Italiano dropdown-ico

Manuale per l’uso Burnham CHG225

72 pagine 5.88 mb
Scarica

Vai alla pagina of 72

Summary
  • Burnham CHG225 - page 1

    Models: • CHG150 • CHG225 W ARNING : Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury , or loss of life. For assistance or additional information, consult a qualied installer , service agency or the gas supplier . This boiler requires a special venting system. Read these instructions car ...

  • Burnham CHG225 - page 2

    2 T able of Contents I. Product Description .................................................................. 3 II. Specications ........................................................................... 3 III. Before Installing ........................................................................ 4 IV . Locating The Boiler ................ ...

  • Burnham CHG225 - page 3

    3 T able 2.2: Specications MODEL* NO. OF SECTIONS MAXIMUM INPUT (BTU/hr) MINIMUM INPUT (BTU/hr) D.O.E. HEA TING CAP ACITY (BTU/hr) IBR NET RA TING (BTU/hr) AFUE (%) VENT COLLAR DIAMETERS (IN.) INLET EXHAUST CHG150 3 150,000 30,000 135,000 1 17,000 93.1 4 3 CHG225 4 225,000 56,250 202,000 176,000 94.2 4 4 * MODELS SHOWN ARE FOR NA TURAL GAS. ADD ...

  • Burnham CHG225 - page 4

    4     ...

  • Burnham CHG225 - page 5

    5 T able 4.2: Clearances From V ent Piping T o Combustible Construction TYPE OF VENT PIPE PIPE DIRECTION ENCLOSURE MINIMUM CLEARANCE TO COMBUSTIBLE MA TERIAL BURNHAM AL29-4C    HEA T F AB SAF-T VENT PROTECH F ASNSEAL Z-FLEX Z-VENT III FLEX-L ST AR-34 VER TICAL OR HORIZONT AL A T LEAST ONE SIDE OPEN, COMBUSTIBLE MA TERI ...

  • Burnham CHG225 - page 6

    6 W ARNING OUTDOOR COMBUSTION AIR MUST BE PIPED T O THE AIR INT AKE. NEVER PIPE COMBUSTION AIR FROM AREAS CONT AINING CONT AMINA TES SUCH AS SWIMMING POOLS AND LAUNDR Y ROOM EXHAUST VENTS. CONT AMINA TED COMBUSTION AIR WILL DAMAGE THE BOILER     ...

  • Burnham CHG225 - page 7

    7 Figure 5.1: Boiler Installed In A Conned Space, V entilation Air From Inside ? ...

  • Burnham CHG225 - page 8

    8    W ARNING   ? ...

  • Burnham CHG225 - page 9

    9 3)    4)  ? ...

  • Burnham CHG225 - page 10

    10 T able 6.2a: Summary of Horizontal V enting Options VENT OPTION # 1 2 3  5 CLASSIFICA TION USED IN THIS MANUAL HORIZONT AL DIRECT VENT HORIZONT AL DIRECT VENT (RESER VED FOR FUTURE USE) (RESER VED FOR FUTURE USE) (RESER VED FOR FUTURE USE) ILLUSTRA TED IN FIGURE 6.1 6.1 VENT PIPE STRUCTURE PENETRA TION W ALL W ALL AIR INT AKE PIPE STRUCTURE P ...

  • Burnham CHG225 - page 11

    1 1 T able 6.2b: Summary of V ertical V enting Options VENT OPTION # 6 7 CLASSIFICA TION USED IN THIS MANUAL VER TICAL DIRECT VENT VER TICAL DIRECT VENT ILLUSTRA TED IN FIGURE 6.4 6.4 VENT PIPE STRUCTURE PENETRA TION ROOF ROOF AIR INT AKE PIPE STRUCTURE PENETRA TION ROOF ROOF VENT PIPE SIZE 3” 4” AIR INT AKE PIPE SIZE 4” 4” MAXIMUM VENT PIP ...

  • Burnham CHG225 - page 12

    12 Figure 6.3a: Location of V ent T erminal Relative to Windows, Doors, Grade Figure 6.3b: Location of V ent T erminal Relative to Meters and Forced Air Inlets Figure 6.3c: Positioning V ent T erminal Under Overhangs ...

  • Burnham CHG225 - page 13

    13    ...

