Deutsch dropdown-ico

Bedienungsanleitung Heatcraft Refrigeration Products H-IM-82C

26 Seiten 2.67 mb
Download

Zur Seite of 26

Summary
  • Heatcraft Refrigeration Products H-IM-82C - page 1

    H-IM-82C September 2010 P ar t No . 25001901 © 2010 Heatcraft Refrigeration Products, LL C Installa tion and Opera tions Manual PRO 3 T op Mount P ackaged Refrigera tion S y stem F or Outdoor Applications T able of C ontents 1. Owner's Installation Instructions Performance/Electrical Data Specications ...................................... ...

  • Heatcraft Refrigeration Products H-IM-82C - page 2

    2 Installation and Operations Manual 1. Owner's Operating Instructions P er formanc e / Elec trical Data © 2010 Heatcraft Refrigeration Products, LL C T AB L E 1 COOLER – A ir Defrost S ystems Model BTUH @ 95˚F V oltage MCA MOPD Unit Amps Evapora tor CFM Fig . Appro x. Net W eight Refrig. Charge R-404A T otal Heat of Rejection 35˚F Box T ...

  • Heatcraft Refrigeration Products H-IM-82C - page 3

    3 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 25" x 25" panel opening required f or evaporator section of medium cabinet sizes . * 21.5" with weather hood. Figur e A. Medium Cabinet Dimensions without weather hood (See refer ence on P age 2) Dimensional Diagrams Figur e B. Large C abinet without weather hood (See refer ...

  • Heatcraft Refrigeration Products H-IM-82C - page 4

    4 Installation and Operations Manual 1. Owner's Operating Instructions Some general rules for the evaporat or section placement which must be follow ed are: 1. Ensure that the structural integrity of the box can withstand the weight of the top mounted equipment. 2. The air pattern must cov er the entire room. 3. NEVER locate the evaporator sec ...

  • Heatcraft Refrigeration Products H-IM-82C - page 5

    5 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 1. Owner ’ s Operating Instructions Rigging Rigging holes are provided on all models . Caution should be exer cised when moving these units. T o prevent damage to the unit housing during rigging, cables or chains used must be held apart by spacer bars. The mounting platform or base shou ...

  • Heatcraft Refrigeration Products H-IM-82C - page 6

    6 Installation and Operations Manual 1. Owner's Operating Instructions The Outdoor comes standard with the following additional c omp onents: • Crankcase Heater • Drain Line Heater • Weather Hood • F an Cy cling (Pressure on 1 fan models, P ressure and Ambient on 2 fan models). Standard Installation P rocedur e PTT Mo dels F or outdoor ...

  • Heatcraft Refrigeration Products H-IM-82C - page 7

    7 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 1. Owner's Operating Instructions F igure 1. Curb placed on r oof of walk-in cooler . F igure 2. Roof membrane placed ov er curb. F igure 3. PT T unit placed on roof of walk -in color . (see rigging instructions). F igure 4. Weather hood installed after electrical ser vice connection ...

  • Heatcraft Refrigeration Products H-IM-82C - page 8

    8 Installation and Operations Manual Ser vice Inf ormation All units are designed for maximum durability , reliability and simplicity . comes to you r eady for operation, fully char ged and with all controls pr eset at the factor y . T he following inf ormation is provided as an aid in the even t that service is required. Maintenance The evaporator ...

  • Heatcraft Refrigeration Products H-IM-82C - page 9

    9 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Refri gera tion /Defros t Sequenc e of Opera tion The sequence of operation varies depending on the model that has been installed. The three basic models are Low T emperature, Medium T emperature , and H igh T emperature models. The par ticular model can be determined by the seventh digit ...

  • Heatcraft Refrigeration Products H-IM-82C - page 10

    10 Installation and Operations Manual Status Compressor C ondenser F ans Evapora tor F ans Defrost Heaters Notes O Display alternates “OFF” and Room T emperature O O O O  If unit shows “OFF” , depress the “^” button and hold for three seconds. On Automatic Defr ost on star t up O O O On If coil temperature is bel ...

  • Heatcraft Refrigeration Products H-IM-82C - page 11

    11 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Prog ramm ing the P JEZC C arel Electronic C ontrol ler Reprinted with permission from Carel . The Carel P JEZC control is a fully c ongurable electronic refrigeration controller . The T op Mount packaged refrigeration system uses the Carel controller on all three temperature designat ...

