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 39

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 39 Service Parts 08/10 42 in. Woodburning Fireplace Part numbers on following page. T raditional Molded Brick Panel Herringbone Molded Brick Panel ODCASTLEWD-42 1 2 3 4 5 6 7 13 7 12 1 1 14 15 8 9 12 1 1 10 7 Beginning Manufacturing Date: July 2010 Ending Manufa ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 40

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 40 Service Parts List ODCASTLEWD-42 Service Parts 08/10 42 in. Woodburning Fireplace Part numbers on following page. T raditional Molded Brick Panel Herringbone Molded Brick Panel ODCASTLEWD-42 1 2 3 4 5 6 7 13 7 12 1 1 14 15 8 9 12 1 1 10 7 Beginning Manufactur ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 41

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 41 Outdoor Lifestyles by Hearth & Home T echnologies, Inc.™ Limited W arranty Hearth & Home T echnologies, Inc. (“HHT”) extends the following warranty for all Outdoor Lifestyles by HHT™ brand products (“Products”) that are purchased from an H ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 42

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 42 Limited W arranty  • Damages resulting from: (1) failure to install, operate, or maintain the Product in accordance with the installation instructions, operating instructions, and listing agent identification label furnished ...

  • Hearth and Home Technologies CASTLEWOOD 42 - page 43

    Outdoor Lifestyles by Hearth & Home T echnologies Inc. • 4070-300 Rev C • 4/1 1 43 – NOTES – G. Contact Information DO NOT DISCARD THIS MANUAL CAUTION • Important operating and maintenance instructions included. • Leave this manual with party responsible for use and operation. • Read, understand and follow these instructions for s ...

Производитель Hearth and Home Technologies Категория Outdoor Fireplace

Документы, которые мы получаем от производителя устройства Hearth and Home Technologies CASTLEWOOD 42 мы можем разделить на несколько групп. Это в частности:
- технические чертежи Hearth and Home Technologies
- инструкции обслуживания CASTLEWOOD 42
- паспорта изделия Hearth and Home Technologies
- информационные брошюры
- энергетические этикетки Hearth and Home Technologies CASTLEWOOD 42
Все из них важны, однако самую важную информацию с точки зрения пользователя мы найдем в инструкции обслуживания Hearth and Home Technologies CASTLEWOOD 42.

Группа документов, определяемая как инструкции обслуживания, делится также на более подробные типы, такие как: Инструкции монтажа Hearth and Home Technologies CASTLEWOOD 42, инструкции обслуживания, короткие инструкции или инструкции пользователя Hearth and Home Technologies CASTLEWOOD 42. В зависимости от потребностей, Вам необходимо поискать требуемый документ. На нашем сайте Вы можете просмотреть самую популярную инструкцию использования изделия Hearth and Home Technologies CASTLEWOOD 42.

Похожие инструкции обслуживания

Полная инструкция обслуживания устройства Hearth and Home Technologies CASTLEWOOD 42, как должна выглядеть?
Инструкция обслуживания, определяемая также как пособие пользователя, или просто "руководство" - это технический документ, цель которого заключается в использовании Hearth and Home Technologies CASTLEWOOD 42 пользователями. Инструкции пишет, как правило технический писатель, языком, доступным для всех пользователей Hearth and Home Technologies CASTLEWOOD 42.

Полная инструкция обслуживания Hearth and Home Technologies, должна заключать несколько основных элементов. Часть из них менее важная, как например: обложка / титульный лист или авторские страницы. Однако остальная часть, должна дать нам важную с точки зрения пользователя информацию.

1. Вступление и рекомендации, как пользоваться инструкцией Hearth and Home Technologies CASTLEWOOD 42 - В начале каждой инструкции, необходимо найти указания, как пользоваться данным пособием. Здесь должна находится информация, касающаяся местонахождения содержания Hearth and Home Technologies CASTLEWOOD 42, FAQ и самых распространенных проблем - то есть мест, которые чаще всего ищут пользователи в каждой инструкции обслуживания
2. Содержание - индекс всех советов, касающихся Hearth and Home Technologies CASTLEWOOD 42, которое найдем в данном документе
3. Советы по использованию основных функций устройства Hearth and Home Technologies CASTLEWOOD 42 - которые должны облегчить нам первые шаги во время использования Hearth and Home Technologies CASTLEWOOD 42
4. Troubleshooting - систематизированный ряд действия, который поможет нам диагностировать а в дальнейшем очередность решения важнейших проблем Hearth and Home Technologies CASTLEWOOD 42
5. FAQ - чаще всего задаваемые вопросы
6. Контактные данные Информация о том, где искать контактные данные производителя / сервисного центра Hearth and Home Technologies CASTLEWOOD 42 в данной стране, если самостоятельно не получится решить проблему.

У вас вопрос, касающийся Hearth and Home Technologies CASTLEWOOD 42?

Воспользуйтесь формуляром, находящимся ниже

Если с помощью найденной инструкции Вы не решили свою проблему с Hearth and Home Technologies CASTLEWOOD 42, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Hearth and Home Technologies CASTLEWOOD 42 со всей вероятностью он захочет поделиться методом ее решения.

Перепишите текст с картинки

Captcha
Новая картинка

Комментарии (0)