Coleman PM402511の取扱説明書

32ページ 1.4 mb
ダウンロード

ページに移動 of 32

Summary
  • Coleman PM402511 - page 1

    © 2003 ÂColeman Powermate, Inc. 12-03 S t ationary S t andby Electric Generator - 25,000 W A TTS I MPORT ANT SAFETY INSTRUCTIONS – Please make cert ain that persons who are to inst all, operate and maint ain this equipment thoroughly read and underst and these instructions prior to operation. SA VE THESE INSTRUCTIONS — This manual cont ains i ...

  • Coleman PM402511 - page 2

    Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 General Safety Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4 Introduction . . . . . . . . . . . . ...

  • Coleman PM402511 - page 3

    Do not attempt to install the generator yourself. Extremely high and dangerous electrical voltages are present in utility power source lines and in generator load leads when the unit is running. Therefore, be sure to turn OFF all power voltage supplies at their source before attempting to complete electrical connections. Only qualified installation ...

  • Coleman PM402511 - page 4

    The National Electrical Code (NEC) requires the frame and external electrically conductive parts of the generator to be connected to an approved earth ground. Keep a fire extinguisher near the generator at all times. Extinguishers rated "ABC" by the National Fire Protection Association are appropriate for use on the standby electric syste ...

  • Coleman PM402511 - page 5

    The stationary standby electric generator is manufactured for our customers to supply reliable backup power. The generator is a compact unit, designed to supply the power for your critical needs when utility power fails. The standby generator will run on Liquid Propane Gas or Natural Gas allowing flexibility for getting the power you need. Fuel lin ...

  • Coleman PM402511 - page 6

    Rated W attage - (S tandby) 25,000 W atts@1.0PF LPG 22,000 W atts @ 1.0 PF NG V oltage - 120/240 volts Rated Current - 208/104 amps LPG Frequency - 60 HZ Power Factor - 1.0 Max. Ambient T emp Rise - 105°C Insulation class - H Note: Rated wattage is specified at sea level, 60°F ambient temperature, and prop ane fuel (with 2500 BTU/cuft). Rated wat ...

  • Coleman PM402511 - page 7

    I I N N S S T T A A L L L L A A T T I I O O N N D D R R A A W W I I N N G G S S 7 ...

  • Coleman PM402511 - page 8

    NOTE: The generator frame has been designed with rectangular slots and frame tubes to be used with a forklift for removing the unit from the pallet and positioning the unit on the cement pad. NOTE: The generator has an engine fan that draws the air in from the side panel slots, circulates it within the enclosure and forces the air through the radia ...

  • Coleman PM402511 - page 9

    L L O O C C A A T T I I O O N N A A N N D D G G E E N N E E R R A A T T O O R R P P L L A A C C E E M M E E N N T T ( ( c c o o n n t t i i n n u u e e d d ) ) W W A A R R N N I I N N G G • For fire safety, the generator must be installed and maintained properly. Installation always must comply with applicable codes, standards, laws and regulatio ...

  • Coleman PM402511 - page 10

    NATURAL GAS (NG) SETTINGS Units are tested with natural gas before they leave the factory. If natural gas is to be used, no adjustments are required. The fuel select switch, located on the bottom of the control panel, should be in the (NG) position. The (NG) position is with the switch depressed away from the front of the control panel (see A in il ...

  • Coleman PM402511 - page 11

    This generator must be connected to an automatic transfer switch. The automatic transfer switch detects when a power failure occurs and automatically starts the engine to provide generator power. When the utility power becomes available, the transfer switch automatically shuts down the generator and switches back to the utility power. (See figure 1 ...

  • Coleman PM402511 - page 12

    Minimum recommended battery size is a BCI Group 26 with a minimum of 550 CCA (Cold Cranking Amps). Place the battery in the battery rack as shown and secure using the holddown hardware provided. Once the battery has been placed and tied down with the battery hold down bar, connect the leads to the respective battery post. Always connect the (red) p ...

  • Coleman PM402511 - page 13

    Check oil level before start-up. The unit is shipped with the proper type of oil in the crankcase for operation above 40°F. Follow the engine manufacturer’s recommendations for oil at temperatures below 40°F. Check oil periodically to ensure that the unit is properly lubricated. Follow the engine manufacturer’s recommended service schedule. E ...

  • Coleman PM402511 - page 14

    A Two line by twenty character LCD provides the primary visual interface for metering, alarms, pre- alarms and protective functions. In the normal mode, labels appear above and below the display. In the alternate display mode, labels and the displayed value appear on the display. B Red LED turns ON when the device is not in the AUTO mode. C Red LED ...

