Bedienungsanleitung Follett 00119628R01

24 Seiten 0.49 mb
Download

Zur Seite of 24

Summary
  • Follett 00119628R01 - page 1

    Installation, Operation and Ser vice Manual VU300K Series Integral Cold Carbonation Ice and Be verage Dispenser s 00119628R01 801 Church Lane • PO Box D, Easton, PA 18044, USA Toll free (800) 523-9361 • (610) 252-7301 Fax (610) 250-0696 • www.follettice.com U L ® Following installation, please f orward this manual to the appropriate operatio ...

  • Follett 00119628R01 - page 2

    2 ...

  • Follett 00119628R01 - page 3

    Welcome to Follett Corporation Important cautions Specifications Installation Installing dispenser in counter Field wiring diagrams Connecting beverage lines Installing optional icemaker Operation How the dispenser works Cleaning Service Dispense chute cover removal Auger motor assembly removal Gate assembly removal Auger and auger tube removal Dis ...

  • Follett 00119628R01 - page 4

    W elcome to Follett Follett ice dispensers enjoy a well-deserved reputation for excellent performance, long-term reliability and outstanding after-the-sale support. To ensure that this dispenser delivers that same degree of service, we ask that you take a moment to review this manual before beginning the installation of the dispenser. Should you ha ...

  • Follett 00119628R01 - page 5

    5 Specifications Electrical Each dispenser requires a separate circuit with electrical disconnect within 10 ft (6m). Equipment ground required. Standard electrical – 115V, 60Hz, 1 phase. Maximum dispenser fuse – 20 amps, Maximum icemaker fuse – 20 amps each. Cord and plug provided with each dispenser. Icemaker Dispenser amperage amperage VU30 ...

  • Follett 00119628R01 - page 6

    Front Vie w (shown with two Chewblet FC400A auto-fill icemaker kits) 24.62" (626mm) 30" (762mm) beverage lines enter through bottom 9" (229mm) 9" (229mm) 15" (381mm) 10" (254mm) 2.5" (64mm) 7" (178mm) 3" (77mm) 2" (51mm) 32.375" (823mm) 3/4" (19mm) drain 1" (26mm) drains 8.5" (21 ...

  • Follett 00119628R01 - page 7

    Installation Installing dispenser in counter Note: All dispensers must be supported from below with supplied 4" – 6" (102 – 153mm) adjustable leg accessory, or equivalent. Do not hang dispenser on flange. All dispensers must be installed level in both directions to ensure proper operation. 1. Check that dispenser location meets all re ...

  • Follett 00119628R01 - page 8

    8 Field wiring diagrams Note: Field wiring diagrams are intended to aid electricians or technicians in understanding how equipment works. All field wiring must be installed in accordance with all local and NEC codes. Connecting bevera ge lines 1. Connect syrup and water lines. Non-carbonated water line will be labeled “water”. Syrup lines are n ...

  • Follett 00119628R01 - page 9

    Installing optional auto-fill icemaker kit(s) Correct installation of remote icemaker(s) is critical to proper performance of icemaker. Refer to installation manual packed with icemaker for important details on ice transport tube run, ventilation requirements and other installation requirements. Failure to comply with instructions may void warranty ...

  • Follett 00119628R01 - page 10

    Operation How the dispenser w orks Follett’s dispensers may be fed by Follett remote icemakers or manually loaded (using ice from another source). In all models, ice is stored below the counter in the dispenser storage area. When the dispense lever or button is pushed, the dispense motors are activated. This causes the wheel assembly in the stora ...

  • Follett 00119628R01 - page 11

    Cleaning Using solutions below, clean and sanitize storage area and beverage lines before starting unit and on a routine basis as noted below. Note: Always disconnect power before cleaning dispenser. Do not run plastic parts through a dishwasher. Solution A: Combine 1 oz (250ml) bleach with 2 gal (8L) hot water or use Ecolab Mikro-chlor Cleaner per ...

  • Follett 00119628R01 - page 12

    Recommended daily dispenser cleaning 1. Remove all debris from drain pan. 2. Pour 1 gallon (4L) hot water into drain pan to keep drain lines clear. Recommended weekly dispenser cleaning 1. Remove drain pan and grille and wash with Solution A. Rinse thoroughly. 2. Remove nozzles and diffusers from valves, soak for at least 10 minutes in cleaning Sol ...

  • Follett 00119628R01 - page 13

    Service Dispense chute cover removal 1. Remove top cover. 2. Remove two screws from top cover and pull cover forward and down to remove. 3. On push button units, disconnect plug on harness. Auger motor assembly removal 1. Remove drain pan. 2. Remove thumbscrews from splash guard and remove. 3. Remove thumbscrews from splash panel; lift and pull for ...

  • Follett 00119628R01 - page 14

    Wiring diagram VU300K series YELLOW YELLOW M3 WHITE BATHPUMP MOTOR (35 MIN ON DELAY) DISPENSE SWITCH LID PL1-1 L1 SWITCH POWER BLACK POWER BLACK TOP LID SWITCH NO C BLACK RED RED 24V RED PL6-1 C M2 MTR PURPLE DISPENSE PL1-2 DRAIN PAN SWITCH C GRAY NO ORANGE 7 4 R1 READY AUGER MOTOR RED BLK WHEEL MOTOR PURPLE PL2-1 RED PL3-2 M1 BLUE PL2-2 WHT PL3-3 ...

