Français dropdown-ico

Manuel d’utilisation United States Stove 5660(I)

40 pages 2.35 mb
Télécharger

Aller à la page of 40

Summary
  • United States Stove 5660(I) - page 1

    1  Report  #:  215 ‐ S ‐ 32 ‐ 4 and 215 ‐ S ‐ 33 ‐ 4 Installation  and  Operating  Manual  Models  5660( I )     Safety  Notice  Please  read  this  en tire  manual  before  installation  and  use  of  this  pellet  fuel ‐ bu rning  room  heater.  F ...

  • United States Stove 5660(I) - page 2

    2  TABLE  OF  CONTENTS  Topic   Page(s)   Introduction   3  Safety  Information     4 ‐ 5  Specifications    6  Dimensions     ...

  • United States Stove 5660(I) - page 3

    3  Introduction   The  entire  family  of  United  States  Stove  Company  thanks  you  for  pur chasing  your  new  pellet  burning  room  hea ter.  At  U.S.  Stove,  we  build  all  of  our  products  with  a  ha nds ‐ on  approach  to  d ...

  • United States Stove 5660(I) - page 4

    4  SAFETY  INFORMATION   Be  sure  to  read  the  entire  owner’s  manual  prior  to  installing  and  operating  this  Pellet  heater.  Failure  to  follow  these  instruction s  could  result  in  fire,  property  damage,  bodily  injury  or ? ...

  • United States Stove 5660(I) - page 5

    5  SAFETY  INFORMATION  ‐ continued   Keep  foreign  objects  out  of  the  hopper.  Contact  your  local  building  officials  to  obtain  a  permit  and  information  on  any  installation  restrictions  or  inspection  requirements  in  your  are ...

  • United States Stove 5660(I) - page 6

    6  SPECIFICATIONS   Heating  Specifications:   Burn  Rate:   *43,900  btu’s  per  hour  or  5.1  lbs.  of  fuel  per  hour  Hopper  Capacity:   55  lbs.   *Dependent  upon  quality  and  heating  value  of  pellet  fuel.  ...

  • United States Stove 5660(I) - page 7

    7  DIMENSIONS  ‐ continued  The  minimum  installation  dimensions,  of  the  insert  opening,  are:   32”  (813mm)  wide  x  22 ‐ 3/4”  (578mm)  high  x  12 ‐ 1/4”  (311mm)  deep.   Figure  2       ...

  • United States Stove 5660(I) - page 8

    8  OPERATING  INSTRUCTIONS  Check  and  Fill  the  Fuel  Hopper  with  Pellets:  This  Pellet  Stove  is  available  as  a  freestanding  unit  or  as  a  fireplace  insert.  There  is  a  different  method  for  filling  the  hopper  for  ea ...

  • United States Stove 5660(I) - page 9

    9    OPERATING  INSTRUCTIONS  ‐  continued   When  the  pellets  have  ignited  and  flame  has  been  established,  the  start ‐ up  cycle  will  end;  this  procedur e  takes  between  8  and  12  minutes.  If  the  control  is  set  ...

  • United States Stove 5660(I) - page 10

    10  OPERATING  INSTRUCTIONS ‐ continued   Control  Board  Functions:   MODE  Button:  The  MODE  button  allows  you  to  switch  operating  mode  on  your  Pellet  Stove  Room  Heater.  Depress  the  MODE  button  to  switch  between  Manu ...

  • United States Stove 5660(I) - page 11

    11  OPERATING  INSTRUCTIONS  ‐  continued   the  Auger  feed  rate  will  help  keep  the  flames  from  extinguishi ng  on  the  minimum  heat  level  setting.  You  can  also  use  the  AUGER  TRIM  button  to  lower  heat  output  on  ...

  • United States Stove 5660(I) - page 12

    12    THERMOSTAT  INSTALLATION   Optional  thermostats  are  available  for  use  with  your  pellet  stove.  A  thermostat  can  help  you  maintain  a  constant  room  temperature.  The  thermostat  option  will  require  the  installation  of  a ...

  • United States Stove 5660(I) - page 13

    13  USA 6” CANADA 8” USA 6” CANADA 8” CLEARANCES  TO  COMBUSTIBLES  INSTALL  ALL  VENTS  AT  CLEARANCES  SPECIFIED  BY  THE  VENT  MANUFACT URER!   When  your  Pellet  Stove  Room  Heater  is  being  installed  on  a  combustible  floor  it  is  mandat ...

