Italiano dropdown-ico

Manuale per l’uso Heatcraft Refrigeration Products H-IM-82C

26 pagine 2.67 mb
Scarica

Vai alla pagina of 26

Summary
  • Heatcraft Refrigeration Products H-IM-82C - page 1

    H-IM-82C September 2010 P ar t No . 25001901 © 2010 Heatcraft Refrigeration Products, LL C Installa tion and Opera tions Manual PRO 3 T op Mount P ackaged Refrigera tion S y stem F or Outdoor Applications T able of C ontents 1. Owner's Installation Instructions Performance/Electrical Data Specications ...................................... ...

  • Heatcraft Refrigeration Products H-IM-82C - page 2

    2 Installation and Operations Manual 1. Owner's Operating Instructions P er formanc e / Elec trical Data © 2010 Heatcraft Refrigeration Products, LL C T AB L E 1 COOLER – A ir Defrost S ystems Model BTUH @ 95˚F V oltage MCA MOPD Unit Amps Evapora tor CFM Fig . Appro x. Net W eight Refrig. Charge R-404A T otal Heat of Rejection 35˚F Box T ...

  • Heatcraft Refrigeration Products H-IM-82C - page 3

    3 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 25" x 25" panel opening required f or evaporator section of medium cabinet sizes . * 21.5" with weather hood. Figur e A. Medium Cabinet Dimensions without weather hood (See refer ence on P age 2) Dimensional Diagrams Figur e B. Large C abinet without weather hood (See refer ...

  • Heatcraft Refrigeration Products H-IM-82C - page 4

    4 Installation and Operations Manual 1. Owner's Operating Instructions Some general rules for the evaporat or section placement which must be follow ed are: 1. Ensure that the structural integrity of the box can withstand the weight of the top mounted equipment. 2. The air pattern must cov er the entire room. 3. NEVER locate the evaporator sec ...

  • Heatcraft Refrigeration Products H-IM-82C - page 5

    5 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 1. Owner ’ s Operating Instructions Rigging Rigging holes are provided on all models . Caution should be exer cised when moving these units. T o prevent damage to the unit housing during rigging, cables or chains used must be held apart by spacer bars. The mounting platform or base shou ...

  • Heatcraft Refrigeration Products H-IM-82C - page 6

    6 Installation and Operations Manual 1. Owner's Operating Instructions The Outdoor comes standard with the following additional c omp onents: • Crankcase Heater • Drain Line Heater • Weather Hood • F an Cy cling (Pressure on 1 fan models, P ressure and Ambient on 2 fan models). Standard Installation P rocedur e PTT Mo dels F or outdoor ...

  • Heatcraft Refrigeration Products H-IM-82C - page 7

    7 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 1. Owner's Operating Instructions F igure 1. Curb placed on r oof of walk-in cooler . F igure 2. Roof membrane placed ov er curb. F igure 3. PT T unit placed on roof of walk -in color . (see rigging instructions). F igure 4. Weather hood installed after electrical ser vice connection ...

  • Heatcraft Refrigeration Products H-IM-82C - page 8

    8 Installation and Operations Manual Ser vice Inf ormation All units are designed for maximum durability , reliability and simplicity . comes to you r eady for operation, fully char ged and with all controls pr eset at the factor y . T he following inf ormation is provided as an aid in the even t that service is required. Maintenance The evaporator ...

  • Heatcraft Refrigeration Products H-IM-82C - page 9

    9 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Refri gera tion /Defros t Sequenc e of Opera tion The sequence of operation varies depending on the model that has been installed. The three basic models are Low T emperature, Medium T emperature , and H igh T emperature models. The par ticular model can be determined by the seventh digit ...

  • Heatcraft Refrigeration Products H-IM-82C - page 10

    10 Installation and Operations Manual Status Compressor C ondenser F ans Evapora tor F ans Defrost Heaters Notes O Display alternates “OFF” and Room T emperature O O O O  If unit shows “OFF” , depress the “^” button and hold for three seconds. On Automatic Defr ost on star t up O O O On If coil temperature is bel ...

  • Heatcraft Refrigeration Products H-IM-82C - page 11

    11 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Prog ramm ing the P JEZC C arel Electronic C ontrol ler Reprinted with permission from Carel . The Carel P JEZC control is a fully c ongurable electronic refrigeration controller . The T op Mount packaged refrigeration system uses the Carel controller on all three temperature designat ...

  • Heatcraft Refrigeration Products H-IM-82C - page 12

    12 Installation and Operations Manual Electrical C onnection s WARNINGS: The el ectric al con nect ions mus t only b e comp leted by a qual ied e lec tricia n; A power s uppl y othe r than th e ty pe spe cie d may seriou sly da mage th e system; Sepa rate as mu ch as po ssi ble the p robes a nd dig ital i nput sig nal cab les fro m the cab le ...

