English dropdown-ico

Manual United States Stove 5660(I)

40 pages 2.35 mb
Download

Go to site of 40

Summary
  • United States Stove 5660(I) - page 1

    1  Report  #:  215 ‐ S ‐ 32 ‐ 4 and 215 ‐ S ‐ 33 ‐ 4 Installation  and  Operating  Manual  Models  5660( I )     Safety  Notice  Please  read  this  en tire  manual  before  installation  and  use  of  this  pellet  fuel ‐ bu rning  room  heater.  F ...

  • United States Stove 5660(I) - page 2

    2  TABLE  OF  CONTENTS  Topic   Page(s)   Introduction   3  Safety  Information     4 ‐ 5  Specifications    6  Dimensions     ...

  • United States Stove 5660(I) - page 3

    3  Introduction   The  entire  family  of  United  States  Stove  Company  thanks  you  for  pur chasing  your  new  pellet  burning  room  hea ter.  At  U.S.  Stove,  we  build  all  of  our  products  with  a  ha nds ‐ on  approach  to  d ...

  • United States Stove 5660(I) - page 4

    4  SAFETY  INFORMATION   Be  sure  to  read  the  entire  owner’s  manual  prior  to  installing  and  operating  this  Pellet  heater.  Failure  to  follow  these  instruction s  could  result  in  fire,  property  damage,  bodily  injury  or ? ...

  • United States Stove 5660(I) - page 5

    5  SAFETY  INFORMATION  ‐ continued   Keep  foreign  objects  out  of  the  hopper.  Contact  your  local  building  officials  to  obtain  a  permit  and  information  on  any  installation  restrictions  or  inspection  requirements  in  your  are ...

  • United States Stove 5660(I) - page 6

    6  SPECIFICATIONS   Heating  Specifications:   Burn  Rate:   *43,900  btu’s  per  hour  or  5.1  lbs.  of  fuel  per  hour  Hopper  Capacity:   55  lbs.   *Dependent  upon  quality  and  heating  value  of  pellet  fuel.  ...

  • United States Stove 5660(I) - page 7

    7  DIMENSIONS  ‐ continued  The  minimum  installation  dimensions,  of  the  insert  opening,  are:   32”  (813mm)  wide  x  22 ‐ 3/4”  (578mm)  high  x  12 ‐ 1/4”  (311mm)  deep.   Figure  2       ...

  • United States Stove 5660(I) - page 8

    8  OPERATING  INSTRUCTIONS  Check  and  Fill  the  Fuel  Hopper  with  Pellets:  This  Pellet  Stove  is  available  as  a  freestanding  unit  or  as  a  fireplace  insert.  There  is  a  different  method  for  filling  the  hopper  for  ea ...

  • United States Stove 5660(I) - page 9

    9    OPERATING  INSTRUCTIONS  ‐  continued   When  the  pellets  have  ignited  and  flame  has  been  established,  the  start ‐ up  cycle  will  end;  this  procedur e  takes  between  8  and  12  minutes.  If  the  control  is  set  ...

  • United States Stove 5660(I) - page 10

    10  OPERATING  INSTRUCTIONS ‐ continued   Control  Board  Functions:   MODE  Button:  The  MODE  button  allows  you  to  switch  operating  mode  on  your  Pellet  Stove  Room  Heater.  Depress  the  MODE  button  to  switch  between  Manu ...

  • United States Stove 5660(I) - page 11

    11  OPERATING  INSTRUCTIONS  ‐  continued   the  Auger  feed  rate  will  help  keep  the  flames  from  extinguishi ng  on  the  minimum  heat  level  setting.  You  can  also  use  the  AUGER  TRIM  button  to  lower  heat  output  on  ...

  • United States Stove 5660(I) - page 12

    12    THERMOSTAT  INSTALLATION   Optional  thermostats  are  available  for  use  with  your  pellet  stove.  A  thermostat  can  help  you  maintain  a  constant  room  temperature.  The  thermostat  option  will  require  the  installation  of  a ...

  • United States Stove 5660(I) - page 13

    13  USA 6” CANADA 8” USA 6” CANADA 8” CLEARANCES  TO  COMBUSTIBLES  INSTALL  ALL  VENTS  AT  CLEARANCES  SPECIFIED  BY  THE  VENT  MANUFACT URER!   When  your  Pellet  Stove  Room  Heater  is  being  installed  on  a  combustible  floor  it  is  mandat ...

