Français dropdown-ico

Manuel d’utilisation England's Stove Works 55-TRP22E

25 pages 1.12 mb
Télécharger

Aller à la page of 25

Summary
  • England's Stove Works 55-TRP22E - page 1

    INSTALLATION & OPERATION MANUAL MODEL NUMBERS: 25-PDV 55-SHP22 55-TRP22 25-PDVE 55-SHP22E 55-TRP22E Thank you for purchasing this product from a fine line of heating equipment. We wish you many years of safe heating pleasure with your new heating appliance. Save These Instructions. IMPORTANT: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN I ...

  • England's Stove Works 55-TRP22E - page 2

    2 A letter from our Technical Support department : Thank you for purchasing this fine produ ct from England’s Stove Works! England's Stove Works was started, a nd is still owned by, a family that believes strongly in a "Do It Yoursel f" spirit – that’s one reason you found this product at your favorite “Do It Yourself” stor ...

  • England's Stove Works 55-TRP22E - page 3

    3 IMPORTANT INFORMATION 1. Check local installation codes for your area. C all your Homeowner’s Insurance representative for inspection of your stove’s installation. 2. Read and comply with the instructions in this manual. 3. This unit should be tested (dry run) before load ing pellets for 20 minutes. The st ove should automatically shut itself ...

  • England's Stove Works 55-TRP22E - page 4

    4 14. Do not allow paint, chemicals or construction dust on or near your unit. Do not allow liquid or ANY foreign materials on or inside your unit. Shut your unit down and cover it when painting, construction or similar activity is taking place. Wipe and clean your unit after any construction is done in your home, or if any foreign material gets on ...

  • England's Stove Works 55-TRP22E - page 5

    5 Proper Impingement (Baffle) Plate Placement in Pellet Stove Firebox Occasionally in shipping, the impingement (baffle) plate may shift out of its proper position. If this is the case with your stove, follow these instructions to r eturn the plate to its proper position. 1. Remove the plate from the stove, holding the plate by its tab handle, with ...

  • England's Stove Works 55-TRP22E - page 6

    6 FLUE SYSTEM Caution: Follow the pipe manufacturer’s installation instructions and directions for pas sing through combustible walls and ceilings. Be sure to check local codes in your area. NOTE : See the installation drawing later in this manual (Illustration 1). This unit is equipped with a negative draft system that pulls combustion air throu ...

  • England's Stove Works 55-TRP22E - page 7

    7 Through the Ceiling When venting the stove through the ceiling, the pipe is connected the same as through the wall, except the clean out tee is always on the inside of the house, and a 3” adapter is ad ded before the clean-out tee. You must use the proper ceiling support flanges and roof flash ing supplied by the pipe manufacturer -- follow the ...

  • England's Stove Works 55-TRP22E - page 8

    8 FLOOR AND WALL PROTECTION Floor Protection If your floor is constructed of a non-combustible ma terial such as brick or concrete, there is no need for floor protection. If the floor is constructed of a combustible material such as hardwood, linoleum, or carpet, then you will be required to use floor protection between the unit and the combustible ...

  • England's Stove Works 55-TRP22E - page 9

    9 OPERATING INSTRUCTIONS CAUTION: DO NOT OPERATE WITH THE DOOR OPEN. If door is left open (approximately ) two minut es, unit will stop feeding and fire will go out. Do not burn trash (paper bags, etc.) in this unit. This stove has an induced draft system and is designed to operate continuously, as frequent shutdown is not required. The digital con ...

  • England's Stove Works 55-TRP22E - page 10

    10 E-Codes “E-Codes,” or Error Codes, are codes that will appear in the Heat Range and Blower Speed windows of the Control Board if your unit experiences problems. If you receive any of these codes, first attempt to reset your unit by pressing the “ON” button (only once). If the unit continues to display any E-Code(s), please contact Techni ...

  • England's Stove Works 55-TRP22E - page 11

    11 DAILY OPERATION Refueling the Unit Always press the “OFF” touch pad before refueling. This stove has a (approximately) 60-lb. hopper, and should be refilled when the hopper level drops to three or four inches. Note : The hopper lid will be warm; therefore, you should always use some type of hand protection. NEVER place your hand near the aug ...

  • England's Stove Works 55-TRP22E - page 12

    12 ASH REMOVAL AND DISPOSAL IMPORTANT: While the amount of ash generated by this unit is not excessive compared to log-burning woodstoves, keeping the unit clean and free of ash is essential for peak performance. Too much ash build-up hampers airflow and reduces the unit’s efficiency, and can cause smoke-back. Follow these directions at least as ...

  • England's Stove Works 55-TRP22E - page 13

    13 Monthly Ash Removal The large baffle plate (12-5/8” x 9-3/8”) that rests above and behind the burn pot (refer to the section on “Proper Impingement Plate Placement” and the exploded diagram in t he rear of this manual – Illustration 4) should be removed monthly. This can be done by lifting up the plate and pulling it out. The area behi ...

  • England's Stove Works 55-TRP22E - page 14

    14 MAINTENANCE CAUTION: UNPLUG THE UNIT PRIOR TO ANY SERVICE WOR K! SEE EXPLODED DIAGRA M (ILLUSTRATION 4) FOR PARTS REF ERENCE Parts Orders: (800) 516-3636 www.englanderstoves.com Questions: (800) 245-6489 NOTE: Visit our web site for downloadable maintenance sheets and/or a service video that details and illustrates the following maintenance task ...