  • Burnham CHG225 - page 14

    14 VENT SYSTEM COMPONENT P ART NUMBER EQUIV ALENT FEET OF PIPE 3” DIA. PIPE X 1 FT .   1 4” DIA. PIPE X 1 FT . 100176-01 3” DIA. PIPE X 3 FT .   3 4” DIA. PIPE X 3 FT . 100177-01 3” DIA. PIPE X 5 FT .   5 4” DIA. PIPE X 5 FT .  3”  ...

  • Burnham CHG225 - page 15

    15    ? ...

  • Burnham CHG225 - page 16

    16 2)    ®  ? ...

  • Burnham CHG225 - page 17

    17 Figure 6.7b: Star-34 Connections l)  Cuttheexcessjoinerbandsothatitlaysatinthebeadedchannel(Fig6.7b). m) Filltheinletofthebeadedchannelwithsilicone.Smooththesiliconeoverthechannelinletaswellasthe  siliconebetween ...

  • Burnham CHG225 - page 18

    18 Figure 6.8: Z-V ent III Connection to V ent Collar  ? ...

  • Burnham CHG225 - page 19

    19 Figure 6.9: SAF-T V ent Ezseal Connection to V ent Collar 7)      ...

  • Burnham CHG225 - page 20

    20 Figure 6.10: FasNSeal Connection to V ent Collar  1)  ? ...

  • Burnham CHG225 - page 21

    21 W ARNING BOILER CONDENSA TE IS CORROSIVE. ROUTE CONDENSA TE DRAIN LINE IN A MANNER SUCH THA T ANY CONDENSA TE LEAKAGE WILL NOT CAUSE PROPER TY DAMAGE. SOME JURISDICTIONS MA Y REQUIRE THA T CONDENSA TE BE NEUTRALIZED PRIOR T O DISPOSAL. Figure 6.1 1: Condensate Piping Arrangement ...

  • Burnham CHG225 - page 22

    22    ...

  • Burnham CHG225 - page 23

    23   CAUTION THE HEA T EXCHANGER USED IN THE CHG IS MADE FROM A SPECIAL ALUMINUM ALLOY .     ...

  • Burnham CHG225 - page 24

    24    ...

  • Burnham CHG225 - page 25

    25 Figure 8.3: Piping Method #1 - Heat + Indirect W ater Heater Figure 8.2: Piping Method #1 - Heat Only ...

  • Burnham CHG225 - page 26

    26 Figure 8.4b: Piping Method #1 - Indirect W ater Heater Loop Piping (Shaded) Figure 8.4a: Piping Method #1 - Secondary Loop Piping (Shaded) ...

  • Burnham CHG225 - page 27

    27 T able 8.5: Pipe and Circulator Sizing for Boiler Loop BOILER MODEL (a)    PIPE SIZE FLOW CIRCULA TOR MODEL BOILER LOOP MAX EqUIV ALENT LENGTH (in NPT) (GPM)  CHG150 1 1/4     CHG150 1 1/4    224 CHG225 1 1/4 12.0   ...

  • Burnham CHG225 - page 28

    28                           ...

  • Burnham CHG225 - page 29

    29 Figure 8.8: Piping Method #2 - Heat Only Figure 8.9: Piping Method #2 - Heat + Indirect W ater Heater ...

  • Burnham CHG225 - page 30

    30 Figure 8.10a: Piping Method #2 - Secondary Loop Piping (Bolded) Figure 8.10b: Piping Method #2 - Primary Loop Piping (Bolded) ...

  • Burnham CHG225 - page 31

    31 Figure 8.10c: Piping Method #2 - Indirect W ater Heater Loop Piping (Bolded) Figure 8.1 1: Piping Method #3 - Direct Connection of Boiler to Heating System ...

  • Burnham CHG225 - page 32

    32  ? ...

  • Burnham CHG225 - page 33

    33  ? ...

  • Burnham CHG225 - page 34

    34 Figure 8.14: Chiller Piping Figure 8.13: Isolation of the Boiler From Oxygenated W ater with A Plate Heat Exchanger ...

  • Burnham CHG225 - page 35

    35       ...