  • United States Stove 5660(I) - page 14

    14   INSTALLING  YOUR  ROOM  HEATER    You  have  already  made  the  important  decision  of  choosing  your  U.S.  Stove  Pellet  Burning  Room  Heater;  now  your  next  step  is  to  determine  where  to  install  your  new  pellet  st ...

  • United States Stove 5660(I) - page 15

    15  INSTALLING  YOUR  ROOM  HEATER  ‐ continued   HORIZONTAL  EXHAUST  VENT  INSTALLATION   1. Locate  your  pellet  stove  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  does  not  interfere ...

  • United States Stove 5660(I) - page 16

    16  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  HORIZONTAL  EXHAUST  VENT  INSTALLATION    ...

  • United States Stove 5660(I) - page 17

    17   INSTALLING  YOUR  ROOM  HEATER  ‐ continued  FREESTANDING  INTERIOR  VERTICAL  INSTALLATION   1. Locate  your  Pellet  Stove  Room  Heater  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  ...

  • United States Stove 5660(I) - page 18

    18  INSTALLING  YOUR  ROOM  HEATER ‐ continued  FREESTANDING  EXTERIOR  VERTICAL  INSTALLATION   1. Locate  your  Pellet  Stove  Room  Heater  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  does ...

  • United States Stove 5660(I) - page 19

    19   ...

  • United States Stove 5660(I) - page 20

    20  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS  Images  courtesy  of  Selkirk  ...

  • United States Stove 5660(I) - page 21

    21  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS  Images  courtesy  of  Selkirk    UP  &  OUT  HORIZONTAL  TERMINATION  KIT   Figure  12      ...

  • United States Stove 5660(I) - page 22

    22  INSTALLING  YOUR  ROOM  HEATER ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS   Images  courtesy  of  Selkirk    STRAIGHT  OUT  HORIZONTAL  TERMINATION  KIT   Figure  13    ...

  • United States Stove 5660(I) - page 23

    23  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS   Images  courtesy  of  Selkirk   THROUGH  THE  ROOF  VERTICAL  TERMINATION  KIT   Figure  14   ...

  • United States Stove 5660(I) - page 24

    24  MOBILE  HOME  INSTALLATION  Mobile  home  installation  shoul d  be  done  in  accordance  with  the  Manufactured  Home  and  Safety  Stan dard  (HUD),  CFR  3280,  Part  24.  Canadian  installations  require  that  the  heater  must  be  co nnected ...

  • United States Stove 5660(I) - page 25

    25  INSERT  PELLET  STOVE  INSTALLATION   U.S.  Stove  Pellet  Burning  Room  Heaters  are  also  available  as  an  insert  into  existing  masonry  of  factory ‐ built  fireplaces.  Do  not  alter  the  existing  fireplace  in  any  way  eit he ...

  • United States Stove 5660(I) - page 26

    26  INSERT  PELLET  STOVE  INSTALLATION  ‐ continued    Step  3:  Sh roud  Top:  Facing  the  back  of  the  unit  take  the  top  shroud  side  piece  and  fasten,  as  shown,  with  4  screws  provided.     Step  4:  Control  Boa ...

  • United States Stove 5660(I) - page 27

    27  INSERT  PELLET  STOVE  INSTALLATION ‐ continued   Minimum  Clearance  to  Combustibles  and  Floor  Protection                A :  Side  wall:  16”  to  side  of  appliance  B :  Top  Trim:  5”  above  top  of ? ...

  • United States Stove 5660(I) - page 28

    28  Installation  into  a  Masonry  Fireplace:            1. Your  chimney  must  be  inspected  by  a  certified  chimney  sweep  or  installer  to  determine  its  structural  condition.  2. Measure  amount  of  venting  required  to ...