  • Heatcraft Refrigeration Products H-IM-82C - page 13

    13 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor K e ypads Preliminary C ongurations Once the electrical connections hav e been completed, simply power-up the c ontroller to make it operativ e. Heatcraft recommends that you check the parameters listed. F unc tions A vailable from Ke ypad ON AN D O F F Switching the instrument ON: pr ...

  • Heatcraft Refrigeration Products H-IM-82C - page 14

    14 Installation and Operations Manual W ARNI NG: Whe n rst c onnec ted , easy i s alrea dy on a nd read y to be used . The ins trume nt can b e switche d on from a sup er visor P C and via a n ex tern al conta ct (set ting A4 = 5). The latte r has prio rity over th e othe r mode s. SET POINT SETTING DESIRED TEMPERA TURE V ALUE The easy and ...

  • Heatcraft Refrigeration Products H-IM-82C - page 15

    15 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Alarm Code Buzzer and A larm Relay LED Alarm Description Reset Enable Alarm parameters in volv ed E0 active ON probe 1 error= contr ol automatic – E1 not active ON probe 2 error= defrost automatic d0= 0 / 1 / 4, F0= 1 E2 not active ON probe 3 error= condenser/ product automatic [A4=10] ...

  • Heatcraft Refrigeration Products H-IM-82C - page 16

    16 Installation and Operations Manual Description of the Main Signals and Alarms LED ashing The activation of the corresponding function is delayed by a timer , awaiting an external signal or disabled by another proc edure that is already in progr ess. e.g . if is a continuous c ycle in prog ress and a defrost is called, the latt er will remain ...

  • Heatcraft Refrigeration Products H-IM-82C - page 17

    17 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Modifying the Par ameters P ARAMETER NA VIGA TION The oper ating paramet ers, modiable using the keypad , are divided into t wo types: frequent (type F) and conguration (type C). Access to the latter is protected by password (default= 22) to prevent accidental or unauthorized modi? ...

  • Heatcraft Refrigeration Products H-IM-82C - page 18

    18 Installation and Operations Manual T roubleshooting The following table sho ws a number of situations that may oc cur on the various models. The most frequent causes and corr esponding checks are described: Problem Cause Checks the compressor does not start (signalled by the compressor LED ashing) • compressor delay set defrost post • dri ...

  • Heatcraft Refrigeration Products H-IM-82C - page 19

    19 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor Set 1 - Low T emperature Models - L6 w/ -10° F Set Point Set 3 - High T emperature Models - H6 w/ 38° F Set Poin t Set 2 - Medium T emperature Models - M6 w/ 34° F Set Poin t Paramet er Description Min Max Default St Set point -30 30 -10 r1 Minimum set point value -50 303 -30 r2 Maxim ...

  • Heatcraft Refrigeration Products H-IM-82C - page 20

    20 Installation and Operations Manual 4. Ser vice Inf ormation T able 5. S ystem T roubleshooting Chart PROBLEM POSSIBLE CAUSES POSSIBLE C ORRECTIVE STEPS Compressor 1. Main switch open. 1. Close switch. will not run 2. Fuse blown. 2. Check elec trical circuits and motor winding for shorts or grounds. Investigate for possible overloading . Replace ...

  • Heatcraft Refrigeration Products H-IM-82C - page 21

    21 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 4. Ser vice Inf ormation Replacement P ar ts by Part Description Part Number High T emp Medium T emp Low T emp PTT050H6B^ PTT067H6B^ PTT076H6B^ PTT104H6B^ PTT104H6C^ PTT133H6B^ PTT133H6C^ PTT047M6B^ PTT063M6B^ PTT072M6B^ PTT099M6B^ PTT099M6C^ PTT128M6B^ PTT128M6C^ PTT021L6B^ PTT031L6B^ P ...

  • Heatcraft Refrigeration Products H-IM-82C - page 22

    22 Installation and Operations Manual Fr eezer - Electric Defrost Sy stems - Single Phase Diagram 1. Wiring Diagram for Sy stem, T ypic al Low T emp PFC L1 WN T1 GND 3 1 2 YELLOW CCH BLACK BLACK GRA Y BLUE WN WHITE GRA Y DLH WN YELLOW DL T WN YELLOW RED BLUE BLACK YELLOW YELLOW ORANGE YELLOW RED DH SW BLUE BLUE WHITE HL BROWN WN BLACK WN BLACK WN B ...

  • Heatcraft Refrigeration Products H-IM-82C - page 23

    23 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 5. Wiring Inf ormation Cooler - Electric Defrost Sy stems - Single Phase Diagram 2. Wiring Diagram for Sy stem, T ypic al Medium T emp PFC L1 WN T1 GND 3 1 2 YELLOW CCH BLACK BLACK GRA Y BLUE WN WHITE GRA Y DLH WN YELLOW DL T WN YELLOW RED BLUE BLACK YELLOW YELLOW ORANGE YELLOW RED DH SW ...

