Wagner SprayTech 9185Gの取扱説明書

28ページ 7.42 mb
ダウンロード

ページに移動 of 28

Summary
  • Wagner SprayTech 9185G - page 1

    Español Français English Owner’s Manual Read this manual for complete instructions 0412 • Form No. 0293922E Contents 2 Important Safety Information 4 What’s in the Box? 5 Proper Use and Functions 6 Assembly 7 Pressure Relief Procedure 8 Load Material 9 Getting Material to Flow 10 Practice Spraying 12 Clear the Spray Tip 13 Clean the Spray G ...

  • Wagner SprayTech 9185G - page 2

    English 2 Safety Safety Important Safety Information Read all safety information before operating the equipment. Save these instructions Indicates a hazardous situation which, if not avoided, could result in death or serious injury.  a) Toreducetherisksofreorexplosion,electrical shock and the injury to persons ...

  • Wagner SprayTech 9185G - page 3

    English 3 7. Do not kink or over-bend the hose. Airless hose can develop leaks from wear, kinking and abuse. A leak can inject material into the skin. 8. Do not expose the hose to temperatures or pressures in excess of those specied by manufacturer. 9. Do not use the hose as a strength member to pull or lift the equipment. 10. Use lowest possibl ...

  • Wagner SprayTech 9185G - page 4

    English 4 What’ s in the box?* Start *Certain parts of the sprayer will not be assembled out of the box. Be sure to read Assembly instructions, page 6. Notice: Refer to the engine manufacturer’s instruction manual for complete engine information. Heed all cautions and warnings. Note: The engine on the sprayer will come lled with oil. However ...

  • Wagner SprayTech 9185G - page 5

    English 5 Proper use and functions Start Controls and Functions Sprays a variety of paints (oil-based and latex), primers, stains, preservatives and other nonabrasive materials. Do not use. . . This pump should not be used with textured materials, block ller, asphalt sealer or materials containing HHC. See coating supplier if ash point is not ...

  • Wagner SprayTech 9185G - page 6

    English 6 1. Assembly Start 1. Insert the ends of the hose bracket into the holes of the handle as shown. 2. Remove the plug from inside the hose ttings and remove the cap on the outlet valve. Discard both. 5. Thread the other end of the hose to the spray gun. Hold the gun with one adjustable wrench, and tighten the hose nut with the other. 4. H ...

  • Wagner SprayTech 9185G - page 7

    English 7 Safety Start Pressure Relief Procedure* *Perform when instructed Start Important Safety Warning Be sure to follow the Pressure Relief Procedure when shutting the unit off for any purpose. This procedure is used to relieve pressure from the spray hose. Failure to do so could result in serious injury. You will need: • A waste bucket Impor ...

  • Wagner SprayTech 9185G - page 8

    English 8 2. Load Material Start You will need: • The material you plan to spray • Flat blade screwdriver • Piston Oil™ • Waste bucket 1. Remove AutoOiler cap with a at blade screwdriver. Squirt Piston Oil into the AutoOiler. Replace cap. 2. Push AutoOiler button 2-5 times to lubricate the uid section. Press button 2-3 times before ...

  • Wagner SprayTech 9185G - page 9

    You will need: • Waste bucket • Scrap material / cardboard • Drop cloths to protect oors and furnishings from overspray IMPOR´TANT: When placed on a smooth surface, the vibration of the running engine may cause the unit to move forward or backward slightly. Avoid placing the unit on an inclinded surface or near a drop-off such as stairs. ...

  • Wagner SprayTech 9185G - page 10

    English 10 4. Practice Spraying Start You will need: • Scrap material / cardboard Notes: If the spray pattern becomes distorted or stops completely while the gun is triggered, follow any or all the procedures listed on pages 12-14. If you plan to be away from your spray project for more than one hour, follow the Short Term Storage instructions on ...

