Deutsch dropdown-ico

Bedienungsanleitung Alto-Shaam ASC-4G

30 Seiten 2.3 mb
Download

Zur Seite of 30

Summary
  • Alto-Shaam ASC-4G - page 1

    W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 USA / C A N A D A FAX: 262.251.7067 • 800.329.8744 U . S . A . O N L Y www.alto-shaam.com M odel: ASC-4G Manual Control Convection Oven Gas • INSTALLATION • OPERATION • MAINTENANCE p r i n t e d i n u . s . a . MN-2866 ...

  • Alto-Shaam ASC-4G - page 2

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control Delivery .................................. 1 Unpacking ............................... 1 Safety Procedures and Precautions ............ 2 Installation Site Installation ......................... 3 Clearance Requirements .................. 3 Installation Requirements ....... ...

  • Alto-Shaam ASC-4G - page 3

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 1 DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims s ...

  • Alto-Shaam ASC-4G - page 4

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 2 CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard that can or will cause ...

  • Alto-Shaam ASC-4G - page 5

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 3 INSTALLATION DANGER IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIP ...

  • Alto-Shaam ASC-4G - page 6

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 4 INSTALLATION The oven must be mounted on the factory equipped oven legs or on an optional oven stand. Installation on a solid or concrete base that in any way restricts air flow may void the warranty. All clearances for a proper ventilation air supply must be maintaine ...

  • Alto-Shaam ASC-4G - page 7

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 5 GAS SUPPLY & INSTALLATION GAS PRESSURE CHART The gas valve and burner have been fitted according to the gas type specified on the identification name plate. DANGER CONNECTING TO THE WRONG GAS SUPPLY COULD RESULT IN FIRE OR AN EXPLOSION CAUSING SEVERE INJURY AND PRO ...

  • Alto-Shaam ASC-4G - page 8

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 6 GAS SUPPLY & INSTALLATION DANGER Installation, air adjustment and/or service work must be in accordance with all local codes and must be performed by a certifi ed service technician qualifi ed to work on gas appliances. GAS REQUIREMENTS The gas inlet is located a ...

  • Alto-Shaam ASC-4G - page 9

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 7 GAS SUPPLY & INSTALLATION GAS CONNECTION  FOR OVENS ON CASTERS The oven must be supplied with a flexible connector that complies with The Standard for Connectors for Movable Gas Appliances, ANSI Z21.69, CGA 6.16 and addenda Z21.69a (latest editions). A quick dis ...

  • Alto-Shaam ASC-4G - page 10

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 8 INSTALLATION This appliance is equipped with a three-prong grounding plug. For your protection against shock hazard this appliance should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. Plug ...

  • Alto-Shaam ASC-4G - page 11

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 9 INSTALLATION VENTILATION VENTILATION HOODS Proper venting along with a sufficient quantity of make-up air is essential for proper oven operation. A mechanically driven, canopy exhaust hood is the preferred method of ventilation and must conform to local codes along wit ...

  • Alto-Shaam ASC-4G - page 12

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 10 INSTALLATION CAUTION TO PREVENT PERSONAL INJURY, USE CAUTION WHEN MOVING OR LEVELING THIS APPLIANCE. STACKING KIT (5005783) STACKING INSTRUCTIONS A) Remove side panels. B) Knock out the mounting holes on top of the intended bottom oven. C) After legs or casters have b ...

  • Alto-Shaam ASC-4G - page 13

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 11 INSTALLATION STACKING, GAS PLUMBING & FLUE INTERCONNECT (5003788) 7 8 1 2 3 4 5 6 Rev 01/13 ASSEMBLY INSTRUCTIONS FIRST: Assemble plumbing items 2 thru 6 as shown NEXT: Assemble items 7, 8, & 1 as shown ITEM DESCRIPTION PART NO. QTY 1 SCREW, #10 SMS .5LG SC-26 ...

  • Alto-Shaam ASC-4G - page 14

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 12 INSTALLATION 8 1 1 7 3 4 2 9 1 2 34-5/16" (876mm) 5 6 2 38" (956mm) OVEN STAND ASSEMBLY ITEM DESCRIPTION PART NO. QTY 1 LEG SUPPORT ASSEMBLY 5003488 2 2 CHANNEL, SUPPORT 1004459 2 3 LEG LG-22185 4 *CASTERS, RIGID CS-25674 2 *CASTERS, SWIVEL W/BRAKE CS-25675 ...

  • Alto-Shaam ASC-4G - page 15

    OPERATING INSTRUCTIONS MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 13 PRODUCTPAN CAPACITY 72 lb (33 kg) maximum • 45 qts (43 liters) Twelve (12): 18" x 26" x 1" full-size sheet pans 6 chrome plated wire shelves with 2 removable side racks and 12 shelf positions spaced at 1-3/4" (43mm) FACTOR ...

  • Alto-Shaam ASC-4G - page 16

    OPERATING INSTRUCTIONS MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 14 START-UP OPERATION BEFORE INITIAL USE: Interior oven surfaces must be heated to remove surface oils and the accompanying odors produced during the first use of the oven. 1. Wipe all wire shelves, side racks and the full oven interior with a clea ...

  • Alto-Shaam ASC-4G - page 17

    OPERATING INSTRUCTIONS MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 15 a c b e f d NOTE: Under normal operating conditions, the burner will ignite within four (4) seconds. If the burner does not ignite within fifteen (15) seconds, usually as a result of insufficient gas flow or air trapped in the gas line, the igni ...

  • Alto-Shaam ASC-4G - page 18

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 16 CHEF OPERATING TIPS The Alto-Shaam convection oven will provide the best results and longest possible service with the utilization of the following suggestions and guidelines. NOTE : Moisture will escape around the doors when baking products with a heavy moisture cont ...

