Italiano dropdown-ico

Manuale per l’uso United States Stove VF30IL

28 pagine 0.81 mb
Scarica

Vai alla pagina of 28

Summary
  • United States Stove VF30IL - page 1

    1 WARNINGS WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. WHAT TO DO IF YOU SMELL GAS • Do not try to light any appliance. ...

  • United States Stove VF30IL - page 2

    2 TABLE OF CONTENTS IMPORTANT SAFETY INFORMATION.............................................................3-4 PRODUCT FEATURES...........................................................................................4 SPECIFICATIONS......................................................................................................5 CONTENTS.. ...

  • United States Stove VF30IL - page 3

    3 CARBON MONOXIDE POISONING: Early signs of carbon monoxide poisoning are similar to the flu with headaches, dizziness and/or nausea. If you have these signs, obtain fresh air immediately. Have the heater serviced as it may not be operating properly. The installation must conform with local codes or, in the absence of local codes, with the National ...

  • United States Stove VF30IL - page 4

    4 IMPORTANT SAFETY INFORMATION Outside air ducts in the fireplace shall be permanently closed at the time of appliance installation. Keep appliance area clear and free from combustible materials, gasoline and other flammable vapors and liquids. Fireplace screen must be closed during operation of the heater. This vent-free gas heater is intended to ...

  • United States Stove VF30IL - page 5

    5 SPECIFICATIONS Natural Gas Manifold Pressure Setting 4" w.c. Gas Inlet Pressure Maximum 10-1/2" w.c. Minimum 5" w.c. Gas Rate Number Model Number Type Max BTU/Hr Min BTU/Hr of Burners VF30IN Manual 30,000 16,000 1 Propane / LPG Note: An external regulator is required to reduce supply pressure to a maximum of 13" w.c. Manifold ...

  • United States Stove VF30IL - page 6

    6 UNIT DIMENSIONS MINIMUM AND MAXIMUM SIZE OF FIREPLACE DI ME N S I ON MI NI MU M MA X I MU M A 26" 44" B 22- 1/ 4" 32" C 13- 1/ 4" 24" ...

  • United States Stove VF30IL - page 7

    7 ITEMS REQUIRED FOR INSTALLATION ITEMS REQUIRED FOR INSTALLATION Ensure that the following items are available before proceeding with installation: • External regulator (for propane/LPG only) • Manual shutoff valve • Piping which complies with local codes • Sediment trap • Pipe sealant approved for use with • Pipe wrench propane/LPG (r ...

  • United States Stove VF30IL - page 8

    8 Providing adequate ventilation The following is excerpts from National Fuel Gas Code. NFPA 54/ANSI Z223.1, Section 5.3, Air for Combustion and Ventilation. All spaces in homes fall into one of the three following ventilation classifications: 1. Unusually Tight Construction; 2. Unconfined Space; 3. Confined Space. The information on pages 7 throug ...

  • United States Stove VF30IL - page 9

    9 Determining if You Have a Confined or Unconfined Space Use this worksheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install the firebox plus any adjoining rooms with doorless passageways or ventilation grills between the rooms. 1. Determine the volume of the space (length x width x height) ...

  • United States Stove VF30IL - page 10

    10 B. Vent room directly to the outdoors. See Ventilation Air from Outdoors , page 11. C. Install a lower BTU/Hr firebox, if lower BTU/Hr size makes room unconfined. If the actual BTU/Hr used is less than the maximum BTU/Hr the space can support, the space is an unconfined space. You will need no additional fresh air ventilation. WARNING If the are ...

  • United States Stove VF30IL - page 11

    11 WARNING Maintain these clearances to ensure adequate space around air opening for proper operation. Minimum clearances to combustibles: Sides of heater...........................8" MIN Front of heater.........................60" MIN Top of heater............................50" MIN Top to Mantel...........................18" M ...

  • United States Stove VF30IL - page 12

    12 INSTALLING TOP SURROUND & BRASS TRIM INSTALLING TOP SURROUND N OTE : YOU WILL NEED A FLATHEAD SCREW - DRIVER AND A 3/8" NUT - DRIVER TO ATTACH THE SURROUND AND BRASS TRIM . The top surround is shipped unassembled for shipping purposes only. To install the top surround place the surround on top of the unit and line up the holes. Attach t ...

  • United States Stove VF30IL - page 13

    13 PREPARING FIREPLACE WARNING: IF THIS APPLIANCE IS INSTALLED IN A FACTORY-BUILT FIREPLACE, DO NOT BLOCK OR RESTRICT ANY OF THE GRILLES ON THE FACTORY-BUILT FIREPLACE. THE GRILLES ALLOW AIR CIRCULATION WHICH PREVENTS THE FACTORY-BUILT FIREPLACE FROM OVERHEATING. BLOCKING OR RESTRICTING THE AIR CIRCULATION CAN CAUSE A FIRE HAZARD. Preparing Firepla ...

