Follett U155の取扱説明書

24ページ 0.46 mb
ダウンロード

ページに移動 of 24

Summary
  • Follett U155 - page 1

    Installation, Operation and Service Manual U155 Series Ice and Be verage Dispenser s Cool Ideas For Ice Management 207896 10/00 801 Church Lane • PO Box D, Easton, PA 18044 Toll-free (800) 523-9361 • (888) 2-FOLLETT (610) 252-7301 • FAX (610) 250-0696 • www.follettice.com ® U L ® Following installation, please f orward this manual to the ...

  • Follett U155 - page 2

    Contents Before y ou begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Installation procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Installing U155 dispenser ...

  • Follett U155 - page 3

    W elcome to Follett Follett ice dispensers enjoy a well-deserved reputation for excellent performance, long-term reliability and outstanding after-the-sale support. To ensure that this dispenser delivers that same degree of service, we ask that you take a moment to review this manual before beginning the installation of the dispenser. Should you ha ...

  • Follett U155 - page 4

    Plumbing Dispenser - 3/4" PVC slip joint for hopper drain 3/4" PVC pipe nipple for beverage drain pan 3/4" PVC pipe nipple for bath overflow Note : Drains should be hard piped and insulated. Maintain at least 1/4" per foot (6mm per 30.4cm run) slope on drain line run. Icemaker - Refer to Icemaker Installation Manual packed with ...

  • Follett U155 - page 5

    X Electric power source Standard electrical - 115V, 1 Ph, 60 Hz, max. fuse size 15 amps BL W GND GRN GND GRN BL W LEGEND Wirenut field connections X Equipment ground BL - black W - white GRN - green Left junction box Field wiring diagram is intended to aid electrician or technician in understanding how equipment works. All field wiring must be inst ...

  • Follett U155 - page 6

    Installation Installing U155 dispenser in counter 1. Check that dispenser location meets all requirements in this manual and cut counter as shown. (NOTE: Different cut-outs for 8 and 10 valve units!) 2. Block up area below counter cut-out to support dispenser when lowered into place. 3. For automatic load dispensers, disconnect ice transport tube f ...

  • Follett U155 - page 7

    Installing remote icemaker (automatic load units only) 1. Position icemaker in desired location. 2. Push one end of ice transport tube(s) through hole(s) provided in side of dispenser. 3. Route tube into ice tube bracket inside dispenser and engage bracket tabs in holes located in end of ice transport tube(s). (See drawings below.) 4. Proceed with ...

  • Follett U155 - page 8

    Connecting bevera ge lines 1. Connect syrup and water lines, following drawings for appropriate model U155 dispenser. Non-carbonated water line will be labeled “ water ” . 2. Clean and sanitize beverage lines in accordance with cleaning instructions that follow. T o start-up and operate dispenser 1. Follow detailed cleaning instructions in serv ...

  • Follett U155 - page 9

    8 User inf ormation How the dispenser w orks Follett's U155 Series ice dispensers are available in manual load configurations (using ice from another source) or automatic load configurations, fed from one or two Follett 400 lb (181kg)/day remote icemakers. In all models, ice is stored below the counter in the dispenser storage area. When the d ...

  • Follett U155 - page 10

    Cleaning and sanitizing bevera ge system before use Cleaning Prepare 6 gallons (23 liters) of cleaning Solution A. Fill a clean product tank with cleaning solution. Fill a second clean product tank with potable rinse water. 1. Disconnect all syrup lines from product containers. 2. Connect syrup circuit #1 to cleaning solution tank, pressurize tank ...

  • Follett U155 - page 11

    Recommended quarterly cleaning (e very 3 months) 1. Turn power switch to "OFF" position and remove top from dispenser. 2. Remove ice from storage area. 3. Remove dispense chute cover, chute, auger motor assembly, auger and auger tube (see page 11). 4. Remove drain pan, grill, dispense wheel and cover plate (see page 12). 5. Clean all comp ...

  • Follett U155 - page 12

    Dispense chute co ver remo val 1. Remove top cover. 2. Push chute cover up vertically to slip off holding tab. 3. After clearing tab, pull chute cover forward to remove. Dispense mechanism assembl y remov al 1. Remove top cover. 2. Remove chute cover (see above). 3. Remove auger motor assembly (see above). 4. Remove quick release pins from the ice ...

  • Follett U155 - page 13

    Service Disassembl y instructions f or service requirements only – NO T required f or an y cleaning pr ocedure . Dispense wheel motor remov al (see drawing abo ve) 1. Remove drain pan, bin access cover and dispense wheel. 2. Remove stainless steel baffle plate under dispense wheel. 3. Remove two screws holding wheel motor bracket on bin. 4. Lift ...

