Français dropdown-ico

Manuel d’utilisation Clarke L30

24 pages 0.49 mb
Télécharger

Aller à la page of 24

Summary
  • Clarke L30 - page 1

    Form No. 70762A 9/03 Clarke ® Printed in the U.S.A. READ THIS BOOK CAUTION: Read the Operator's Manual before using the appliance. This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your Clarke machine could resu ...

  • Clarke L30 - page 2

    Page -2- Clarke ® Operator's Manual -Encore S30/L30 Table of Contents SECTION II - Parts and Service Manual How to Correct Problems in the Machine ......................................................................................... ............... 2 8 Encore S30/L30 Final Assembly Drawing ................................................. ...

  • Clarke L30 - page 3

    Clarke ® Operator's Manual - Encore S30/L30 Page -3- OPERA TOR SAFETY INSTRUCTIONS WARNING AVERTISSEMENT ADVERTENCIA D A N G E R : Failure to read and observe all DANGER statements could result in severe bodily injury or death. Read and observe all DANGER statements found in your Owner's Manual and on your machine. WARNING: Failure to re ...

  • Clarke L30 - page 4

    Page -4- Clarke ® Operator's Manual -Encore S30/L30 WARNING: Maintenance and repairs performed by unauthorized personnel could result in damage or injury. Maintenance and repairs must be performed by authorized Clarke personnel only. WARNING: Any alterations or modifications of this machine could result in damage to the machine or injury to t ...

  • Clarke L30 - page 5

    Clarke ® Operator's Manual - Encore S30/L30 Page -5- SPECIFICATIONS: Model Encore L30 Machine Power Supply 24 Volt D.C., 24 Volt D.C., (4) 6V 250 AH Deep Cycle Batteries or (2) 6V 195 AH Deep Cycle Batteries or (4) 6V 330 AH Deep Cycle Batteries (4) 6V 250 AH Deep Cycle Batteries or (4) 6V 330 AH Deep Cycle Batteries Pad or Brush Gimbal Style ...

  • Clarke L30 - page 6

    Page -6- Clarke ® Operator's Manual -Encore S30/L30 Procedures For Transporting How to Put the Machine Into a Van or Truck WARNING: This machine is heavy. Get assistance before attempting to transport or move it. Use two able persons to move the machine on a ramp or incline. Always move slowly. Do not turn the machine on a ramp. Do not stop a ...

  • Clarke L30 - page 7

    Clarke ® Operator's Manual - Encore S30/L30 Page -7- 11. Fasten the machine to the vehicle. Clarke recommends a strap over the top of the machine and a strap to keep the machine from rolling forward or backwards. If this is not done, there is a possibility of the machine toppling over. Four tie down points (2 along each side of frame) are pro ...

  • Clarke L30 - page 8

    Page -8- Clarke ® Operator's Manual -Encore S30/L30 SYMBOLS USED ON ENCORE S30 and L30 Solution Control ("L Class" & "S Class") Brush Up/Down ("L Class" & "S Class") Warning ("L Class" & "S Class') Power ("L Class" & "S Class") Traverse Speed Contr ...

  • Clarke L30 - page 9

    Clarke ® Operator's Manual - Encore S30/L30 Page -9- SYMBOLS USED ON ENCORE S30 and L30 Warning Label ("L Class" & "S Class") with parking brake Warning Label ("L Class" & "S Class") without parking brake Solution/Brush Motors ("S Class" ) IVIE Enterprises – Website: www.ivie-ent.com ...

  • Clarke L30 - page 10

    Page -10- Clarke ® Operator's Manual -Encore S30/L30 Machine Control Panel Figure 3 Circuit Breakers (See Fig 3, Items "F", "G", "H", "I" & "J") The circuit breaker reset buttons are located on the rear cover. The breakers are located as follows: Item F - Actuator Head (5 amp) Item G - Vac ...

  • Clarke L30 - page 11

    Clarke ® Operator's Manual - Encore S30/L30 Page -11- Machine Controls and Features Squeegee Lift Handle, See Figures 4 and 5 The squeegee lift handle is located below the control handles in the center. It is used to raise or lower the squeegee. The vac motor is turned on when the handle is lowered to either the first or last position. Float ...

  • Clarke L30 - page 12

    Page -12- Clarke ® Operator's Manual -Encore S30/L30 Figure 8B How To Install The Batteries The Encore machines uses either two 12-volt batteries or four - 6 volt batteries. The batteries are located in the battery compartment under the recovery tank. To install the batteries, follow this procedure: 1. Turn machine off. Set brake (if equipped ...

  • Clarke L30 - page 13

    Clarke ® Operator's Manual - Encore S30/L30 Page -13- Battery Maintenance The electrical power to operate the machine comes from the storage batteries. Storage batteries need preventative maintenance. WARNING: Working with batteries can be dangerous. Always wear eye protection and protective clothing when working near batteries. NO SMOKING! T ...