  • Coleman PM402511 - page 15

    DISPLAY MODE Pressing the Display/Toggle pushbutton allows the user to scroll through the Normal, Alternate and Menu display Modes. ALTERNATE DISPLAY MODE Alternate Display Mode can be used to observe generator performance including oil pressure, coolant temperature, battery voltage, kilowatt load, generator voltage, kVA, hours to next service, amp ...

  • Coleman PM402511 - page 16

    When the generator control panel senses an abnormal operating condition, an alarm is declared and the generator set is shutdown. All alarm conditions will light a red LED (labeled Alarm ) along with displaying the condition on the LCD screen. When an alarm condition occurs, the display indicates the cause of the alarm and the fuel solenoid contact ...

  • Coleman PM402511 - page 17

    2 2 5 5 K K W W W W I I R R I I N N G G D D I I A A G G R R A A M M ( ( C C P P 5 5 0 0 0 0 C C O O N N T T R R O O L L L L E E R R ) ) SCHÉMA DE CÂBLAGE 25KW (CONTRÔLEUR CP 500) DIAGRAMA DE CIRCUITO ELÉCTRICO DE 25 KILOV A TIOS (CONTROLADOR CP500) 17 ...

  • Coleman PM402511 - page 18

    2 2 5 5 K K W W W W I I R R I I N N G G D D I I A A G G R R A A M M ( ( C C P P 1 1 0 0 0 0 0 0 C C O O N N T T R R O O L L L L E E R R ) ) SCHÉMA DE CÂBLAGE 25KW (CONTRÔLEUR CP 1000) DIAGRAMA DE CIRCUITO ELÉCTRICO DE 25 KILOV A TIOS (CONTROLADOR CP1000) 18 ...

  • Coleman PM402511 - page 19

    • Check oil every 8 hours of operation. • Change oil and oil filter every 100 hours of operation. • Change air filter every 400 hours. • Replace spark plugs every 500 hours . • Check Coolant level every 8 hours of operation. Check coolant mixture at least twice a year using a hygrometer. • Check battery terminals at least twice a year. ...

  • Coleman PM402511 - page 20

    SYMPTOM Engine will not crank in Manual mode. Engine will crank in manual mode but will not start. Engine runs but no A.C. output from the generator. Fault light on, engine will not start. Engine starts but shuts down immediately. Battery will not stay charged. Engine will not run at full speed or runs rough. POSSIBLE CAUSE 1. Defective Battery. 2. ...

  • Coleman PM402511 - page 21

    Coleman PowerSt ation™ St ationary S t andby 3-Y ear or 1500 Hour Limited W arranty Your Coleman PowerStation™ emergency back up power system generator has been manufactured to stringent guidelines & standards for years of dependable operation & service. Coleman Powermate warrants this product to the original consumer against defects in ...

  • Coleman PM402511 - page 22

    Hour Maintenance Performed Meter Time Hour Maintenance Performed Meter Time M M A A I I N N T T E E N N A A N N C C E E L L O O G G Always follow the engine manufactures recommendations when performing maintenance. Use this page to track the maintenance which is performed. Noting the time on the hour meter will help in keeping the maintenance sched ...

  • Coleman PM402511 - page 23

    P P A A R R T T S S D D R R A A W W I I N N G G - - E E X X H H A A U U S S T T S S Y Y S S T T E E M M PLAN DES PIÈCES - SYSTÈME D'ÉCHAPPEMENT DIAGRAMA DE PIEZAS - SISTEMA DE ESCAPE P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS 1 0058015 1 Tailpipe . . . . . . . . . . . . . . . . . . . . . . . Embout d'éc ...

  • Coleman PM402511 - page 24

    P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS P P A A R R T T S S D D R R A A W W I I N N G G - - E E N N C C L L O O S S U U R R E E PLAN DES PIÈCES - BOÎTIER DIAGRAMA DE PIEZAS - CARCASA 24 1 115-0206 1 Lid assembly (includes lid and . . . . . . Couvercle (incluant l'isolant sonore) . Conjunto de tapa (incluye ...

  • Coleman PM402511 - page 25

    P P A A R R T T S S D D R R A A W W I I N N G G - - C C O O O O L L I I N N G G S S Y Y S S T T E E M M PLAN DES PIÈCES - SYSTÈME DE REFROIDISSEMENT DIAGRAMA DE PIEZAS - SISTEMA DE ENFRIAMIENTO 25 P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS 1 115-0211 1 Radiator panel . . . . . . . . . . . . . . . . . . Panneau de rad ...

