English dropdown-ico

Manual Clarke L30

24 pages 0.49 mb
Download

Go to site of 24

Summary
  • Clarke L30 - page 1

    Form No. 70762A 9/03 Clarke ® Printed in the U.S.A. READ THIS BOOK CAUTION: Read the Operator's Manual before using the appliance. This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your Clarke machine could resu ...

  • Clarke L30 - page 2

    Page -2- Clarke ® Operator's Manual -Encore S30/L30 Table of Contents SECTION II - Parts and Service Manual How to Correct Problems in the Machine ......................................................................................... ............... 2 8 Encore S30/L30 Final Assembly Drawing ................................................. ...

  • Clarke L30 - page 3

    Clarke ® Operator's Manual - Encore S30/L30 Page -3- OPERA TOR SAFETY INSTRUCTIONS WARNING AVERTISSEMENT ADVERTENCIA D A N G E R : Failure to read and observe all DANGER statements could result in severe bodily injury or death. Read and observe all DANGER statements found in your Owner's Manual and on your machine. WARNING: Failure to re ...

  • Clarke L30 - page 4

    Page -4- Clarke ® Operator's Manual -Encore S30/L30 WARNING: Maintenance and repairs performed by unauthorized personnel could result in damage or injury. Maintenance and repairs must be performed by authorized Clarke personnel only. WARNING: Any alterations or modifications of this machine could result in damage to the machine or injury to t ...

  • Clarke L30 - page 5

    Clarke ® Operator's Manual - Encore S30/L30 Page -5- SPECIFICATIONS: Model Encore L30 Machine Power Supply 24 Volt D.C., 24 Volt D.C., (4) 6V 250 AH Deep Cycle Batteries or (2) 6V 195 AH Deep Cycle Batteries or (4) 6V 330 AH Deep Cycle Batteries (4) 6V 250 AH Deep Cycle Batteries or (4) 6V 330 AH Deep Cycle Batteries Pad or Brush Gimbal Style ...

  • Clarke L30 - page 6

    Page -6- Clarke ® Operator's Manual -Encore S30/L30 Procedures For Transporting How to Put the Machine Into a Van or Truck WARNING: This machine is heavy. Get assistance before attempting to transport or move it. Use two able persons to move the machine on a ramp or incline. Always move slowly. Do not turn the machine on a ramp. Do not stop a ...

  • Clarke L30 - page 7

    Clarke ® Operator's Manual - Encore S30/L30 Page -7- 11. Fasten the machine to the vehicle. Clarke recommends a strap over the top of the machine and a strap to keep the machine from rolling forward or backwards. If this is not done, there is a possibility of the machine toppling over. Four tie down points (2 along each side of frame) are pro ...

  • Clarke L30 - page 8

    Page -8- Clarke ® Operator's Manual -Encore S30/L30 SYMBOLS USED ON ENCORE S30 and L30 Solution Control ("L Class" & "S Class") Brush Up/Down ("L Class" & "S Class") Warning ("L Class" & "S Class') Power ("L Class" & "S Class") Traverse Speed Contr ...

  • Clarke L30 - page 9

    Clarke ® Operator's Manual - Encore S30/L30 Page -9- SYMBOLS USED ON ENCORE S30 and L30 Warning Label ("L Class" & "S Class") with parking brake Warning Label ("L Class" & "S Class") without parking brake Solution/Brush Motors ("S Class" ) IVIE Enterprises – Website: www.ivie-ent.com ...

  • Clarke L30 - page 10

    Page -10- Clarke ® Operator's Manual -Encore S30/L30 Machine Control Panel Figure 3 Circuit Breakers (See Fig 3, Items "F", "G", "H", "I" & "J") The circuit breaker reset buttons are located on the rear cover. The breakers are located as follows: Item F - Actuator Head (5 amp) Item G - Vac ...

  • Clarke L30 - page 11

    Clarke ® Operator's Manual - Encore S30/L30 Page -11- Machine Controls and Features Squeegee Lift Handle, See Figures 4 and 5 The squeegee lift handle is located below the control handles in the center. It is used to raise or lower the squeegee. The vac motor is turned on when the handle is lowered to either the first or last position. Float ...

  • Clarke L30 - page 12

    Page -12- Clarke ® Operator's Manual -Encore S30/L30 Figure 8B How To Install The Batteries The Encore machines uses either two 12-volt batteries or four - 6 volt batteries. The batteries are located in the battery compartment under the recovery tank. To install the batteries, follow this procedure: 1. Turn machine off. Set brake (if equipped ...

  • Clarke L30 - page 13

    Clarke ® Operator's Manual - Encore S30/L30 Page -13- Battery Maintenance The electrical power to operate the machine comes from the storage batteries. Storage batteries need preventative maintenance. WARNING: Working with batteries can be dangerous. Always wear eye protection and protective clothing when working near batteries. NO SMOKING! T ...