  • Alto-Shaam ASC-4G - page 19

    CARE AND CLEANING MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 17 PROTECTING STAINLESS STEEL SURFACES It is important to guard against corrosion in the care of stainless steel surfaces. Harsh, corrosive, or inappropriate chemicals can completely destroy the protective surface layer of stainless steel. Abrasive pads ...

  • Alto-Shaam ASC-4G - page 20

    CARE AND CLEANING MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 18 CLEAN THE OVEN ON A DAILY BASIS 1. After the oven has cooled, remove all detachable items such as wire shelves, side racks, and drip pan. Clean these items separately. 2. Remove any food scraps from shelves, shelf supports, and blower fan wheel. Conv ...

  • Alto-Shaam ASC-4G - page 21

    CARE AND CLEANING MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 19 TROUBLESHOOTING GUIDE TROUBLE POSSIBLE CAUSE REMEDY Oven has no power • Insufficient power supply • Defective power cord or plug • Defective power switch. • Loose electrical connection • Check power source. • Check and replace if necessar ...

  • Alto-Shaam ASC-4G - page 22

    SERVICE MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 20 Part numbers and drawings are subject to change without notice. 2 3 4 5 7 6 20 17 19 16 9 10 11 12 14 13 15 8 21 22 18 1 ITEM DESCRIPTION PART NO. QTY ITEM DESCRIPTION PART NO. QTY 1 LATCH LT-26976 2 14 SWITCH, FAN, HI/LO SW-34101 1 2 DOOR ASSEMBLY, LH WINDOW ...

  • Alto-Shaam ASC-4G - page 23

    SERVICE MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 21 Part numbers and drawings are subject to change without notice. DANGER Installation, air adjustment and/or service work must be in accordance with all local codes and must be performed by a certifi ed service technician qualifi ed to work on gas appliances. ...

  • Alto-Shaam ASC-4G - page 24

    SERVICE MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 22 Part numbers and drawings are subject to change without notice. ITEM DESCRIPTION PART NO. 5011301/ QTY 5016619/ QTY 1 SCREW , 10-32 X 1/2, NF PHIL, FLA T SC-23670 8 8 2 ROLLER LA TCH WITH STRIKE L T -26976 2 2 3 CHAIN, MASTER LINK CH-26622 4 4 4 CHAIN, DOOR DR ...

  • Alto-Shaam ASC-4G - page 25

    SERVICE MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 23 Part numbers and drawings are subject to change without notice. DOOR MECHANISM A A 9 8 7 1 2 3 4 5 6 1 B B 2 1 6 6 7 5 ITEM DESCRIPTION PART NO. QTY 1 CHAIN, MASTER LINK CH-26622 4 2 LINKAGE ASSEMBL Y , SHORT 5003667 2 3 NUT , 10-32 UNF HEX MS, 18-8 SST NU-221 ...

  • Alto-Shaam ASC-4G - page 26

    SERVICE MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 24 Part numbers and drawings are subject to change without notice. DOOR HARDWARE C 5 8 6 7 6 5 4 3 2 1 9 1 1 C 3 2 1 10 11 ITEM DESCRIPTION PART NO. QTY 1 BUSHING BU-26433 4 2 SP ACER, DOOR 1005449 2 3 SP ACER, DOOR SP-26442 2 4 DOOR ASSEMBL Y , LH WINDOW DR-2785 ...

  • Alto-Shaam ASC-4G - page 27

    SERVICE MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 25 Part numbers and drawings are subject to change without notice. LEG ASSEMBLY (5003784) 1 2 3 4 6 5 7 ITEM DESCRIPTION PART NO. QTY 1 SUPPORT, LEG, SIDE, ASSEMBLY 5009564 2 2 SUPPORT, LEG, REAR, ASSEMBLY 5009565 2 3 LEG ASSEMBLY, 25" LG-27829 4 4 NUT, 1/4- ...

  • Alto-Shaam ASC-4G - page 28

    SERVICE MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 26 Part numbers and drawings are subject to change without notice. PARTS LIST P/N DESCRIPTION QTY EXTERIOR 1006623 PANEL, OUTER, SIDE/TOP ....................................... 1 1006671 PANEL, OUTER, RH ................................................... 1 1006 ...

  • Alto-Shaam ASC-4G - page 29

    MN-28664 • Rev 2 (06/13) • ASC-4G Gas Convection Oven - Manual Control • 27 ...

  • Alto-Shaam ASC-4G - page 30

    TRANSPORTATION DAMAGE and CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...

Produzent Alto-Shaam Kategorie Convection Oven

Dokumente, die wir vom Produzenten des Geräts Alto-Shaam ASC-4G erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Alto-Shaam
- Bedienungsanleitungen ASC-4G
- Produktkarten Alto-Shaam
- Informationsbroschüren
- oder Energieetiketten Alto-Shaam ASC-4G
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Alto-Shaam ASC-4G.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Alto-Shaam ASC-4G, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Alto-Shaam ASC-4G. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Alto-Shaam ASC-4G ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Alto-Shaam ASC-4G, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Alto-Shaam ASC-4G hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Alto-Shaam ASC-4G verständlich ist.

Eine gänzliche Bedienungsanleitung von Alto-Shaam sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Alto-Shaam ASC-4G bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Alto-Shaam ASC-4G befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Alto-Shaam ASC-4G, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Alto-Shaam ASC-4G - die uns die ersten Schritte während der Nutzung von Alto-Shaam ASC-4G erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Alto-Shaam ASC-4G hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Alto-Shaam ASC-4G im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Alto-Shaam ASC-4G?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Alto-Shaam ASC-4G nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Alto-Shaam ASC-4G hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Captcha
Neues Bild

Kommentare (0)