AllTrade 835408の取扱説明書

21ページ 0.4 mb
ダウンロード

ページに移動 of 21

Summary
  • AllTrade 835408 - page 1

    Model #835408 A I R C O M P R E S S O R 3 Gallon / 1.5 Peak HP 226892 If you encounter any problems or dif ficulties, Do not return your compressor to the stor e! Please contact our toll-free customer service department at: 1-800-423-3598 • 1-310-522-9008 (Califor nia Only) • www .powerbuilttools.com ...

  • AllTrade 835408 - page 2

    It is the owner and/or operator’ s responsibility to study all WARNINGS, operating, and maintenance instructions contained on the product label and instruction manual prior to operation of this unit. The owner/operator shall r etain product instructions for future refer ence. The owner and/or operator is responsible for maintenance, maintaining a ...

  • AllTrade 835408 - page 3

    Duty Cycle: This air compressor pump is capable of running continuously . However , in order to prolong the life of your air compressor , it is recommended that a 50% to 75% average duty cycle be maintained. Duty cycle r efers to the per centage of time a compressor can safely run within a given amount of time expr essed as a ratio. Example: Oil lu ...

  • AllTrade 835408 - page 4

    INTRODUCTION This oil lubricated air compressor is designed for Household Use Only and is not intended for commer cial applications. It is well suited for do-it- yourselfers with a variety of automotive and home uses. This instruction manual is intended for your benefit. Please read and follow the safety , installation, maintenance and tr oubleshoo ...

  • AllTrade 835408 - page 5

    SAFETY WARNINGS READ ALL SAFETY W ARNINGS BEFORE USING AIR COMPRESSOR. GENERAL SAFETY WARNINGS: • Keep work area clean. Messy areas and cluttered workbenches invite personal injury and/or property damage. • Keep children and visitors away . All childr en should be kept away fr om the work ar ea. DO NOT let children handle the compr essor or ext ...

  • AllTrade 835408 - page 6

    DRAIN LIQUID FROM AIR T ANK DAIL Y • Use the drain valve located on the bottom of the lower air tank to drain. Failur e to properly drain liquid from the tank will cause rust from moisture buildup, which weakens the tank and could lead to a violent tank explosion. Periodically inspect the tanks for unsafe conditions such as corrosion, cracked wel ...

  • AllTrade 835408 - page 7

    RISK OF FALLING Portable air compressors can fall from a table, workbench, or roof causing damage to the compressor and could r esult in serious injury or death to the operator . Always operate air compressor in a stable and secure position to prevent accidental movement of the unit. Never operate air compressor on a roof or other elevated position ...

  • AllTrade 835408 - page 8

    IMPROPER INST ALLA TION OF THE GROUNDING PLUG CAN RESUL T IN A RISK OF ELECTRIC SHOCK. IF REP AIR OR REPLACEMENT OF THE CORD IS NECESSARY , DO NOT CONNECT THE GROUNDING WIRE TO EITHER FLA T BLADE TERMINAL. THE WIRE WITH GREEN INSULA TION WITH OR WITHOUT YELLOW STRIPES IS THE GROUNDING WIRE. THIS PRODUCT IS FOR USE ON A NOMINAL 120-VOL T CIRCUIT AND ...

  • AllTrade 835408 - page 9

    7 COMPRESSOR FEA TURES 1 2 3 4 5 6 7 8 1 0 1 1 9 ...

  • AllTrade 835408 - page 10

    COMPRESSOR FEA TURES OIL LUBRICA TION: Oil lubricated direct drive pump with cast-iron cylinder for durability . OIL FILL SIGHT GLASS: Located on the face of the crankcase, the oil fill sight glass provides a convenient way to check the oil fill level within the pump. The oil level must be checked prior to each use to ensure proper fill level. DO N ...

  • AllTrade 835408 - page 11

    ASSEMBL Y INSTRUCTIONS THE COMPRESSOR IS SHIPPED WITHOUT OIL IN THE CRANKCASE. ADD OIL AS INDICA TED BELOW . STEP 1 – PUMP LUBRICA TION This air compressor features an oil lubricated pump that requires the use of SAE 30 weight non-detergent air compressor oil . Adding Compressor Oil: 1. Place air compr essor on a flat, level surface. 2. Remove pl ...

  • AllTrade 835408 - page 12

    STEP 2 – INSPECTION CHECK Assembly Check: In order to complete the assembly of your new air compressor , a car eful inspection should be made to ensure that all of the parts are properly aligned and securely fastened. 1. Inspect air filter to ensure that it is installed and secure. 2. Check oil fill level in crankcase. OPERA TION INITIAL SETUP / ...