  • Heatcraft Refrigeration Products H-IM-82C - page 12

    12 Installation and Operations Manual Electrical C onnection s WARNINGS: The el ectric al con nect ions mus t only b e comp leted by a qual ied e lec tricia n; A power s uppl y othe r than th e ty pe spe cie d may seriou sly da mage th e system; Sepa rate as mu ch as po ssi ble the p robes a nd dig ital i nput sig nal cab les fro m the cab le ...

  • Heatcraft Refrigeration Products H-IM-82C - page 13

    13 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor K e ypads Preliminary C ongurations Once the electrical connections hav e been completed, simply power-up the c ontroller to make it operativ e. Heatcraft recommends that you check the parameters listed. F unc tions A vailable from Ke ypad ON AN D O F F Switching the instrument ON: pr ...

  • Heatcraft Refrigeration Products H-IM-82C - page 14

    14 Installation and Operations Manual W ARNI NG: Whe n rst c onnec ted , easy i s alrea dy on a nd read y to be used . The ins trume nt can b e switche d on from a sup er visor P C and via a n ex tern al conta ct (set ting A4 = 5). The latte r has prio rity over th e othe r mode s. SET POINT SETTING DESIRED TEMPERA TURE V ALUE The easy and ...

  • Heatcraft Refrigeration Products H-IM-82C - page 15

    15 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Alarm Code Buzzer and A larm Relay LED Alarm Description Reset Enable Alarm parameters in volv ed E0 active ON probe 1 error= contr ol automatic – E1 not active ON probe 2 error= defrost automatic d0= 0 / 1 / 4, F0= 1 E2 not active ON probe 3 error= condenser/ product automatic [A4=10] ...

  • Heatcraft Refrigeration Products H-IM-82C - page 16

    16 Installation and Operations Manual Description of the Main Signals and Alarms LED ashing The activation of the corresponding function is delayed by a timer , awaiting an external signal or disabled by another proc edure that is already in progr ess. e.g . if is a continuous c ycle in prog ress and a defrost is called, the latt er will remain ...

  • Heatcraft Refrigeration Products H-IM-82C - page 17

    17 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Modifying the Par ameters P ARAMETER NA VIGA TION The oper ating paramet ers, modiable using the keypad , are divided into t wo types: frequent (type F) and conguration (type C). Access to the latter is protected by password (default= 22) to prevent accidental or unauthorized modi? ...

  • Heatcraft Refrigeration Products H-IM-82C - page 18

    18 Installation and Operations Manual T roubleshooting The following table sho ws a number of situations that may oc cur on the various models. The most frequent causes and corr esponding checks are described: Problem Cause Checks the compressor does not start (signalled by the compressor LED ashing) • compressor delay set defrost post • dri ...

  • Heatcraft Refrigeration Products H-IM-82C - page 19

    19 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Set 1 - Low T emperature Models - L6 w/ -10° F Set Point Set 3 - High T emperature Models - H6 w/ 38° F Set Poin t Set 2 - Medium T emperature Models - M6 w/ 34° F Set Poin t Paramet er Description Min Max Default St Set point -30 30 -10 r1 Minimum set point value -50 303 -30 r2 Maxim ...

  • Heatcraft Refrigeration Products H-IM-82C - page 20

    20 Installation and Operations Manual 4. Ser vice Inf ormation T able 5. S ystem T roubleshooting Chart PROBLEM POSSIBLE CAUSES POSSIBLE C ORRECTIVE STEPS Compressor 1. Main switch open. 1. Close switch. will not run 2. Fuse blown. 2. Check elec trical circuits and motor winding for shorts or grounds. Investigate for possible overloading . Replace ...

  • Heatcraft Refrigeration Products H-IM-82C - page 21

    21 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 4. Ser vice Inf ormation Replacement P ar ts by Part Description Part Number High T emp Medium T emp Low T emp PTT050H6B^ PTT067H6B^ PTT076H6B^ PTT104H6B^ PTT104H6C^ PTT133H6B^ PTT133H6C^ PTT047M6B^ PTT063M6B^ PTT072M6B^ PTT099M6B^ PTT099M6C^ PTT128M6B^ PTT128M6C^ PTT021L6B^ PTT031L6B^ P ...

