Follett 00119628R01の取扱説明書

24ページ 0.49 mb
ダウンロード

ページに移動 of 24

Summary
  • Follett 00119628R01 - page 1

    Installation, Operation and Ser vice Manual VU300K Series Integral Cold Carbonation Ice and Be verage Dispenser s 00119628R01 801 Church Lane • PO Box D, Easton, PA 18044, USA Toll free (800) 523-9361 • (610) 252-7301 Fax (610) 250-0696 • www.follettice.com U L ® Following installation, please f orward this manual to the appropriate operatio ...

  • Follett 00119628R01 - page 2

    2 ...

  • Follett 00119628R01 - page 3

    Welcome to Follett Corporation Important cautions Specifications Installation Installing dispenser in counter Field wiring diagrams Connecting beverage lines Installing optional icemaker Operation How the dispenser works Cleaning Service Dispense chute cover removal Auger motor assembly removal Gate assembly removal Auger and auger tube removal Dis ...

  • Follett 00119628R01 - page 4

    W elcome to Follett Follett ice dispensers enjoy a well-deserved reputation for excellent performance, long-term reliability and outstanding after-the-sale support. To ensure that this dispenser delivers that same degree of service, we ask that you take a moment to review this manual before beginning the installation of the dispenser. Should you ha ...

  • Follett 00119628R01 - page 5

    5 Specifications Electrical Each dispenser requires a separate circuit with electrical disconnect within 10 ft (6m). Equipment ground required. Standard electrical – 115V, 60Hz, 1 phase. Maximum dispenser fuse – 20 amps, Maximum icemaker fuse – 20 amps each. Cord and plug provided with each dispenser. Icemaker Dispenser amperage amperage VU30 ...

  • Follett 00119628R01 - page 6

    Front Vie w (shown with two Chewblet FC400A auto-fill icemaker kits) 24.62" (626mm) 30" (762mm) beverage lines enter through bottom 9" (229mm) 9" (229mm) 15" (381mm) 10" (254mm) 2.5" (64mm) 7" (178mm) 3" (77mm) 2" (51mm) 32.375" (823mm) 3/4" (19mm) drain 1" (26mm) drains 8.5" (21 ...

  • Follett 00119628R01 - page 7

    Installation Installing dispenser in counter Note: All dispensers must be supported from below with supplied 4" – 6" (102 – 153mm) adjustable leg accessory, or equivalent. Do not hang dispenser on flange. All dispensers must be installed level in both directions to ensure proper operation. 1. Check that dispenser location meets all re ...

  • Follett 00119628R01 - page 8

    8 Field wiring diagrams Note: Field wiring diagrams are intended to aid electricians or technicians in understanding how equipment works. All field wiring must be installed in accordance with all local and NEC codes. Connecting bevera ge lines 1. Connect syrup and water lines. Non-carbonated water line will be labeled “water”. Syrup lines are n ...

  • Follett 00119628R01 - page 9

    Installing optional auto-fill icemaker kit(s) Correct installation of remote icemaker(s) is critical to proper performance of icemaker. Refer to installation manual packed with icemaker for important details on ice transport tube run, ventilation requirements and other installation requirements. Failure to comply with instructions may void warranty ...

  • Follett 00119628R01 - page 10

    Operation How the dispenser w orks Follett’s dispensers may be fed by Follett remote icemakers or manually loaded (using ice from another source). In all models, ice is stored below the counter in the dispenser storage area. When the dispense lever or button is pushed, the dispense motors are activated. This causes the wheel assembly in the stora ...

  • Follett 00119628R01 - page 11

    Cleaning Using solutions below, clean and sanitize storage area and beverage lines before starting unit and on a routine basis as noted below. Note: Always disconnect power before cleaning dispenser. Do not run plastic parts through a dishwasher. Solution A: Combine 1 oz (250ml) bleach with 2 gal (8L) hot water or use Ecolab Mikro-chlor Cleaner per ...

  • Follett 00119628R01 - page 12

    Recommended daily dispenser cleaning 1. Remove all debris from drain pan. 2. Pour 1 gallon (4L) hot water into drain pan to keep drain lines clear. Recommended weekly dispenser cleaning 1. Remove drain pan and grille and wash with Solution A. Rinse thoroughly. 2. Remove nozzles and diffusers from valves, soak for at least 10 minutes in cleaning Sol ...

  • Follett 00119628R01 - page 13

    Service Dispense chute cover removal 1. Remove top cover. 2. Remove two screws from top cover and pull cover forward and down to remove. 3. On push button units, disconnect plug on harness. Auger motor assembly removal 1. Remove drain pan. 2. Remove thumbscrews from splash guard and remove. 3. Remove thumbscrews from splash panel; lift and pull for ...

  • Follett 00119628R01 - page 14

    Wiring diagram VU300K series YELLOW YELLOW M3 WHITE BATHPUMP MOTOR (35 MIN ON DELAY) DISPENSE SWITCH LID PL1-1 L1 SWITCH POWER BLACK POWER BLACK TOP LID SWITCH NO C BLACK RED RED 24V RED PL6-1 C M2 MTR PURPLE DISPENSE PL1-2 DRAIN PAN SWITCH C GRAY NO ORANGE 7 4 R1 READY AUGER MOTOR RED BLK WHEEL MOTOR PURPLE PL2-1 RED PL3-2 M1 BLUE PL2-2 WHT PL3-3 ...