  • Wagner SprayTech 9185G - page 11

    English 11 Spray P attern Overlap Y our Strokes Spray T echnique 50% Overlap 8” - 10” (20 - 25 cm) ! GOOD SPRAY PATTERN BAD SPRAY PATTERN: TAILING CORRECT See page 12-14 Start stroke End stroke Pull trigger Release trigger Move steadily CORRECT CORRECT INCORRECT Tip: Flex your wrist as you move in order to keep gun parallel to the surface ...

  • Wagner SprayTech 9185G - page 12

    English 12 Spraying T roubleshooting - Clear the Spray Tip Start You will need: • Scrap material / cardboard Do not attempt to unclog or clean the tip with your finger. High pressure fluid can cause injection injury. 1. Lock the spray gun. 2. Rotate spray tip 180 degrees from its current position. Note: If spray tip is difcult to rotate, relie ...

  • Wagner SprayTech 9185G - page 13

    English 13 Spraying T roubleshooting - Clean the Spray Gun Filter Start You will need: • Wrench • Warm, soapy water for latex material • Mineral spirits for oil based materials • Replacement spray gun lter (if necessary) IMPORTANT: Never clean the filter by poking it with a sharp object. 1. Peform the Pressure Relief Procedure , page 7. ...

  • Wagner SprayTech 9185G - page 14

    English 14 Spraying T roubleshooting - Clean the Inlet Filter Start You will need: • Warm, soapy water for latex material • Mineral spirits for oil based materials IMPORTANT: Make sure your floors and furnishings are covered with drop cloths to prevent accidental drips. 1. Unscrew the inlet lter from the tting on the end of the suction tu ...

  • Wagner SprayTech 9185G - page 15

    English 15 Short T erm Storage Start English You will need: • Water • Plastic bag or bucket • Rags • Stir stick This procedure should be used when taking a short term break or when ending your project for the day. If your break is longer than 16 hours follow Cleanup instructions, page 16. Instructions are for latex materials only Note: If u ...

  • Wagner SprayTech 9185G - page 16

    English 16 Cleanup Start You will need: • A water source that can be delivered with a garden hose (latex materials only) • Mineral spirits if using oil-based material • Empty waste container • A container with warm, soapy water • When using latex material, clean sprayer and components with warm, soapy water. For oil based material use min ...

  • Wagner SprayTech 9185G - page 17

    English 17 5. Remove the inlet lter from the suction tube and place it into waste container. 6. Thread pump cleaning adapter onto garden hose. Thread suction tube tting over the adapter. 7. Unclip the return tube from the suction tube and place it into the waste container. Turn the PRIME/SPRAY knob to PRIME. 8. Turn the water supply to the ga ...

  • Wagner SprayTech 9185G - page 18

    English 18 Cleanup - Oil-Based Materials Start You will need: • Mineral spirits if using oil-based material • Warm, soapy water if using latex material • Waste container Follow these steps if you sprayed oil-based materials,orifyousprayedlatexmaterials and do not have a garden hose available. Be sure to use the appropriat ...

  • Wagner SprayTech 9185G - page 19

    English 19 Cleaning the Spray Gun Components Start You will need: • Soft bristled brush • Light household oil • Warm, soapy water if using latex material • Mineral spirits for oil based material • Wrench IMPORTANT: DO NOT use any silicone- based lubricants to clean or lubricate the spray gun. 1. Peform the Pressure Relief Procedure , page ...

  • Wagner SprayTech 9185G - page 20

    English 20 Long T erm Storage Start You will need: • Light household oil / Piston Oil • Rags • Wrench IMPORTANT: Store in a well-ventilated area. If you plan to store in temperatures below 32ºF (0ºC), flush with Wagner Liquid Shield™ (sold separately). 1. Remove the suction tube. Using a wrench, remove the spray hose. 2. Fill a cup or oth ...

  • Wagner SprayTech 9185G - page 21

    English 21 Cleaning the Sureflo V alve Start You will need: • Wrench CleaningorservicingtheSureoValve may be required if the unit has priming problems. Priming problems may be prevented by properly cleaning the sprayer and following the long-term storage steps. If priming problems persist, you may need toreplacetheS ...