  • Heatcraft Refrigeration Products H-IM-82C - page 24

    24 Installation and Operations Manual Cooler - Air Defr ost Sy stems - Single Phase Diagram 3. Wiring Diagram for Sy stem, T ypic al High T emp TFC PFC L1 WN WN T1 GND 1 2 3 YELLOW CCH BLACK BLACK GRA Y BLUE WN WHITE GRA Y DLH WN YELLOW DL T WN 1 Defrost Wire not used on High T emp Models without electric defrost YELLOW BLUE BLACK YELLOW YELLOW ORA ...

  • Heatcraft Refrigeration Products H-IM-82C - page 25

    25 PRO 3 T op Mount Packaged Refrigera tion Sy stem | Outdoor 2175 W est P ark Place Blvd. • S tone Mountain, GA 30087 (800) 321-1881 • www.heatcr aftrpd.com Since product improv ement is a continuing eort, we reserve the right to make changes in specications without notice . W arranty Statement Heatc raft Refrigeratio n Products LL C war ...

  • Heatcraft Refrigeration Products H-IM-82C - page 26

    H-IM-82C-0910 | V ersion 000 Since product improv ement is a continuing eort, we reserve the right to make changes in specications without notice . Heatcr aft Refrigeration Products, LL C 2175 W est P ark Place Blvd., S tone Mountain, GA 30087 P: (800) 321-1881 • www.hea tcraftrpd.com The name behind the brands y ou trust. ...

Fabbricante Heatcraft Refrigeration Products Categoria Refrigerator

I documenti che otteniamo dal fabbricante del dispositivoHeatcraft Refrigeration Products H-IM-82C possono essere suddivisi in diversi gruppi. Questi sono tra gli altri:
- disegni tecnici Heatcraft Refrigeration Products
- manuali per l’uso H-IM-82C
- schede prodotto Heatcraft Refrigeration Products
- opuscoli
- o etichette energetiche Heatcraft Refrigeration Products H-IM-82C
Tutti sono importanti, ma le informazioni più importanti dal punto di vista di utilizzo del dispositivo possono essere trovate nel manuale per l’uso Heatcraft Refrigeration Products H-IM-82C.

Un gruppo di documenti denominato manuali per l’uso, è anche suddiviso in tipi più specifici, come: Manuali di installazione Heatcraft Refrigeration Products H-IM-82C, manuali di manutenzione, brevi manuali o manuali utente Heatcraft Refrigeration Products H-IM-82C. A seconda delle esigenze, si dovrebbe cercare il documento necessario. Nel nostro sito web, puoi visualizzare il manuale più popolare per l'uso del prodotto Heatcraft Refrigeration Products H-IM-82C.

Manuali per l’uso simili

Manuale completo del dispositivo Heatcraft Refrigeration Products H-IM-82C, come deve essere?
Il manuale per l’uso, denominato anche istruzioni per l’uso, o semplicemente il manuale è un documento tecnico progettato per aiutare ad utilizzare Heatcraft Refrigeration Products H-IM-82C dagli utenti. I manuali sono di solito scritti da uno scrittore tecnico, ma in un linguaggio accessibile a tutti gli utenti Heatcraft Refrigeration Products H-IM-82C.

Il manuale per l’uso completo Heatcraft Refrigeration Products, dovrebbe includere vari elementi di base. Alcuni di loro sono meno importanti, come ad esempio: copertina / pagina del titolo o pagina di autore. Tuttavia, la parte rimanente, dovrebbe fornire informazioni importanti dal punto di vista dell'utente.

1. Introduzione e la guida su come utilizzare il manuale Heatcraft Refrigeration Products H-IM-82C - All'inizio di ogni manuale, dovremmo trovare indizi su come utilizzare il documento. Dovrebbe contenere informazioni sulla posizione dell’indice Heatcraft Refrigeration Products H-IM-82C, FAQ o i problemi più comuni : i punti che sono più spesso cercati dagli utenti di ogni manuale
2. Indice - elenco di tutti i suggerimenti per Heatcraft Refrigeration Products H-IM-82C che possono essere trovati nel documento corrente
3. Suggerimenti su come utilizzare le funzioni di base del dispositivo Heatcraft Refrigeration Products H-IM-82C - che ci dovrebbe aiutare nei primi passi durante l'uso Heatcraft Refrigeration Products H-IM-82C
4. Troubleshooting - sequenza sistematica delle attività che vi aiuterà a diagnosticare e, successivamente, risolvere i problemi più importanti del Heatcraft Refrigeration Products H-IM-82C
5. FAQ - domande più frequenti
6. Dettagli di contatto Informazioni su dove cercare il contatto con il fabbricante / servizio Heatcraft Refrigeration Products H-IM-82C in un dato paese, se il problema non può essere risolto da noi stessi.

Hai una domanda su Heatcraft Refrigeration Products H-IM-82C?

Utilizza il modulo sottostante

Se non hai risolto il problema con Heatcraft Refrigeration Products H-IM-82C con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con Heatcraft Refrigeration Products H-IM-82C è probabile che voglia condividere il modo di risolverlo.

Riscrivi il testo dall’immagine

Captcha
Nuova immagine

Commenti (0)