  • Burnham CHG225 - page 36

    36 Figure 9.1: Wiring Connections Diagram ...

  • Burnham CHG225 - page 37

    37 Figure 9.2: Ladder Diagram ...

  • Burnham CHG225 - page 38

    38 Figure 9.3: Wiring of Isolation Relay for Control of T wo Heating Circulators ...

  • Burnham CHG225 - page 39

    39    ? ...

  • Burnham CHG225 - page 40

    40  ...

  • Burnham CHG225 - page 41

    41    ...

  • Burnham CHG225 - page 42

    42 Figure 10.2: Gas V alve Detail   ? ...

  • Burnham CHG225 - page 43

    43        ? ...

  • Burnham CHG225 - page 44

    44    ...

  • Burnham CHG225 - page 45

    45   ...

  • Burnham CHG225 - page 46

    46 Figure 1 1.2: Basic Menu T ree ...

  • Burnham CHG225 - page 47

    47     ? ...

  • Burnham CHG225 - page 48

    48 Figure 1 1.4: Outdoor Reset Curve 7)   ? ...

  • Burnham CHG225 - page 49

    49  IMPOR T ANT W ARRANTY DOES NOT COVER BOILER DAMAGE OR MALFUNCTION IF THE FOLLOWING STEPS ARE NOT PERFORMED A T THE INTER V ALS SPECIFIED. 1) Continuously   ? ...

  • Burnham CHG225 - page 50

    50     ? ...

  • Burnham CHG225 - page 51

    51    A.  CONDITION POSSIBLE CAUSES Display Blank, Fan off, L WCO lights off • No 120V AC Power at boiler . Check ...

  • Burnham CHG225 - page 52

    52 B.    ...

  • Burnham CHG225 - page 53

    53 C.    ? ...

  • Burnham CHG225 - page 54

    54 SER VICE RECORD DA TE SER VICE PERFORMED ...

  • Burnham CHG225 - page 55

    55   All CHG Series Repair Parts may be obtained through your local Burnham Wholesale distributor . Should you require assistance in locating a Burnham distributor in your area, or have questions regarding the availability of Burnham products or repair parts, please contact Burnham Customer Service at (717) 481-8400 or Fax ( ...

  • Burnham CHG225 - page 56

    56 CHG REPLACEMENT P ARTS LIST KEY DESCRIPTION CHG150 CHG225 BURNHAM P ART # QUANTITY BURNHAM P ART # QUANTITY 3 #8-32 x 1/4” H.W .H. Screw 100401-01 2 100401-01 2 4 Front Door Panel 100402-01 1 100402-02 1 5 #6-32 Hex Nylon Insert LockNut 100403-01 4 100403-01 4 6 Control Chassis Assembly 100404-01 1 100404-01 1 7 .125” ID x .250”OD Silicone ...

  • Burnham CHG225 - page 57

    57 CHG REPLACEMENT P ARTS LIST KEY DESCRIPTION CHG150 CHG225 BURNHAM P ART # QUANTITY BURNHAM P ART # QUANTITY 47 Nylon Glide Foot 1”Dia x 3/4” Long 100444-01 4 100444-01 4 48 Combination Base / Rear Panel 100445-01 1 100445-02 1 49 V esibule T op Panel Assembly 100446-01 1 100446-02 1 50 V ent Seal Gasket 100447-01 1 100447-02 1 51 V ent Adapt ...

  • Burnham CHG225 - page 58

    58 ...

  • Burnham CHG225 - page 59

    59 ...

  • Burnham CHG225 - page 60

    60 ...

  • Burnham CHG225 - page 61

    61 ...

  • Burnham CHG225 - page 62

    62 CHG REPLACEMENT P ARTS LIST KEY DESCRIPTION CHG150 CHG225 BURNHAM P ART # QUANTITY BURNHAM P ART # QUANTITY 89 #6-32 x 13mm Hex x 92mm, Long Standoff 100488-01 2 100488-01 2 90 M6 x 1.0 x 75mm, Hex Head Screw 100489-01 16 100489-01 16 91 Manifold Seal Ring, EPDM 100490-01 8 100490-01 8 92 M6 x 1.0 x 30mm, SS Hex Socket Set Screw 100491-01 6 1004 ...

  • Burnham CHG225 - page 63

    63 ...