  • United States Stove VF30IL - page 14

    14 GAS CONNECTION A qualified gas appliance installer must connect the fireplace to the gas supply. Consult all local codes. Use new black iron or steel pipe only. Internally tinned copper tubing can be used in some areas when permitted by local codes. Only use pipe of 1/2" or greater diameter to allow full gas volume to heater. Excessive pres ...

  • United States Stove VF30IL - page 15

    15 The heater regulator controls the burner pressure which should be checked at the pressure test point located on the right side of the main control and is accessible from the side of the gas log assembly (see FIGURE 6). The pressure should be checked with the heater burning and the control set to high (HI). The pressure regulator is preset and lo ...

  • United States Stove VF30IL - page 16

    16 WIRING BLOWER ASSEMBLY To locate the blower, open the lower access door and locate the blower cover as shown in FIGURE 7. The blower is located directly behind the blower cover. The blower comes partially pre-wired into the junction box. To complete wiring, run the house power supply into the heater through one of the knockouts located on either ...

  • United States Stove VF30IL - page 17

    17 LOGS AND LOG STOP ASSEMBLY LOG POSITIONING This unit is supplied with a set of four ceramic fiber logs. Do not handle these logs with your bare hands! Always wear gloves to prevent skin irritation from ceramic fibers. After handling logs, wash your hands gently with soap and water to remove any traces of fibers. PROPER INSTALLATION SEQUENCE: 1. ...

  • United States Stove VF30IL - page 18

    18 OPERATING INSTRUCTIONS Avoid any drafts that alter the burner flame patterns. Do not allow fans to blow directly into the heater. Do not place a blower inside burn area of firebox. Ceiling fans may create drafts that alter burner flame patterns. Sooting and improper burning will occur. This unvented gas heater is intended to be smokeless. If log ...

  • United States Stove VF30IL - page 19

    19 6. Push in the control (knob 1) all the way and rotate counter-clockwise to "PILOT". The piezo ignitor will light the pilot as the knob passes "IGN" traveling to the "PILOT". Con tinue to hold the control (knob 1) in for about ten (10) seconds after the pilot is lit. Release knob and it should pop back up. Pilot sho ...

  • United States Stove VF30IL - page 20

    20 OPERATING INSTRUCTIONS Wait 30 seconds before readjusting the heater when the control has been turned down to a lower setting. WARNING PILOT FLAME The pilot flame should always be present when the heater is in operation and should just touch the top of the thermocouple tip (FIGURE 9). If the pilot flame does not touch the thermocouple, then the ...

  • United States Stove VF30IL - page 21

    21 CLEANING / SERVICING Periodic Cleaning • Do not use cleaning fluid to clean logs or any part of heater. • Logs - Brush with soft bristle brush or vacuum with brush attachment. • Vacuum loose particles and dust from the front and rear burner, control, and piezo. • Inspect burner's and air intake hole. Remove lint or particles with va ...

  • United States Stove VF30IL - page 22

    22 HEATER ASSEMBLY REPLACEMENT PARTS ...

  • United States Stove VF30IL - page 23

    23 PARTS LIST FOR HEATER ASSEMBLY KEY PART # DESCRIPTION QTY. 1 24731 CABINET BOTTOM 1 2 24732 FIREBOX 1 3 24733 FIREBOX BOTTOM 1 4 24734 INNER TOP 1 5 24735 OUTER TOP 1 6 69184 BLOWER CHANNEL 1 7 24738 DIVIDER 1 8 80337 120 CRM BLOWER 1 9 24759 BLOWER BASE 1 10 24761 BLOWER COVER 1 N/S 89390A 3/8" RUBBER GROMMET 1 11 24739 FRONT BRACE 1 12 24 ...

  • United States Stove VF30IL - page 24

    24 BURNER & LOG ASSEMBLY ...

  • United States Stove VF30IL - page 25

    25 PARTS LIST FOR GAS LOG ASSEMBLY KE Y PA R T # D ESC R I PT I ON QT Y . 1 24751 B URNE R P L A T E 1 2 24752 C O N T R O L BR AC KET 1 3 81195 CO NT RO L V A L V E ( NA T URA L ) 1 81196 CO NT RO L V A L V E ( L. P. ) 1 4 83251 10- 24 x 1 SL RO D 2 5 83244 10- 2 4 KEP N U T 2 6 89831 BU R N ER / CO NT RO L FI TTI NG 1 7 24754 PI L O T BR AC KET 1 ...