  • Clarke L30 - page 14

    Page -14- Clarke ® Operator's Manual -Encore S30/L30 How To Prepare the Machine For Operation Figure 12 ("S" Model) Figure 13A Figure 13B How To Charge The Batteries WARNING: Charging the batteries in an area without adequate ventilation could result in an explosion. To prevent an explosion, charge the batteries only in an area with ...

  • Clarke L30 - page 15

    Clarke ® Operator's Manual - Encore S30/L30 Page -15- 4. Disconnect the battery pack connector from the control housing connector. See figure 14A. 5. Connect the DC connector on the charger to the battery pack connector. See figure 14B. 6. Connect the charger to a properly grounded single phase (3-wire) wall receptacle having the input voltag ...

  • Clarke L30 - page 16

    Page -16- Clarke ® Operator's Manual -Encore S30/L30 How To Operate The Squeegee The squeegee wipes the floor while the vacuum motor removes the dirty solution from the floor. Use your hand to lower or raise the squeegee handle. To operate the squeegee, follow this procedure: 1. To lower the squeegee and start the vacuum motor, move the squee ...

  • Clarke L30 - page 17

    Clarke ® Operator's Manual - Encore S30/L30 Page -17- Figure 21 When filling machine from the rear, position clear drain hose against bracket and insert hose as shown in figure 20B Solution level can be viewed from the back of the machine. WARNING: Water solutions or cleaning materials used with this type of machine can leave wet areas on the ...

  • Clarke L30 - page 18

    Page -18- Clarke ® Operator's Manual -Encore S30/L30 How To Clean A Floor WARNING: Water solutions or cleaning materials used with this type of machine can leave wet areas on the floor surfaces. These areas can cause a dangerous condition for the operator or other persons. Always put CAUTION signs near the area you are cleaning. To clean a fl ...

  • Clarke L30 - page 19

    Clarke ® Operator's Manual - Encore S30/L30 Page -19- WARNING: Maintenance and repairs must be done by authorized personnel only. WARNING: Always empty the solution tank and recovery tank before doing any maintenance. WARNING: Keep all fasteners tight. These Maintenance Procedures Must Be Done Every Day Keep the machine clean, it will need fe ...

  • Clarke L30 - page 20

    Page -20- Clarke ® Operator's Manual -Encore S30/L30 Do These Procedures When You End Your Work 1. Drain the solution tank (Figure 25) and the recovery tank (Figure 26). To drain the tanks , follow this procedure: a. Turn the key switch “OFF”. b. Remove the drain hose from the back of the machine. c. Put the end of the hose over a drain o ...

  • Clarke L30 - page 21

    Clarke ® Operator's Manual - Encore S30/L30 Page -21- Maintenance Procedures To Be Done Every Week: WARNING: Maintenance and repairs must be done by authorized personnel only. Always empty the solution tank and the recovery tank before doing any maintenance. Keep all fasteners tight. WARNING: Always wear eye protection and protective clothing ...

  • Clarke L30 - page 22

    Page -22- Clarke ® Operator's Manual -Encore S30/L30 Maintenance For The Squeegee To remove the squeegee, follow this procedure: 1. Remove the squeegee assembly by loosening the two knobs that attach the squeegee to the machine. Pull the squeegee assembly off. See figure 31. 2. Inspect the squeegee blade. 3. If the blade is worn, turn the bla ...

  • Clarke L30 - page 23

    Clarke ® Operator's Manual - Encore S30/L30 Page -23- Maintenance cont. Consult your Clarke Authorized Service Person to do the service procedures. Use only genuine Clarke parts. How to Center or Offset the Brush Head The brush head on the Encore 30 should be adjusted as far to the left side of the machine as possible. Recommended tools: 3/8& ...

  • Clarke L30 - page 24

    Page -24- Clarke ® Operator's Manual -Encore S30/L30 Clarke ® Encore S30 and L30 Accessories - 9/03 A CCESSORIES Description Part No. Power Wand System Kit 1 0 1 50 A Clarke Care Kit 1 46 07 A 39" Squeegee Assembly 1 00 68 A Poly Dur Protectant 5 04 78 A Kit, Grease Gun 5 54 20 A Kit, Low Voltage Shut-Off 1 40 97 A Brake Kit Assembly &q ...

Fabricant Clarke Catégorie Vacuum Cleaner

Les documents que nous recevons du fabricant de l'appareilClarke L30 peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Clarke
- manuels d’utilisations L30
- fiches produit Clarke
- dépliants
- ou étiquettes-énergie Clarke L30
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Clarke L30.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Clarke L30, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Clarke L30. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Clarke L30.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Clarke L30, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Clarke L30 par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Clarke L30.

Le manuel d’utilisation complet Clarke, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Clarke L30 - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Clarke L30, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lClarke L30 qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Clarke L30 - qui devraient nous aider dans les premières étapes lors de l'utilisation Clarke L30
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Clarke L30
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Clarke L30 dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Clarke L30?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Clarke L30, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Clarke L30 il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)