  • Wagner SprayTech 9185G - page 22

    English 22 T roubleshooting Before servicing, always release system pressure by following Pressure Relief Procedure (page 7). Problem A: The sprayer does not start Cause Solution 1. Gas tank is empty Fill the gas tank 2. There is a pr oblem with sprayer engine Call T echnical Service Problem B: The sprayer starts but does not draw material when the ...

  • Wagner SprayTech 9185G - page 23

    English 23 Problem F: The spray tip assembly leaks Cause Solution 1. The spray tip was assembled incorrectly Check tip assembly and assemble properly see page 19, steps 6-7 2. Gun seal is worn Replace the seal** Problem G: The spray gun will not spray Cause Solution 1. The spray tip plugged Refer to Clear the Spray Tip see page 12 2. The spray gun ...

  • Wagner SprayTech 9185G - page 24

    English Français Español 72 1 3 4 2 Sprayer • Pulvérisateur • Rociador Parts List • Liste de Pièces • Lista de Piezas This unit contains no servicable parts. Do not attempt to service yourself. Take the sprayer to a Wagner authorized service center. Cet appareil ne contient aucune pièce nécessitant un entretien quelconque. Ne tentez p ...

  • Wagner SprayTech 9185G - page 25

    English Español Français Español 73 4 1 2 3 5 6 7 Suction set • Dispositif d’aspiration • Juego de succión Parts List • Liste de Pièces • Lista de Piezas Item Art. Art. Part No. No de piéce Pieza No. English - Description Français-Description Español - Descripción Qty. Qté. Cant. 1 0516127 Suction set Dispositif d’asp ...

  • Wagner SprayTech 9185G - page 26

    English Français Español 74 Parts List • Liste de Pièces • Lista de Piezas 2 3 4 1 5 GS-07 Spray Gun • Pistolet de GS-07 • Pistola de GS-07 Item Art. Art. Part No. No de piéce Pieza No. English - Description Français-Description Español - Descripción Qty. Qté. Cant. 1 0511515 VersaTip, 515 VersaTip, 515 VersaTip, 515 1 2 01 ...

  • Wagner SprayTech 9185G - page 27

    English Español Français Español 75 Accessories • Accessoires • Accesorios Part No. No de piéce Pieza No. English - Description Français-Description Español - Descripción 0512178A Piston repair kit Jeu de joints pour tronçon d’acheminement Juego de reparación del pistón 0093896 Hose connector kit Raccord de exible Conect ...

  • Wagner SprayTech 9185G - page 28

    English Français Español 76 6,981,852 6,933,634 7,018,181 7,071,429 D550,327 D537,839 D553,325 D550,329 D550,328 7,886,876 Other patents pending U.S. Patent Nos. Limited Warranty AIRLESS PAINT SPRAY EQUIPMENT This product, manufactured by Wagner Spray Tech (Wagner), is warranted to the original retail purchaser against defects in material and wor ...

メーカー Wagner SprayTech カテゴリー Paint Sprayer

Wagner SprayTech 9185Gのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 9185Gの取扱説明書
- Wagner SprayTechの製品カード
- パンフレット
- またはWagner SprayTech 9185Gの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Wagner SprayTech 9185Gの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Wagner SprayTech 9185Gの取り付け説明書、サービスマニュアル、簡易説明書、またはWagner SprayTech 9185Gのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Wagner SprayTech 9185Gの製品を使用するにあたって最も人気のある説明書を閲覧できます。

Wagner SprayTech 9185Gデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWagner SprayTech 9185Gを使用するのを助ける技術的文書のことです。説明書は通常、全てのWagner SprayTech 9185Gユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Wagner SprayTechの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Wagner SprayTech 9185Gの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWagner SprayTech 9185Gの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Wagner SprayTech 9185Gに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Wagner SprayTech 9185Gデバイスの基本機能を使うにあたってのヒント。 Wagner SprayTech 9185Gのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Wagner SprayTech 9185Gに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWagner SprayTech 9185Gのメーカー/サービスへの連絡先に関する情報。

Wagner SprayTech 9185Gについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもWagner SprayTech 9185Gの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWagner SprayTech 9185Gで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)