  • Heatcraft Refrigeration Products H-IM-82C - page 22

    22 Installation and Operations Manual Fr eezer - Electric Defrost Sy stems - Single Phase Diagram 1. Wiring Diagram for Sy stem, T ypic al Low T emp PFC L1 WN T1 GND 3 1 2 YELLOW CCH BLACK BLACK GRA Y BLUE WN WHITE GRA Y DLH WN YELLOW DL T WN YELLOW RED BLUE BLACK YELLOW YELLOW ORANGE YELLOW RED DH SW BLUE BLUE WHITE HL BROWN WN BLACK WN BLACK WN B ...

  • Heatcraft Refrigeration Products H-IM-82C - page 23

    23 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 5. Wiring Inf ormation Cooler - Electric Defrost Sy stems - Single Phase Diagram 2. Wiring Diagram for Sy stem, T ypic al Medium T emp PFC L1 WN T1 GND 3 1 2 YELLOW CCH BLACK BLACK GRA Y BLUE WN WHITE GRA Y DLH WN YELLOW DL T WN YELLOW RED BLUE BLACK YELLOW YELLOW ORANGE YELLOW RED DH SW ...

  • Heatcraft Refrigeration Products H-IM-82C - page 24

    24 Installation and Operations Manual Cooler - Air Defr ost Sy stems - Single Phase Diagram 3. Wiring Diagram for Sy stem, T ypic al High T emp TFC PFC L1 WN WN T1 GND 1 2 3 YELLOW CCH BLACK BLACK GRA Y BLUE WN WHITE GRA Y DLH WN YELLOW DL T WN 1 Defrost Wire not used on High T emp Models without electric defrost YELLOW BLUE BLACK YELLOW YELLOW ORA ...

  • Heatcraft Refrigeration Products H-IM-82C - page 25

    25 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 2175 W est P ark Place Blvd. • S tone Mountain, GA 30087 (800) 321-1881 • www.heatcr aftrpd.com Since product improv ement is a continuing eort, we reserve the right to make changes in specications without notice . W arranty Statement Heatc raft Refrigeratio n Products LL C war ...

  • Heatcraft Refrigeration Products H-IM-82C - page 26

    H-IM-82C-0910 | V ersion 000 Since product improv ement is a continuing eort, we reserve the right to make changes in specications without notice . Heatcr aft Refrigeration Products, LL C 2175 W est P ark Place Blvd., S tone Mountain, GA 30087 P: (800) 321-1881 • www.hea tcraftrpd.com The name behind the brands y ou trust. ...

Produzent Heatcraft Refrigeration Products Kategorie Refrigerator

Dokumente, die wir vom Produzenten des Geräts Heatcraft Refrigeration Products H-IM-82C erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Heatcraft Refrigeration Products
- Bedienungsanleitungen H-IM-82C
- Produktkarten Heatcraft Refrigeration Products
- Informationsbroschüren
- oder Energieetiketten Heatcraft Refrigeration Products H-IM-82C
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Heatcraft Refrigeration Products H-IM-82C.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Heatcraft Refrigeration Products H-IM-82C, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Heatcraft Refrigeration Products H-IM-82C. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Heatcraft Refrigeration Products H-IM-82C ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Heatcraft Refrigeration Products H-IM-82C, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Heatcraft Refrigeration Products H-IM-82C hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Heatcraft Refrigeration Products H-IM-82C verständlich ist.

Eine gänzliche Bedienungsanleitung von Heatcraft Refrigeration Products sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Heatcraft Refrigeration Products H-IM-82C bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Heatcraft Refrigeration Products H-IM-82C befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Heatcraft Refrigeration Products H-IM-82C, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Heatcraft Refrigeration Products H-IM-82C - die uns die ersten Schritte während der Nutzung von Heatcraft Refrigeration Products H-IM-82C erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Heatcraft Refrigeration Products H-IM-82C hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Heatcraft Refrigeration Products H-IM-82C im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Heatcraft Refrigeration Products H-IM-82C?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Heatcraft Refrigeration Products H-IM-82C nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Heatcraft Refrigeration Products H-IM-82C hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Captcha
Neues Bild

Kommentare (0)