  • Burnham CHG225 - page 64

    64 CHG REPLACEMENT P ARTS LIST KEY DESCRIPTION CHG150 CHG225 BURNHAM P ART # QUANTITY BURNHAM P ART # QUANTITY Not Shown 1 1-1/2” Releasable Nylon Cable Wire T ie 100533-01 1 100533-01 1 Not Shown 6” Nylon Wire T ie 100534-01 10 100534-01 1 1 Not Shown 1-5/8” Hole Plug 100535-01 1 100535-01 1 Not Shown 5mm x 20mm Fast Acting, Ceramic T ube, 5 ...

  • Burnham CHG225 - page 65

    65 ...

  • Burnham CHG225 - page 66

    66 ...

  • Burnham CHG225 - page 67

    67 ...

  • Burnham CHG225 - page 68

    68         IMPOR T ANT  ...

  • Burnham CHG225 - page 69

    69 SER VICE RECORD DA TE SER VICE PERFORMED ...

  • Burnham CHG225 - page 70

    70 SER VICE RECORD DA TE SER VICE PERFORMED ...

  • Burnham CHG225 - page 71

    71 SER VICE RECORD DA TE SER VICE PERFORMED ...

  • Burnham CHG225 - page 72

    9 EARSIN3ERVICE        3ERVICE#HARGE ASOF 2ETAIL0RICE .O #HARGE       ...

Fabbricante Burnham Categoria Boiler

I documenti che otteniamo dal fabbricante del dispositivoBurnham CHG225 possono essere suddivisi in diversi gruppi. Questi sono tra gli altri:
- disegni tecnici Burnham
- manuali per l’uso CHG225
- schede prodotto Burnham
- opuscoli
- o etichette energetiche Burnham CHG225
Tutti sono importanti, ma le informazioni più importanti dal punto di vista di utilizzo del dispositivo possono essere trovate nel manuale per l’uso Burnham CHG225.

Un gruppo di documenti denominato manuali per l’uso, è anche suddiviso in tipi più specifici, come: Manuali di installazione Burnham CHG225, manuali di manutenzione, brevi manuali o manuali utente Burnham CHG225. A seconda delle esigenze, si dovrebbe cercare il documento necessario. Nel nostro sito web, puoi visualizzare il manuale più popolare per l'uso del prodotto Burnham CHG225.

Manuali per l’uso simili

Manuale completo del dispositivo Burnham CHG225, come deve essere?
Il manuale per l’uso, denominato anche istruzioni per l’uso, o semplicemente il manuale è un documento tecnico progettato per aiutare ad utilizzare Burnham CHG225 dagli utenti. I manuali sono di solito scritti da uno scrittore tecnico, ma in un linguaggio accessibile a tutti gli utenti Burnham CHG225.

Il manuale per l’uso completo Burnham, dovrebbe includere vari elementi di base. Alcuni di loro sono meno importanti, come ad esempio: copertina / pagina del titolo o pagina di autore. Tuttavia, la parte rimanente, dovrebbe fornire informazioni importanti dal punto di vista dell'utente.

1. Introduzione e la guida su come utilizzare il manuale Burnham CHG225 - All'inizio di ogni manuale, dovremmo trovare indizi su come utilizzare il documento. Dovrebbe contenere informazioni sulla posizione dell’indice Burnham CHG225, FAQ o i problemi più comuni : i punti che sono più spesso cercati dagli utenti di ogni manuale
2. Indice - elenco di tutti i suggerimenti per Burnham CHG225 che possono essere trovati nel documento corrente
3. Suggerimenti su come utilizzare le funzioni di base del dispositivo Burnham CHG225 - che ci dovrebbe aiutare nei primi passi durante l'uso Burnham CHG225
4. Troubleshooting - sequenza sistematica delle attività che vi aiuterà a diagnosticare e, successivamente, risolvere i problemi più importanti del Burnham CHG225
5. FAQ - domande più frequenti
6. Dettagli di contatto Informazioni su dove cercare il contatto con il fabbricante / servizio Burnham CHG225 in un dato paese, se il problema non può essere risolto da noi stessi.

Hai una domanda su Burnham CHG225?

Utilizza il modulo sottostante

Se non hai risolto il problema con Burnham CHG225 con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con Burnham CHG225 è probabile che voglia condividere il modo di risolverlo.

Riscrivi il testo dall’immagine

Captcha
Nuova immagine

Commenti (0)