  • Follett 00119628R01 - page 15

    Symptom Ice does not dispense. • Auger motor does not run • Wheel motor does not run Ice does not dispense. • Auger motor runs • Wheel motor runs • Gate does not open Ice does not dispense. • Auger motor does not run • Wheel motor runs Ice does not dispense. • Auger motor runs • Wheel motor does not run Warm drinks or soda foaming ...

  • Follett 00119628R01 - page 16

    Symptom Carbonator pump not turning on. Carbonator pump is not turning off. Carbonation system is not carbonating. Carbonation system is producing excessively carbonated beverages. Possible cause 1. Loose connection. 2. Electrode connections on carbonator tank are satisfied. 3. Carbonator pump or level control board is defective. 1. Loose connectio ...

  • Follett 00119628R01 - page 17

    Condition Pump Solenoids Auger Wheel Beverage valves Top lid off OFF ON OFF OFF ON Drain pan off ON ON OFF OFF OFF On/off switch in OFF position OFF OFF OFF OFF OFF Beverage switch in OFF position ON ON ON ON OFF 17 Operational Status The chart below shows the operational status of various parts when certain switches are turned off or accessories a ...

  • Follett 00119628R01 - page 18

    Replacement par ts Reference # Description Part # 1 Lid, with graphics, single-sided 00126805 2 Graphics, “Follett” 00116780 3 Access panel, tower, single-sided 00108407 Not shown Cover, ice opening (below drain pan) 00143685 Not shown Drain pan assembly and grille 00126862 4 Drain pan, plastic 00108829 Not shown Switch, drain pan safety 502475 ...

  • Follett 00119628R01 - page 19

    1 2 8 10 3 4 9 11 12 13 14 countertop section 4 Top View lower ring Top View auger tube seal Front View auger tube 6 Reference # Description Part # 1 Motor, auger (includes capacitor) 00115212 2 Bracket, auger motor hold-down 502047 Not shown Bracket, auger motor stabilizer 00108498 Not shown Seal, shaft, auger motor 501977 3 Auger 501980 4 Auger t ...

  • Follett 00119628R01 - page 20

    VU300 dispense assembly Side View VU300 dispense assembly Top View 2 1 1 4 3 3 7 Reference # Description Part # 1 Gate, dispense 501955 2 Linkage pin, gate/solenoid 502096 3 Pin, quick release, 3" (77mm), gate and lever 501949 4 Chute, ice 501952 5 Solenoid 501961 Not shown Boot, solenoid 502098 6 Dispense mechanism assembly 501948 7 Spring, d ...

  • Follett 00119628R01 - page 21

    Reference # Description Part # 1 Pump, waterbath (includes mounting plate and elbow) 00111476 2 Elbow, overflow 1" (26mm) x 3/4 MPT 502465 Not shown Elbow, clean out, drain, 3/8" (10mm) x 3/8 MPT 502466 3 Syrup coil 00125864 4 QuickCARB foam pack assembly 00127043 5 Foam pack assembly, 10 valve 00127068 Not shown Foam pack assembly, 8 val ...

  • Follett 00119628R01 - page 22

    Beverage bath control board detail Cold carbonation level control board detail 24V AC (YEL) NO NC 24V AC (RED) C L2 (WHT) PUMP LID ready MTR COLD WARM BEV . BATH INDICA TOR COM N.O. 0 0 0 II I (orange) INPUT VOL T AGE N.O. LOW COM HIGH N.C. COM Reference # Description Part # 1 Transformer, 24V 502058 2 Relay, dispense 501826 3 Strips, terminal 5024 ...

  • Follett 00119628R01 - page 23

    23 ...

  • Follett 00119628R01 - page 24

    00119628R01 02/06 801 Church Lane • PO Box D, Easton, PA 18044, USA Toll free (800) 523-9361 • (610) 252-7301 Fax (610) 250-0696 • www.follettice.com U L ® U L ® C ...

メーカー Follett カテゴリー Beverage Dispenser

Follett 00119628R01のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 00119628R01の取扱説明書
- Follettの製品カード
- パンフレット
- またはFollett 00119628R01の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Follett 00119628R01の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Follett 00119628R01の取り付け説明書、サービスマニュアル、簡易説明書、またはFollett 00119628R01のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Follett 00119628R01の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Follett 00119628R01デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがFollett 00119628R01を使用するのを助ける技術的文書のことです。説明書は通常、全てのFollett 00119628R01ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Follettの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Follett 00119628R01の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははFollett 00119628R01の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Follett 00119628R01に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Follett 00119628R01デバイスの基本機能を使うにあたってのヒント。 Follett 00119628R01のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Follett 00119628R01に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるFollett 00119628R01のメーカー/サービスへの連絡先に関する情報。

Follett 00119628R01についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもFollett 00119628R01の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがFollett 00119628R01で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)