  • AllTrade 835408 - page 13

    MAINTENANCE DISCONNECT AIR COMPRESSOR FROM POWER SOURCE AND BLEED OFF ALL AIR PRESSURE BEFORE A TTEMPTING ANY MAINTENANCE OR REP AIR. SHUTDOWN AND STORAGE: NOTE: NEVER stop the air compressor by unplugging it fr om the power outlet as this may result in damage to the compressor . 1. T urn the switch to the OFF position 2. Disconnect the power cord ...

  • AllTrade 835408 - page 14

    CHECKING SAFETY RELIEF V AL VE: SAFETY RELIEF V AL VE MUST BE REPLACED IF IT CANNOT BE ACTUA TED OR IT LEAKS AIR AFTER THE RING IS RELEASED. 1. The air compressor must be turned OFF . 2. Disconnect compr essor fr om the power sour ce. 3. Open tank drain to bleed off all air pressure before attempting any maintenance or r epair . 4. Allow compressor ...

  • AllTrade 835408 - page 15

    13 TROUBLESHOOTING GUIDE Problem Encountered Possible Cause Possible Solution The compressor does not start or restart: Power cord not plugged in. Plug cord into grounded outlet. Motor/Pressur e switch in OFF position Move switch to AUTO position. Motor thermal overload switch has tripped. T urn air compressor off, wait until the motor is cool, the ...

  • AllTrade 835408 - page 16

    14 TROUBLESHOOTING GUIDE Problem Encountered Possible Cause Possible Solution Air continues to leak at motor/pressur e switch release valve while motor is running: Defective motor/pressure switch. Replace. Check valve stuck in open position. Replace check valve. DANGER — Do not disassemble the check valve with tank pressurized. Open tank petcock ...

  • AllTrade 835408 - page 17

    P ARTS LIST 15 NO. P ART NO. DESCRIPTION QTY NO. P ART NO. DESCRIPTION QTY 1 835408-1 Head Bolt 4 53 835408-53 Gauge (0-200psi) 1 2 835408-2 Spring Washer 8 54 835408-54 Safety V alve (140psi) 1 3 835408-3 Cylinder Head 1 55 835408-55 Gauge (0-200psi) 1 4 835408-4 Exhaust Elbow 1 56 835408-56 Strain Relief 2 5 835408-5 Cylinder Head Gasket 1 57 835 ...

  • AllTrade 835408 - page 18

    16 P ARTS DIAGRAM ...

  • AllTrade 835408 - page 19

    ONE YEAR LIMITED W ARRANTY ALL TRADE TOOLS LLC AIR COMPRESSORS Express and Exclusive Limited W arranty to Original Retail Buyer Alltrade T ools LLC (hereinafter “Alltrade”) expressly warrants to the original retail purchaser of the accompanying air compressor and no one else all parts of the product (except those parts r eferred to below which ...

  • AllTrade 835408 - page 20

    Alltrade will not be liable for the following: labor charges, loss or damage resulting from impr oper operation, maintenance or repairs made by other persons; pre-delivery services such as assembly , oil or lubricants, and adjustment; maintenance services that are normally required to maintain the air compr essor . The use of other than genuine All ...

  • AllTrade 835408 - page 21

    WEAR SAFETY GLASSES WARNING ¥ ADVERTENCIA USE GAFAS DE SEGURIDAD 1431 VIA PLA T A LONG BEACH, CA 90810-1462 www .alltradetools.com MADE IN / FABRI Q UÉ EN / HECHO EN CHINA © COPYRIGHT 2005, ALL TRADE TOOLS LLC REV . 1 ...

メーカー AllTrade カテゴリー Air Compressor

AllTrade 835408のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 835408の取扱説明書
- AllTradeの製品カード
- パンフレット
- またはAllTrade 835408の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、AllTrade 835408の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、AllTrade 835408の取り付け説明書、サービスマニュアル、簡易説明書、またはAllTrade 835408のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、AllTrade 835408の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

AllTrade 835408デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがAllTrade 835408を使用するのを助ける技術的文書のことです。説明書は通常、全てのAllTrade 835408ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

AllTradeの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. AllTrade 835408の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははAllTrade 835408の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。AllTrade 835408に関してこのドキュメントで見つけることができる全てのヒントの目次
3. AllTrade 835408デバイスの基本機能を使うにあたってのヒント。 AllTrade 835408のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。AllTrade 835408に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるAllTrade 835408のメーカー/サービスへの連絡先に関する情報。

AllTrade 835408についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもAllTrade 835408の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがAllTrade 835408で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)