  • United States Stove 5660(I) - page 29

    29  VENT  TERMINATION  LOCATIONS   Figure  22   ...

  • United States Stove 5660(I) - page 30

    30  MAINTENANCE  FAILURE  TO  CLEAN  AND  MAINTAIN  THIS  UNIT  AS  INDICATED  MAY  RESULT  IN  POOR  PERFORMANCE  AND  HAZARDOUS  SITUATIONS.  CLEAN  THE  HEATER  FREQUENTLY  AS  ACCUMULATION  OF  SOOT,  CREOSOTE  OR  FLYASH  MAY  OCCUR.  NEVER  CLEA ...

  • United States Stove 5660(I) - page 31

    31  MAINTENANCE  ‐ continued   Ash  Removal ‐ Freestanding  Unit:   If  left  neglected  ashes  will  eventually  fill  the  ash  pan.  Remove  the  ashes  per iodically  to  avoid  unnecessary  ash  build  up.  Ash  removal  is  as  follows ...

  • United States Stove 5660(I) - page 32

    32  MAINTENANCE  ‐ continued   Cleaning   Heat  Exchanger  Tubes  –  Your  Pellet  Stove  Room  Heat er  is  designed  with  a  built  in  heat  exc hanger  tube  cleaner.  This  should  be  used  every  2  or  3  days  to  remove  ash ...

  • United States Stove 5660(I) - page 33

    33  MAINTENANCE  ‐ continued  Chimney/Vent  System  Cleaning:  1. Soot  Formation  –  When  wood  products  are  burned  slowly  they  produce  tar  and  other  organic  vapors  which  combine  with  expelled  moisture  to  form  soot.  The  soot  ...

  • United States Stove 5660(I) - page 34

    34  TROUBLE  SHOOTING   See  figure  26,  page  31,  for  component  locations .   The  heater  will  not  light:   Check  that  the  heater  is  plugged  in  and  that  the  wall  outlet  has  power.   Unplug  the  unit  then  check ? ...

  • United States Stove 5660(I) - page 35

    35  TROUBLE  SHOOTING ‐ continued   The  auger  motor  does  not  function  normally.   If  the  auger  shaft  does  not  turn  but  the  motors  armature  tries  to  spin  then  this  is  a  sign  your  auger  is  jammed.  Try  to ...

  • United States Stove 5660(I) - page 36

    36  TROUBLE  SHOOTING  ‐ continued   Door  Glass  has  soot  buildup  at  a  fast  rate  and  flame  is  lazy  with  black  tips.   The  vent  pipe  (including  air  intake)  may  be  dirty  or  partially  blocked  restricting  airflow  ...

  • United States Stove 5660(I) - page 37

    37  WIRING  DIAGRAM     ...

  • United States Stove 5660(I) - page 38

    38  REPLACEMENT  PARTS   Contact  your  authorized  U.S.  Stove  Pellet  Burning  Room  Heater  dealer  to  obtain  any  of  these  parts.  Never  use  substitute  materials.  Use  of  non ‐ approved  parts  can  result  in  poor  performance,  safe ...

  • United States Stove 5660(I) - page 39

    39  LIMITED WARRANTY United States Stove Company warrants to the original purchaser its Pellet Heaters against premature failure of any component du e to workmanship, quality, or materials as follows: TIME PERIOD: Firebox / Firepot ......................................................................................................... T hree Ye ...

  • United States Stove 5660(I) - page 40

    40   ...

Fabricant United States Stove Catégorie Stove

Les documents que nous recevons du fabricant de l'appareilUnited States Stove 5660(I) peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques United States Stove
- manuels d’utilisations 5660(I)
- fiches produit United States Stove
- dépliants
- ou étiquettes-énergie United States Stove 5660(I)
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation United States Stove 5660(I).

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation United States Stove 5660(I), manuels d’entretien, brefs manuels ou manuels de l’utilisateur United States Stove 5660(I). Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit United States Stove 5660(I).

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil United States Stove 5660(I), quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser United States Stove 5660(I) par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs United States Stove 5660(I).

Le manuel d’utilisation complet United States Stove, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel United States Stove 5660(I) - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières United States Stove 5660(I), FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lUnited States Stove 5660(I) qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil United States Stove 5660(I) - qui devraient nous aider dans les premières étapes lors de l'utilisation United States Stove 5660(I)
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de United States Stove 5660(I)
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service United States Stove 5660(I) dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de United States Stove 5660(I)?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec United States Stove 5660(I), avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec United States Stove 5660(I) il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)