  • Follett 00119628R01 - page 15

    Symptom Ice does not dispense. • Auger motor does not run • Wheel motor does not run Ice does not dispense. • Auger motor runs • Wheel motor runs • Gate does not open Ice does not dispense. • Auger motor does not run • Wheel motor runs Ice does not dispense. • Auger motor runs • Wheel motor does not run Warm drinks or soda foaming ...

  • Follett 00119628R01 - page 16

    Symptom Carbonator pump not turning on. Carbonator pump is not turning off. Carbonation system is not carbonating. Carbonation system is producing excessively carbonated beverages. Possible cause 1. Loose connection. 2. Electrode connections on carbonator tank are satisfied. 3. Carbonator pump or level control board is defective. 1. Loose connectio ...

  • Follett 00119628R01 - page 17

    Condition Pump Solenoids Auger Wheel Beverage valves Top lid off OFF ON OFF OFF ON Drain pan off ON ON OFF OFF OFF On/off switch in OFF position OFF OFF OFF OFF OFF Beverage switch in OFF position ON ON ON ON OFF 17 Operational Status The chart below shows the operational status of various parts when certain switches are turned off or accessories a ...

  • Follett 00119628R01 - page 18

    Replacement par ts Reference # Description Part # 1 Lid, with graphics, single-sided 00126805 2 Graphics, “Follett” 00116780 3 Access panel, tower, single-sided 00108407 Not shown Cover, ice opening (below drain pan) 00143685 Not shown Drain pan assembly and grille 00126862 4 Drain pan, plastic 00108829 Not shown Switch, drain pan safety 502475 ...

  • Follett 00119628R01 - page 19

    1 2 8 10 3 4 9 11 12 13 14 countertop section 4 Top View lower ring Top View auger tube seal Front View auger tube 6 Reference # Description Part # 1 Motor, auger (includes capacitor) 00115212 2 Bracket, auger motor hold-down 502047 Not shown Bracket, auger motor stabilizer 00108498 Not shown Seal, shaft, auger motor 501977 3 Auger 501980 4 Auger t ...

  • Follett 00119628R01 - page 20

    VU300 dispense assembly Side View VU300 dispense assembly Top View 2 1 1 4 3 3 7 Reference # Description Part # 1 Gate, dispense 501955 2 Linkage pin, gate/solenoid 502096 3 Pin, quick release, 3" (77mm), gate and lever 501949 4 Chute, ice 501952 5 Solenoid 501961 Not shown Boot, solenoid 502098 6 Dispense mechanism assembly 501948 7 Spring, d ...

  • Follett 00119628R01 - page 21

    Reference # Description Part # 1 Pump, waterbath (includes mounting plate and elbow) 00111476 2 Elbow, overflow 1" (26mm) x 3/4 MPT 502465 Not shown Elbow, clean out, drain, 3/8" (10mm) x 3/8 MPT 502466 3 Syrup coil 00125864 4 QuickCARB foam pack assembly 00127043 5 Foam pack assembly, 10 valve 00127068 Not shown Foam pack assembly, 8 val ...

  • Follett 00119628R01 - page 22

    Beverage bath control board detail Cold carbonation level control board detail 24V AC (YEL) NO NC 24V AC (RED) C L2 (WHT) PUMP LID ready MTR COLD WARM BEV . BATH INDICA TOR COM N.O. 0 0 0 II I (orange) INPUT VOL T AGE N.O. LOW COM HIGH N.C. COM Reference # Description Part # 1 Transformer, 24V 502058 2 Relay, dispense 501826 3 Strips, terminal 5024 ...

  • Follett 00119628R01 - page 23

    23 ...

  • Follett 00119628R01 - page 24

    00119628R01 02/06 801 Church Lane • PO Box D, Easton, PA 18044, USA Toll free (800) 523-9361 • (610) 252-7301 Fax (610) 250-0696 • www.follettice.com U L ® U L ® C ...

Produzent Follett Kategorie Beverage Dispenser

Dokumente, die wir vom Produzenten des Geräts Follett 00119628R01 erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Follett
- Bedienungsanleitungen 00119628R01
- Produktkarten Follett
- Informationsbroschüren
- oder Energieetiketten Follett 00119628R01
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Follett 00119628R01.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Follett 00119628R01, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Follett 00119628R01. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Follett 00119628R01 ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Follett 00119628R01, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Follett 00119628R01 hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Follett 00119628R01 verständlich ist.

Eine gänzliche Bedienungsanleitung von Follett sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Follett 00119628R01 bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Follett 00119628R01 befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Follett 00119628R01, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Follett 00119628R01 - die uns die ersten Schritte während der Nutzung von Follett 00119628R01 erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Follett 00119628R01 hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Follett 00119628R01 im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Follett 00119628R01?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Follett 00119628R01 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Follett 00119628R01 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)