  • United States Stove VF30IL - page 26

    26 TROUBLESHOOTING Turn off and let cool before servicing. Only a qualified service person should service and repair heater. NOTE: All troubleshooting items are listed in order of operation. REMEDY POSSIBLE CAUSE OBSERVED PROBLEM When ignitor button is pressed, there is no spark at ODS/Pilot. • Ignitor electrode positioned wrong • Ignitor elect ...

  • United States Stove VF30IL - page 27

    27 TROUBLESHOOTING, CONTINUED... ODS/Pilot lights, but flame goes out When control knob is released. (continued from page 25) One or both burner do not light after ODS/pilot is lit. Burner backfires during combustion. Slight smoke or odor during initial operation. Logs appear to smoke after initial operation. Heater produces a whistling noise when ...

  • United States Stove VF30IL - page 28

    28 OWNERS MANUAL HOW TO ORDER REPAIR PARTS OR "OPTIONS" UNITED STATES STOVE COMPANY 227 Industrial Park Rd., P.O. Box 151 South Pittsburg, TN 37380 (423) 837-2100 C O M P A N Y U N I T E D S T A T E S S T O V E C S S U BEFORE INSTALLING YOUR HEATER, FILL IN THE SERIAL NUMBER IN THE SPACE PROVIDED ABOVE FOR YOUR RECORDS. 1. The PART NUMBER ...

Fabbricante United States Stove Categoria Gas Heater

I documenti che otteniamo dal fabbricante del dispositivoUnited States Stove VF30IL possono essere suddivisi in diversi gruppi. Questi sono tra gli altri:
- disegni tecnici United States Stove
- manuali per l’uso VF30IL
- schede prodotto United States Stove
- opuscoli
- o etichette energetiche United States Stove VF30IL
Tutti sono importanti, ma le informazioni più importanti dal punto di vista di utilizzo del dispositivo possono essere trovate nel manuale per l’uso United States Stove VF30IL.

Un gruppo di documenti denominato manuali per l’uso, è anche suddiviso in tipi più specifici, come: Manuali di installazione United States Stove VF30IL, manuali di manutenzione, brevi manuali o manuali utente United States Stove VF30IL. A seconda delle esigenze, si dovrebbe cercare il documento necessario. Nel nostro sito web, puoi visualizzare il manuale più popolare per l'uso del prodotto United States Stove VF30IL.

Manuali per l’uso simili

Manuale completo del dispositivo United States Stove VF30IL, come deve essere?
Il manuale per l’uso, denominato anche istruzioni per l’uso, o semplicemente il manuale è un documento tecnico progettato per aiutare ad utilizzare United States Stove VF30IL dagli utenti. I manuali sono di solito scritti da uno scrittore tecnico, ma in un linguaggio accessibile a tutti gli utenti United States Stove VF30IL.

Il manuale per l’uso completo United States Stove, dovrebbe includere vari elementi di base. Alcuni di loro sono meno importanti, come ad esempio: copertina / pagina del titolo o pagina di autore. Tuttavia, la parte rimanente, dovrebbe fornire informazioni importanti dal punto di vista dell'utente.

1. Introduzione e la guida su come utilizzare il manuale United States Stove VF30IL - All'inizio di ogni manuale, dovremmo trovare indizi su come utilizzare il documento. Dovrebbe contenere informazioni sulla posizione dell’indice United States Stove VF30IL, FAQ o i problemi più comuni : i punti che sono più spesso cercati dagli utenti di ogni manuale
2. Indice - elenco di tutti i suggerimenti per United States Stove VF30IL che possono essere trovati nel documento corrente
3. Suggerimenti su come utilizzare le funzioni di base del dispositivo United States Stove VF30IL - che ci dovrebbe aiutare nei primi passi durante l'uso United States Stove VF30IL
4. Troubleshooting - sequenza sistematica delle attività che vi aiuterà a diagnosticare e, successivamente, risolvere i problemi più importanti del United States Stove VF30IL
5. FAQ - domande più frequenti
6. Dettagli di contatto Informazioni su dove cercare il contatto con il fabbricante / servizio United States Stove VF30IL in un dato paese, se il problema non può essere risolto da noi stessi.

Hai una domanda su United States Stove VF30IL?

Utilizza il modulo sottostante

Se non hai risolto il problema con United States Stove VF30IL con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con United States Stove VF30IL è probabile che voglia condividere il modo di risolverlo.

Riscrivi il testo dall’immagine

Captcha
Nuova immagine

Commenti (0)