  • United States Stove 5660(I) - page 14

    14   INSTALLING  YOUR  ROOM  HEATER    You  have  already  made  the  important  decision  of  choosing  your  U.S.  Stove  Pellet  Burning  Room  Heater;  now  your  next  step  is  to  determine  where  to  install  your  new  pellet  st ...

  • United States Stove 5660(I) - page 15

    15  INSTALLING  YOUR  ROOM  HEATER  ‐ continued   HORIZONTAL  EXHAUST  VENT  INSTALLATION   1. Locate  your  pellet  stove  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  does  not  interfere ...

  • United States Stove 5660(I) - page 16

    16  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  HORIZONTAL  EXHAUST  VENT  INSTALLATION    ...

  • United States Stove 5660(I) - page 17

    17   INSTALLING  YOUR  ROOM  HEATER  ‐ continued  FREESTANDING  INTERIOR  VERTICAL  INSTALLATION   1. Locate  your  Pellet  Stove  Room  Heater  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  ...

  • United States Stove 5660(I) - page 18

    18  INSTALLING  YOUR  ROOM  HEATER ‐ continued  FREESTANDING  EXTERIOR  VERTICAL  INSTALLATION   1. Locate  your  Pellet  Stove  Room  Heater  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  does ...

  • United States Stove 5660(I) - page 19

    19   ...

  • United States Stove 5660(I) - page 20

    20  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS  Images  courtesy  of  Selkirk  ...

  • United States Stove 5660(I) - page 21

    21  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS  Images  courtesy  of  Selkirk    UP  &  OUT  HORIZONTAL  TERMINATION  KIT   Figure  12      ...

  • United States Stove 5660(I) - page 22

    22  INSTALLING  YOUR  ROOM  HEATER ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS   Images  courtesy  of  Selkirk    STRAIGHT  OUT  HORIZONTAL  TERMINATION  KIT   Figure  13    ...

  • United States Stove 5660(I) - page 23

    23  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS   Images  courtesy  of  Selkirk   THROUGH  THE  ROOF  VERTICAL  TERMINATION  KIT   Figure  14   ...

  • United States Stove 5660(I) - page 24

    24  MOBILE  HOME  INSTALLATION  Mobile  home  installation  shoul d  be  done  in  accordance  with  the  Manufactured  Home  and  Safety  Stan dard  (HUD),  CFR  3280,  Part  24.  Canadian  installations  require  that  the  heater  must  be  co nnected ...

  • United States Stove 5660(I) - page 25

    25  INSERT  PELLET  STOVE  INSTALLATION   U.S.  Stove  Pellet  Burning  Room  Heaters  are  also  available  as  an  insert  into  existing  masonry  of  factory ‐ built  fireplaces.  Do  not  alter  the  existing  fireplace  in  any  way  eit he ...

  • United States Stove 5660(I) - page 26

    26  INSERT  PELLET  STOVE  INSTALLATION  ‐ continued    Step  3:  Sh roud  Top:  Facing  the  back  of  the  unit  take  the  top  shroud  side  piece  and  fasten,  as  shown,  with  4  screws  provided.     Step  4:  Control  Boa ...

  • United States Stove 5660(I) - page 27

    27  INSERT  PELLET  STOVE  INSTALLATION ‐ continued   Minimum  Clearance  to  Combustibles  and  Floor  Protection                A :  Side  wall:  16”  to  side  of  appliance  B :  Top  Trim:  5”  above  top  of ? ...

  • United States Stove 5660(I) - page 28

    28  Installation  into  a  Masonry  Fireplace:            1. Your  chimney  must  be  inspected  by  a  certified  chimney  sweep  or  installer  to  determine  its  structural  condition.  2. Measure  amount  of  venting  required  to ...

  • United States Stove 5660(I) - page 29

    29  VENT  TERMINATION  LOCATIONS   Figure  22   ...

  • United States Stove 5660(I) - page 30

    30  MAINTENANCE  FAILURE  TO  CLEAN  AND  MAINTAIN  THIS  UNIT  AS  INDICATED  MAY  RESULT  IN  POOR  PERFORMANCE  AND  HAZARDOUS  SITUATIONS.  CLEAN  THE  HEATER  FREQUENTLY  AS  ACCUMULATION  OF  SOOT,  CREOSOTE  OR  FLYASH  MAY  OCCUR.  NEVER  CLEA ...