  • England's Stove Works 55-TRP22E - page 15

    15 Convection Blower The Convection (room air) Blower (Part # PU-4C447 ) is located on the left side of the unit and can be removed by disconnecting the power leads and removing the four mounting screws. Once this is done, the blower will slide out of the stove. This procedure can be reversed to install a new blower. Combustion Blower To clean or r ...

  • England's Stove Works 55-TRP22E - page 16

    16 Control Board The Control Board (Part #PU-CB04) is a digital read-out board. This board offers a wide variety of settings to operate the unit. This part can be removed from the unit by loosening the two outside screws and pulling the board back to the inside of the stove. The rear access p anel should be removed prior to removing the control boa ...

  • England's Stove Works 55-TRP22E - page 17

    17 CAUTION: Moving Parts May Cause Injury. Do NOT Operate with Panel(s) Off. DANGER: Parts May Be Hot. Risk of Electric Shock. Disconnect Power Before Servicing Unit. Illustration 2b Control Board Diagram (Wiring) Notes on termination of Pellet Vent Pipe (see also “FLUE SYSTEM” sectio n of manual) : 1. Not less than three (3) feet above any for ...

  • England's Stove Works 55-TRP22E - page 18

    18 Adjusting your Hopper Lid Latches The seals around the top of the pellet hopper are important to safe and efficient operation of the unit. The latches installed on these units are designed to pull the hopper lid tight against this seal. Over the course of operation as these seals “wear in” and compress, the tensio n of the latches should be ...

  • England's Stove Works 55-TRP22E - page 19

    19 ACCESSORY ITEMS The following accessories can be added to your unit at anytime after purchase; however, let the unit cool down before adding any accessories. Thermostats WALL: An external wall thermostat (such as our Part # G U-1E30-914 ) can be used on our pellet units as long as it is a low-voltage that wor ks with millivolt systems. After unp ...

  • England's Stove Works 55-TRP22E - page 20

    20 REPLACEMENT PARTS, ACCESSORIES AND OPTIONS AC-GGK Glass Gasket Kit (gasket only, no glass) AC-DGKC Door Gasket Kit (#2 on diagram) AC-114 Brass Louvers (#26 on diagram) (2001 and later Models; for earlier models call 800-245-6489 for AC-112 louvers) AC-114BN Nickel Louvers (#26 on diagram) AC-G9 9” x 9” Glass with Gasket (#3 on diagram) AC-S ...

  • England's Stove Works 55-TRP22E - page 21

    21 Pellet Stove – Exploded View Diagram Illustration 4 Dimensions of your pellet unit: 28 ½”W x 30”H x 28 ½”D 375 lbs. (Approx. 13 ½” height from floor to center of exhaust) ...

  • England's Stove Works 55-TRP22E - page 22

    22 TROUBLE-SHOOTING GUIDE WARNING: TO AVOID EL ECTRICAL SHOCK ALWAYS DI SCONNECT THE UNIT FROM THE POWER SOURCE BEFORE ATT EMPTING ANY REPAIR. IF THIS GUIDE DOES NOT CORRECT THE PROBLEM CALL YOUR LOCAL DEAL ER OR O UR TECHNICAL SUPPORT AT 1-800-245-6489. Problem Cause Solution 1. Auger not turning 1. Loose set scr ew 1. Tighten setscrew on collar 2 ...

  • England's Stove Works 55-TRP22E - page 23

    23 Have this information on hand if you phone the factory or your dealer regarding this product. Retain for your files: Model Number __________________________ Date of Purchase ________________________ Date of Manufacture _____________________ Serial #_____________________ LIMITED 5 YEAR WARRANTY FROM THE DATE OF PURCHASE TO THE ORIGINAL OWNER The ...

  • England's Stove Works 55-TRP22E - page 24

    24 ...

  • England's Stove Works 55-TRP22E - page 25

    25 WARRANTY REGISTRATION for England’s Stove Works Purchased by (Name) ______________________________________________ Address _________________________________________________________ City ________________________ State __________ Zip _________________ Telephone _______________________________________________________ Email Address _______________ ...

Fabricant England's Stove Works Catégorie Stove

Les documents que nous recevons du fabricant de l'appareilEngland's Stove Works 55-TRP22E peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques England's Stove Works
- manuels d’utilisations 55-TRP22E
- fiches produit England's Stove Works
- dépliants
- ou étiquettes-énergie England's Stove Works 55-TRP22E
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation England's Stove Works 55-TRP22E.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation England's Stove Works 55-TRP22E, manuels d’entretien, brefs manuels ou manuels de l’utilisateur England's Stove Works 55-TRP22E. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit England's Stove Works 55-TRP22E.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil England's Stove Works 55-TRP22E, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser England's Stove Works 55-TRP22E par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs England's Stove Works 55-TRP22E.

Le manuel d’utilisation complet England's Stove Works, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel England's Stove Works 55-TRP22E - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières England's Stove Works 55-TRP22E, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lEngland's Stove Works 55-TRP22E qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil England's Stove Works 55-TRP22E - qui devraient nous aider dans les premières étapes lors de l'utilisation England's Stove Works 55-TRP22E
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de England's Stove Works 55-TRP22E
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service England's Stove Works 55-TRP22E dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de England's Stove Works 55-TRP22E?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec England's Stove Works 55-TRP22E, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec England's Stove Works 55-TRP22E il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)