  • Coleman PM402511 - page 26

    P P A A R R T T S S D D R R A A W W I I N N G G - - D D O O O O R R A A S S S S E E M M B B L L Y Y PLAN DES PIÈCES - ENSEMBLE DE PORTE ESQUEMA DE PIEZAS - CONJUNTO DE LA PUERT A 26 P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS 1 See page 24 1 Door assembly . . . . . . . . . . . . . . . . . . Ensemble de porte (voir pa ...

  • Coleman PM402511 - page 27

    P P A A R R T T S S D D R R A A W W I I N N G G - - F F U U E E L L S S Y Y S S T T E E M M PLAN DES PIÈCES - SYSTÈME D'ADMISSION DIAGRAMA DE PIEZAS - SISTEMA DE COMBUSTIBLE Item Art Art 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 *N/A NOTE: Seal all connections with gas tape. Use 2½ wraps minimum. Check all connections under pressure using a soa ...

  • Coleman PM402511 - page 28

    P P A A R R T T S S D D R R A A W W I I N N G G - - G G E E N N E E R R A A T T O O R R PLAN DES PIÈCES - GÉNÉRA TRICE DIAGRAMA DE PIEZAS - GENERADOR 28 P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS 1 0059337 1 Rectifier service kit w/var, dio . . . . . . Ens. de réparation redresseur . . . . . Juego de rectificaci? ...

  • Coleman PM402511 - page 29

    P P A A R R T T S S D D R R A A W W I I N N G G - - 2 2 5 5 K K W W B B R R E E A A K K D D O O W W N N PLAN DES PIÈCES - VUE ÉCLA TÉE 25 KW DIAGRAMA DE PIEZAS - DESGLOSE DEL MODELO DE 25 KILOV A TIOS 29 P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS 1 059-0332 4 Bolt, M10-1.5 X 25MM . . . . . . . . . . . . Boulon, M10- ...

  • Coleman PM402511 - page 30

    P P A A R R T T S S D D R R A A W W I I N N G G - - C C O O N N T T R R O O L L P P A A N N E E L L E E N N D D A A S S S S E E M M B B L L Y Y PLAN DES PIÈCES - ENSEMBLE DE T ABLEAU DE COMMANDE DIAGRAMA DE PIEZAS - CONJUNTO TERMINAL DEL P ANEL DE CONTROL 30 P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS 1 115-0213 1 Gene ...

  • Coleman PM402511 - page 31

    P P A A R R T T S S D D R R A A W W I I N N G G - - C C O O N N T T R R O O L L P P A A N N E E L L B B R R E E A A K K D D O O W W N N PLAN DES PIÈCES - VUE ÉCLA TÉE DU T ABLEAU DE COMMANDE DIAGRAMA DE PIEZAS - DESGLOSE DEL P ANEL DE CONTROL 31 P P A A R R T T S S L L I I S S T T LISTE DES PIÈCES LIST A DE PIEZAS 1 N/A 4 Nut, 1/4-20 nylon st ...

  • Coleman PM402511 - page 32

    P P A A R R T T S S D D R R A A W W I I N N G G - - B B A A T T T T E E R R Y Y H H O O L L D D D D O O W W N N PLAN DES PIÈCES - FIXA TION DE LA BA TTERIE DIAGRAMA DE PIEZAS - SUJECIÓN DE LA BA TERÍA 32 To Starter Au Démarreur Al Arrancador To Engine Block Au Bloc De Moteur Al Bloque Del Motor P P A A R R T T S S L L I I S S T T LISTE DES PIÈ ...

メーカー Coleman カテゴリー Portable Generator

Coleman PM402511のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- PM402511の取扱説明書
- Colemanの製品カード
- パンフレット
- またはColeman PM402511の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Coleman PM402511の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Coleman PM402511の取り付け説明書、サービスマニュアル、簡易説明書、またはColeman PM402511のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Coleman PM402511の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Coleman PM402511デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがColeman PM402511を使用するのを助ける技術的文書のことです。説明書は通常、全てのColeman PM402511ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Colemanの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Coleman PM402511の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははColeman PM402511の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Coleman PM402511に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Coleman PM402511デバイスの基本機能を使うにあたってのヒント。 Coleman PM402511のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Coleman PM402511に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるColeman PM402511のメーカー/サービスへの連絡先に関する情報。

Coleman PM402511についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもColeman PM402511の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがColeman PM402511で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)