  • United States Stove 5660(I) - page 31

    31  MAINTENANCE  ‐ continued   Ash  Removal ‐ Freestanding  Unit:   If  left  neglected  ashes  will  eventually  fill  the  ash  pan.  Remove  the  ashes  per iodically  to  avoid  unnecessary  ash  build  up.  Ash  removal  is  as  follows ...

  • United States Stove 5660(I) - page 32

    32  MAINTENANCE  ‐ continued   Cleaning   Heat  Exchanger  Tubes  –  Your  Pellet  Stove  Room  Heat er  is  designed  with  a  built  in  heat  exc hanger  tube  cleaner.  This  should  be  used  every  2  or  3  days  to  remove  ash ...

  • United States Stove 5660(I) - page 33

    33  MAINTENANCE  ‐ continued  Chimney/Vent  System  Cleaning:  1. Soot  Formation  –  When  wood  products  are  burned  slowly  they  produce  tar  and  other  organic  vapors  which  combine  with  expelled  moisture  to  form  soot.  The  soot  ...

  • United States Stove 5660(I) - page 34

    34  TROUBLE  SHOOTING   See  figure  26,  page  31,  for  component  locations .   The  heater  will  not  light:   Check  that  the  heater  is  plugged  in  and  that  the  wall  outlet  has  power.   Unplug  the  unit  then  check ? ...

  • United States Stove 5660(I) - page 35

    35  TROUBLE  SHOOTING ‐ continued   The  auger  motor  does  not  function  normally.   If  the  auger  shaft  does  not  turn  but  the  motors  armature  tries  to  spin  then  this  is  a  sign  your  auger  is  jammed.  Try  to ...

  • United States Stove 5660(I) - page 36

    36  TROUBLE  SHOOTING  ‐ continued   Door  Glass  has  soot  buildup  at  a  fast  rate  and  flame  is  lazy  with  black  tips.   The  vent  pipe  (including  air  intake)  may  be  dirty  or  partially  blocked  restricting  airflow  ...

  • United States Stove 5660(I) - page 37

    37  WIRING  DIAGRAM     ...

  • United States Stove 5660(I) - page 38

    38  REPLACEMENT  PARTS   Contact  your  authorized  U.S.  Stove  Pellet  Burning  Room  Heater  dealer  to  obtain  any  of  these  parts.  Never  use  substitute  materials.  Use  of  non ‐ approved  parts  can  result  in  poor  performance,  safe ...

  • United States Stove 5660(I) - page 39

    39  LIMITED WARRANTY United States Stove Company warrants to the original purchaser its Pellet Heaters against premature failure of any component du e to workmanship, quality, or materials as follows: TIME PERIOD: Firebox / Firepot ......................................................................................................... T hree Ye ...

  • United States Stove 5660(I) - page 40

    40   ...

Manufacturer United States Stove Category Stove

Documents that we receive from a manufacturer of a United States Stove 5660(I) can be divided into several groups. They are, among others:
- United States Stove technical drawings
- 5660(I) manuals
- United States Stove product data sheets
- information booklets
- or energy labels United States Stove 5660(I)
All of them are important, but the most important information from the point of view of use of the device are in the user manual United States Stove 5660(I).

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals United States Stove 5660(I), service manual, brief instructions and user manuals United States Stove 5660(I). Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product United States Stove 5660(I).

Similar manuals

A complete manual for the device United States Stove 5660(I), how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use United States Stove 5660(I) by users. Manuals are usually written by a technical writer, but in a language understandable to all users of United States Stove 5660(I).

A complete United States Stove manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual United States Stove 5660(I) - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the United States Stove 5660(I), FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the United States Stove 5660(I), that we can find in the current document
3. Tips how to use the basic functions of the device United States Stove 5660(I) - which should help us in our first steps of using United States Stove 5660(I)
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with United States Stove 5660(I)
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of United States Stove 5660(I) in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning United States Stove 5660(I)?

Use the form below

If you did not solve your problem by using a manual United States Stove 5660(I), ask a question using the form below. If a user had a similar problem with United States Stove 5660(I) it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)