English dropdown-ico

Manual England's Stove Works 55-TRP22E

25 pages 1.12 mb
Download

Go to site of 25

Summary
  • England's Stove Works 55-TRP22E - page 1

    INSTALLATION & OPERATION MANUAL MODEL NUMBERS: 25-PDV 55-SHP22 55-TRP22 25-PDVE 55-SHP22E 55-TRP22E Thank you for purchasing this product from a fine line of heating equipment. We wish you many years of safe heating pleasure with your new heating appliance. Save These Instructions. IMPORTANT: IF YOU HAVE A PROBLEM WITH THIS UNIT DO NOT RETURN I ...

  • England's Stove Works 55-TRP22E - page 2

    2 A letter from our Technical Support department : Thank you for purchasing this fine produ ct from England’s Stove Works! England's Stove Works was started, a nd is still owned by, a family that believes strongly in a "Do It Yoursel f" spirit – that’s one reason you found this product at your favorite “Do It Yourself” stor ...

  • England's Stove Works 55-TRP22E - page 3

    3 IMPORTANT INFORMATION 1. Check local installation codes for your area. C all your Homeowner’s Insurance representative for inspection of your stove’s installation. 2. Read and comply with the instructions in this manual. 3. This unit should be tested (dry run) before load ing pellets for 20 minutes. The st ove should automatically shut itself ...

  • England's Stove Works 55-TRP22E - page 4

    4 14. Do not allow paint, chemicals or construction dust on or near your unit. Do not allow liquid or ANY foreign materials on or inside your unit. Shut your unit down and cover it when painting, construction or similar activity is taking place. Wipe and clean your unit after any construction is done in your home, or if any foreign material gets on ...

  • England's Stove Works 55-TRP22E - page 5

    5 Proper Impingement (Baffle) Plate Placement in Pellet Stove Firebox Occasionally in shipping, the impingement (baffle) plate may shift out of its proper position. If this is the case with your stove, follow these instructions to r eturn the plate to its proper position. 1. Remove the plate from the stove, holding the plate by its tab handle, with ...

  • England's Stove Works 55-TRP22E - page 6

    6 FLUE SYSTEM Caution: Follow the pipe manufacturer’s installation instructions and directions for pas sing through combustible walls and ceilings. Be sure to check local codes in your area. NOTE : See the installation drawing later in this manual (Illustration 1). This unit is equipped with a negative draft system that pulls combustion air throu ...

  • England's Stove Works 55-TRP22E - page 7

    7 Through the Ceiling When venting the stove through the ceiling, the pipe is connected the same as through the wall, except the clean out tee is always on the inside of the house, and a 3” adapter is ad ded before the clean-out tee. You must use the proper ceiling support flanges and roof flash ing supplied by the pipe manufacturer -- follow the ...

  • England's Stove Works 55-TRP22E - page 8

    8 FLOOR AND WALL PROTECTION Floor Protection If your floor is constructed of a non-combustible ma terial such as brick or concrete, there is no need for floor protection. If the floor is constructed of a combustible material such as hardwood, linoleum, or carpet, then you will be required to use floor protection between the unit and the combustible ...

  • England's Stove Works 55-TRP22E - page 9

    9 OPERATING INSTRUCTIONS CAUTION: DO NOT OPERATE WITH THE DOOR OPEN. If door is left open (approximately ) two minut es, unit will stop feeding and fire will go out. Do not burn trash (paper bags, etc.) in this unit. This stove has an induced draft system and is designed to operate continuously, as frequent shutdown is not required. The digital con ...

  • England's Stove Works 55-TRP22E - page 10

    10 E-Codes “E-Codes,” or Error Codes, are codes that will appear in the Heat Range and Blower Speed windows of the Control Board if your unit experiences problems. If you receive any of these codes, first attempt to reset your unit by pressing the “ON” button (only once). If the unit continues to display any E-Code(s), please contact Techni ...

  • England's Stove Works 55-TRP22E - page 11

    11 DAILY OPERATION Refueling the Unit Always press the “OFF” touch pad before refueling. This stove has a (approximately) 60-lb. hopper, and should be refilled when the hopper level drops to three or four inches. Note : The hopper lid will be warm; therefore, you should always use some type of hand protection. NEVER place your hand near the aug ...

  • England's Stove Works 55-TRP22E - page 12

    12 ASH REMOVAL AND DISPOSAL IMPORTANT: While the amount of ash generated by this unit is not excessive compared to log-burning woodstoves, keeping the unit clean and free of ash is essential for peak performance. Too much ash build-up hampers airflow and reduces the unit’s efficiency, and can cause smoke-back. Follow these directions at least as ...

  • England's Stove Works 55-TRP22E - page 13

    13 Monthly Ash Removal The large baffle plate (12-5/8” x 9-3/8”) that rests above and behind the burn pot (refer to the section on “Proper Impingement Plate Placement” and the exploded diagram in t he rear of this manual – Illustration 4) should be removed monthly. This can be done by lifting up the plate and pulling it out. The area behi ...

  • England's Stove Works 55-TRP22E - page 14

    14 MAINTENANCE CAUTION: UNPLUG THE UNIT PRIOR TO ANY SERVICE WOR K! SEE EXPLODED DIAGRA M (ILLUSTRATION 4) FOR PARTS REF ERENCE Parts Orders: (800) 516-3636 www.englanderstoves.com Questions: (800) 245-6489 NOTE: Visit our web site for downloadable maintenance sheets and/or a service video that details and illustrates the following maintenance task ...