  • Clarke L30 - page 14

    Page -14- Clarke ® Operator's Manual -Encore S30/L30 How To Prepare the Machine For Operation Figure 12 ("S" Model) Figure 13A Figure 13B How To Charge The Batteries WARNING: Charging the batteries in an area without adequate ventilation could result in an explosion. To prevent an explosion, charge the batteries only in an area with ...

  • Clarke L30 - page 15

    Clarke ® Operator's Manual - Encore S30/L30 Page -15- 4. Disconnect the battery pack connector from the control housing connector. See figure 14A. 5. Connect the DC connector on the charger to the battery pack connector. See figure 14B. 6. Connect the charger to a properly grounded single phase (3-wire) wall receptacle having the input voltag ...

  • Clarke L30 - page 16

    Page -16- Clarke ® Operator's Manual -Encore S30/L30 How To Operate The Squeegee The squeegee wipes the floor while the vacuum motor removes the dirty solution from the floor. Use your hand to lower or raise the squeegee handle. To operate the squeegee, follow this procedure: 1. To lower the squeegee and start the vacuum motor, move the squee ...

  • Clarke L30 - page 17

    Clarke ® Operator's Manual - Encore S30/L30 Page -17- Figure 21 When filling machine from the rear, position clear drain hose against bracket and insert hose as shown in figure 20B Solution level can be viewed from the back of the machine. WARNING: Water solutions or cleaning materials used with this type of machine can leave wet areas on the ...

  • Clarke L30 - page 18

    Page -18- Clarke ® Operator's Manual -Encore S30/L30 How To Clean A Floor WARNING: Water solutions or cleaning materials used with this type of machine can leave wet areas on the floor surfaces. These areas can cause a dangerous condition for the operator or other persons. Always put CAUTION signs near the area you are cleaning. To clean a fl ...

  • Clarke L30 - page 19

    Clarke ® Operator's Manual - Encore S30/L30 Page -19- WARNING: Maintenance and repairs must be done by authorized personnel only. WARNING: Always empty the solution tank and recovery tank before doing any maintenance. WARNING: Keep all fasteners tight. These Maintenance Procedures Must Be Done Every Day Keep the machine clean, it will need fe ...

  • Clarke L30 - page 20

    Page -20- Clarke ® Operator's Manual -Encore S30/L30 Do These Procedures When You End Your Work 1. Drain the solution tank (Figure 25) and the recovery tank (Figure 26). To drain the tanks , follow this procedure: a. Turn the key switch “OFF”. b. Remove the drain hose from the back of the machine. c. Put the end of the hose over a drain o ...

  • Clarke L30 - page 21

    Clarke ® Operator's Manual - Encore S30/L30 Page -21- Maintenance Procedures To Be Done Every Week: WARNING: Maintenance and repairs must be done by authorized personnel only. Always empty the solution tank and the recovery tank before doing any maintenance. Keep all fasteners tight. WARNING: Always wear eye protection and protective clothing ...

  • Clarke L30 - page 22

    Page -22- Clarke ® Operator's Manual -Encore S30/L30 Maintenance For The Squeegee To remove the squeegee, follow this procedure: 1. Remove the squeegee assembly by loosening the two knobs that attach the squeegee to the machine. Pull the squeegee assembly off. See figure 31. 2. Inspect the squeegee blade. 3. If the blade is worn, turn the bla ...

  • Clarke L30 - page 23

    Clarke ® Operator's Manual - Encore S30/L30 Page -23- Maintenance cont. Consult your Clarke Authorized Service Person to do the service procedures. Use only genuine Clarke parts. How to Center or Offset the Brush Head The brush head on the Encore 30 should be adjusted as far to the left side of the machine as possible. Recommended tools: 3/8& ...

  • Clarke L30 - page 24

    Page -24- Clarke ® Operator's Manual -Encore S30/L30 Clarke ® Encore S30 and L30 Accessories - 9/03 A CCESSORIES Description Part No. Power Wand System Kit 1 0 1 50 A Clarke Care Kit 1 46 07 A 39" Squeegee Assembly 1 00 68 A Poly Dur Protectant 5 04 78 A Kit, Grease Gun 5 54 20 A Kit, Low Voltage Shut-Off 1 40 97 A Brake Kit Assembly &q ...

Manufacturer Clarke Category Vacuum Cleaner

Documents that we receive from a manufacturer of a Clarke L30 can be divided into several groups. They are, among others:
- Clarke technical drawings
- L30 manuals
- Clarke product data sheets
- information booklets
- or energy labels Clarke L30
All of them are important, but the most important information from the point of view of use of the device are in the user manual Clarke L30.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Clarke L30, service manual, brief instructions and user manuals Clarke L30. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Clarke L30.

Similar manuals

A complete manual for the device Clarke L30, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Clarke L30 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Clarke L30.

A complete Clarke manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Clarke L30 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Clarke L30, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Clarke L30, that we can find in the current document
3. Tips how to use the basic functions of the device Clarke L30 - which should help us in our first steps of using Clarke L30
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Clarke L30
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Clarke L30 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Clarke L30?

Use the form below

If you did not solve your problem by using a manual Clarke L30, ask a question using the form below. If a user had a similar problem with Clarke L30 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)