  • Follett U155 - page 14

    Wiring diagram - 13 115 VOL TS 24 VOL TS RED - W ARM ST A TUS LIGHTS GREEN - COLD BA TH CONTROL BOARD BEVERAGE COOLING OPTION BLUE BLACK V alve_1 BLACK V alve_6 ICEMAKER #1 TERMINAL STRIP CONNECTION PIN and SOCKET CONNECTION LEGEND V alve_9 V alve_4 YELLOW V alve_10 BLACK PL7-2 BLACK V alve_5 YELLOW V alve_8 V alve_7 24V JUNCTION BO X ICEMAKER #2 B ...

  • Follett U155 - page 15

    14 Symptom Ice does not dispense. • Auger motor does not run. • Wheel motor does not run. Ice does not dispense. • Auger motor runs. • Wheel motor runs. • Gate does not open. Ice does not dispense. • Auger motor does not run. • Wheel motor runs. Ice does not dispense. • Auger motor runs. • Wheel motor does not run. Warm drinks or ...

  • Follett U155 - page 16

    I 0 I 0 I 0 Operational Status The chart below shows the operational status of various parts when certain switches are turned off or accessories are removed. Condition Pump Solenoids A uger Wheel Bevera ge valves Top lid off off on off off on Rear lid off on on off off on Drain pan off on on off off off On/off switch in off position off off off off ...

  • Follett U155 - page 17

    Replacement par ts Reference # Description Part # 1 Lid, 8 valve unit (includes “ Follett ” label) 502436 1 Lid, 10 valve unit (includes “ Follett ” label) 502437 2 Label, "Follett" 502438 3 Cover, dispense chute, lever operation 502439 3 Cover, dispense chute, push button operation (includes button) 502440 4 Switch, push button o ...

  • Follett U155 - page 18

    Dispense assembly side view (RH unit with bath shown) Reference # Description Part # 1 Gate, dispense 502455 2 Linkage pin, gate / solenoid 502456 3 Pin, quick release, 3" (77mm), bath gate and lever 501949 4 Pin, quick release, 5.53" (141mm), dispense gate 502102 5 Solenoid (includes linkage pin) 501961 6 Dispense mechanism assembly, bat ...

  • Follett U155 - page 19

    Reference # Description Part # 1 Coil, 14" (356mm) riser — carbonated water 502460 2 Coil, 12-1/2" (318mm) riser — plain water / carbonated water 502461 3 Coil, syrup 502462 4 Pump, water bath (includes mounting plate and elbow) 502463 5 Pump, discharge assembly, RH, 8v (includes 2 elbows) 502467 Not shown Pump, discharge assembly, LH ...

  • Follett U155 - page 20

    19 2 Reference # Description Part # 1 Auger, LH unit (black, stamped with “ 1 ” ) 502491 Not shown Auger, RH unit (gray, stamped with “ 2 ” ) 502492 2 Tube, auger, LH unit with beverage bath 502486 Not shown Tube, auger, RH unit with beverage bath 502485 Not shown Tube, auger, RH unit without beverage bath 502487 Not shown Tube, auger, LH u ...

  • Follett U155 - page 21

    20 Reference # Description Part # Auger motor/drive assembly, vertical (includes all items below) 502493 1 Motor, vertical auger (includes gearbox and capacitor) 502476 2 Chain, auger drive #35, 40p 502477 3 Sprocket 35#, 22T 5/8 bore 502478 4 Sprocket 35#, 12T 5/8 bore 502479 5 Drive shaft 502480 6 Bearing, auger, upper and lower 501314 7 Cover an ...

  • Follett U155 - page 22

    I 0 I 0 I 0 Reference # Description Part # 1 Transformer, 24V 502058 2 Relay, level fill 501826 3 Relay, dispense 501826 4 Timer, level fill (automatic fill units) 502471 5 Strips, terminal 502472 6 Switches (power and icemaker) 502209 7 Board, circuit and probe (one unit) 502473 8 Bracket, probe 502474 9 Switch, safety 502511 Not shown Switch, saf ...

  • Follett U155 - page 23

    ...

  • Follett U155 - page 24

    Cool Ideas For Ice Management 207896 10/00 801 Church Lane • PO Box D, Easton, PA 18044 Toll-free (800) 523-9361 • (888) 2-FOLLETT (610) 252-7301 • FAX (610) 250-0696 • www.follettice.com ® U L ® U L ® C ...

メーカー Follett カテゴリー Beverage Dispenser

Follett U155のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- U155の取扱説明書
- Follettの製品カード
- パンフレット
- またはFollett U155の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Follett U155の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Follett U155の取り付け説明書、サービスマニュアル、簡易説明書、またはFollett U155のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Follett U155の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Follett U155デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがFollett U155を使用するのを助ける技術的文書のことです。説明書は通常、全てのFollett U155ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Follettの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Follett U155の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははFollett U155の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Follett U155に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Follett U155デバイスの基本機能を使うにあたってのヒント。 Follett U155のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Follett U155に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるFollett U155のメーカー/サービスへの連絡先に関する情報。

Follett U155についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもFollett U155の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがFollett U155で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)