  • England's Stove Works 55-TRP22E - page 15

    15 Convection Blower The Convection (room air) Blower (Part # PU-4C447 ) is located on the left side of the unit and can be removed by disconnecting the power leads and removing the four mounting screws. Once this is done, the blower will slide out of the stove. This procedure can be reversed to install a new blower. Combustion Blower To clean or r ...

  • England's Stove Works 55-TRP22E - page 16

    16 Control Board The Control Board (Part #PU-CB04) is a digital read-out board. This board offers a wide variety of settings to operate the unit. This part can be removed from the unit by loosening the two outside screws and pulling the board back to the inside of the stove. The rear access p anel should be removed prior to removing the control boa ...

  • England's Stove Works 55-TRP22E - page 17

    17 CAUTION: Moving Parts May Cause Injury. Do NOT Operate with Panel(s) Off. DANGER: Parts May Be Hot. Risk of Electric Shock. Disconnect Power Before Servicing Unit. Illustration 2b Control Board Diagram (Wiring) Notes on termination of Pellet Vent Pipe (see also “FLUE SYSTEM” sectio n of manual) : 1. Not less than three (3) feet above any for ...

  • England's Stove Works 55-TRP22E - page 18

    18 Adjusting your Hopper Lid Latches The seals around the top of the pellet hopper are important to safe and efficient operation of the unit. The latches installed on these units are designed to pull the hopper lid tight against this seal. Over the course of operation as these seals “wear in” and compress, the tensio n of the latches should be ...

  • England's Stove Works 55-TRP22E - page 19

    19 ACCESSORY ITEMS The following accessories can be added to your unit at anytime after purchase; however, let the unit cool down before adding any accessories. Thermostats WALL: An external wall thermostat (such as our Part # G U-1E30-914 ) can be used on our pellet units as long as it is a low-voltage that wor ks with millivolt systems. After unp ...

  • England's Stove Works 55-TRP22E - page 20

    20 REPLACEMENT PARTS, ACCESSORIES AND OPTIONS AC-GGK Glass Gasket Kit (gasket only, no glass) AC-DGKC Door Gasket Kit (#2 on diagram) AC-114 Brass Louvers (#26 on diagram) (2001 and later Models; for earlier models call 800-245-6489 for AC-112 louvers) AC-114BN Nickel Louvers (#26 on diagram) AC-G9 9” x 9” Glass with Gasket (#3 on diagram) AC-S ...

  • England's Stove Works 55-TRP22E - page 21

    21 Pellet Stove – Exploded View Diagram Illustration 4 Dimensions of your pellet unit: 28 ½”W x 30”H x 28 ½”D 375 lbs. (Approx. 13 ½” height from floor to center of exhaust) ...

  • England's Stove Works 55-TRP22E - page 22

    22 TROUBLE-SHOOTING GUIDE WARNING: TO AVOID EL ECTRICAL SHOCK ALWAYS DI SCONNECT THE UNIT FROM THE POWER SOURCE BEFORE ATT EMPTING ANY REPAIR. IF THIS GUIDE DOES NOT CORRECT THE PROBLEM CALL YOUR LOCAL DEAL ER OR O UR TECHNICAL SUPPORT AT 1-800-245-6489. Problem Cause Solution 1. Auger not turning 1. Loose set scr ew 1. Tighten setscrew on collar 2 ...

  • England's Stove Works 55-TRP22E - page 23

    23 Have this information on hand if you phone the factory or your dealer regarding this product. Retain for your files: Model Number __________________________ Date of Purchase ________________________ Date of Manufacture _____________________ Serial #_____________________ LIMITED 5 YEAR WARRANTY FROM THE DATE OF PURCHASE TO THE ORIGINAL OWNER The ...

  • England's Stove Works 55-TRP22E - page 24

    24 ...

  • England's Stove Works 55-TRP22E - page 25

    25 WARRANTY REGISTRATION for England’s Stove Works Purchased by (Name) ______________________________________________ Address _________________________________________________________ City ________________________ State __________ Zip _________________ Telephone _______________________________________________________ Email Address _______________ ...

Manufacturer England's Stove Works Category Stove

Documents that we receive from a manufacturer of a England's Stove Works 55-TRP22E can be divided into several groups. They are, among others:
- England's Stove Works technical drawings
- 55-TRP22E manuals
- England's Stove Works product data sheets
- information booklets
- or energy labels England's Stove Works 55-TRP22E
All of them are important, but the most important information from the point of view of use of the device are in the user manual England's Stove Works 55-TRP22E.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals England's Stove Works 55-TRP22E, service manual, brief instructions and user manuals England's Stove Works 55-TRP22E. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product England's Stove Works 55-TRP22E.

Similar manuals

A complete manual for the device England's Stove Works 55-TRP22E, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use England's Stove Works 55-TRP22E by users. Manuals are usually written by a technical writer, but in a language understandable to all users of England's Stove Works 55-TRP22E.

A complete England's Stove Works manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual England's Stove Works 55-TRP22E - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the England's Stove Works 55-TRP22E, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the England's Stove Works 55-TRP22E, that we can find in the current document
3. Tips how to use the basic functions of the device England's Stove Works 55-TRP22E - which should help us in our first steps of using England's Stove Works 55-TRP22E
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with England's Stove Works 55-TRP22E
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of England's Stove Works 55-TRP22E in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning England's Stove Works 55-TRP22E?

Use the form below

If you did not solve your problem by using a manual England's Stove Works 55-TRP22E, ask a question using the form below. If a user had a similar problem with England's Stove Works 55-TRP22E it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)