日本語 dropdown-ico

England's Stove Works 25PAHの取扱説明書

46ページ 1.46 mb
ダウンロード

ページに移動 of 46

Summary
  • England's Stove Works 25PAH - page 1

    PELLET  AUXILIARY  HEATER     INSTALLATION  &  OPERATION  MANUAL  25 ‐ PAH/55 ‐ SHPAH/55 ‐ TRPAH             REV.  12/2011     CAUTION Please  read  this  entire  manual  before ...

  • England's Stove Works 25PAH - page 2

    Page | 2   WARNING :   Use  of  outside  combustion  air  is  mandatory  with  this  unit.   Do  not  operate  with  the  hopper  open;  lid  must  be  shut  and  tightly  latched  during  operation.  Retain  for  your  files  Model  Numbe ...

  • England's Stove Works 25PAH - page 3

    Page | 3 TABLE  OF  CONTENTS   Introduction   Introduction  .................................  4  Specifications   Heating  Specifications  ..................  5   Dimensions  ...................................  5   EPA  Compliance  ...........................  5  Installation ...

  • England's Stove Works 25PAH - page 4

    Page | 4 INTRODUCTION   Thank  you  for  purchasing  this  fine  product  from  England’s  Stove  Works!   England’s  Stove  Works  was  started,  and  is  still  owned  by,  a  family  that  believes  strongly  in  a  “Do  It  Yourself”  s ...

  • England's Stove Works 25PAH - page 5

    Page | 5 SPECIFICATIONS   Heating  Specifications   Heat  Output  Range**  ............................................  11,000  BTU/hr  –  25,000  BTU/hr   Approximate  Pellet  Burn  Rate**  ...............................................  1.6  lb/hr  –  4.0  lb/hr   ...

  • England's Stove Works 25PAH - page 6

    Page | 6 INSTALLATION   Installation  Over view  When  choosing  a  loca tion  for  your  new  stove,  there  are  a  multitude  of  factors  that  should  be  taken  into  account  before  beginning  the  installation.   1. Traffic  Patterns  –  To ? ...

  • England's Stove Works 25PAH - page 7

    Page | 7 INSTALLATION   Clearances  to  Combustibles             Unit  to  Side  Wall  Unit  to  Rear  Wall  Unit  to  Corner   Unit  Top  to  Ceiling   Min.  Ceiling  Height  Min.  Alcove  Width  Max.  Alcove  Depth  A ? ...

  • England's Stove Works 25PAH - page 8

    Page | 8 INSTALLATION  Venting  Introduction   This  pellet  stove  operates  on  a  negative  draft  system,  which  pulls  combustion  air  through  the  burn  pot  and  pushes  the  exhaust  air  through  the  vent  pipe  and  out  of  the  buil ...

  • England's Stove Works 25PAH - page 9

    Page | 9 INSTALLATION   Additional  Venting  Information   Do  not  mix  and  match  components  from  different  pipe  manufacturers  when  assembling  your  venting  system  (i.e.  Do  NOT  use  venting  pipe  from  one  manufacturer  and  a  thimble ? ...

  • England's Stove Works 25PAH - page 10

    Page | 10 INSTALLATION   Approved  Venting  Method  1 :  Through  the  Wall    Generally  the  simplest  installation  method,  venting  through  the  wall  using  our  AC ‐ 3000  kit  (or  similar  venting  system)  is  also  the  preferred  venting ? ...

  • England's Stove Works 25PAH - page 11

    Page | 11 INSTALLATION   Approved  Venting  Method  2 :  Through  the  Ceiling    Venting  through  the  ceiling/roof  may  be  the  only  feasible  venting  option  in  some  cases  and  is  a  factory  recommended  installation.   When  installing ? ...

  • England's Stove Works 25PAH - page 12

    Page | 12 INSTALLATION   Approved  Venting  Method  3 :  Exis ting  Chimn ey  System   Using  an  existing  masonry  or  factory  built  chimney  for  venting  is  the  only  other  acceptable  method  for  venting  this  pellet  unit.   Use  Type  ...

  • England's Stove Works 25PAH - page 13

    Page | 13 INSTALLATION  Mobile  Home  Installation   The  England’s  Stove  Works,  Inc.  outside  air  kit  MUST  be  used  for  installation  of  this  unit  in  a  mobile  home.  Please  see  the  “Outside  Air”  section  on  page  14  ...

  • England's Stove Works 25PAH - page 14

    Page | 14 OUTSIDE  AIR  HOOK ‐ UP    The  use  of  outside  combustion  air  is  mandatory  on  this  pellet  stove.   The  outside  air  connection  pipe  protrudes  from  the  lower  rear  center  of  the  stove;  use  the  included  outside ...

  • England's Stove Works 25PAH - page 15

    Page | 15 FLOOR  PROTECTION    This  pellet  stove  requires  a  non ‐ combustible  floor  protector  if  the  stove  is  to  be  installed  on  a  combustible  floor.  If  the  floor  the  stove  is  to  be  installed  on  is  already  non ...

  • England's Stove Works 25PAH - page 16

    Page | 16 DAILY  OPERATION   Getting  Started   Check  to  see  that  the  hopper  is  clean  and  free  from  foreign  materials.  Be  sure  to  connect  this  unit  to  a  working  outlet;  we  recommend  using  a  surge  protector  to  ...

  • England's Stove Works 25PAH - page 17

    Page | 17  Shortly  after  pressing  the  “On”  button,  the  letters  “ S  U ”  will  appear  in  the  heat  range  and  blower  speed  windows  of  the  control  board.  This  indicates  the  stove  has  entered  the  start ‐ up  sequen ...

  • England's Stove Works 25PAH - page 18

    Page | 18 CONTROL  BOARD  SETTINGS  The  control  board  on  this  stove  allows  the  user  to  adjust  the  heat  output  and  convection  blower  speed,  turn  the  unit  on  and  off,  and  test  components  for  function  (more  on  diagnostic ...

  • England's Stove Works 25PAH - page 19

    Page | 19 ERROR  CODES  Error  codes,  or  “E ‐ Codes,”  are  alphanumeric  codes  that  will  appear  in  the  Heat  Range  and  Blower  Speed  windows  of  the  Control  Board  if  the  unit  experiences  an  abnormal  condition.  Error  codes ...

  • England's Stove Works 25PAH - page 20

    Page | 20  POWER  FAILURE  If  the  power  to  the  unit  is  interrupted  for  approximately  three  minutes  or  less,  the  unit  will  resume  operation  when  power  is  restored  according  to  the  following  table:   Unit’s  State  Before ...

  • England's Stove Works 25PAH - page 21

    Page | 21 THERMOSTAT  OPERATION  Thermostat  Installation  1. Unplug  the  unit  and  remove  the  back  panel  of  the  stove.  2. Locate  the  thermostat  connect  block,  labeled  J18,  on  the  rear  of  the  control  board,  near  the  bottom  (See ...

  • England's Stove Works 25PAH - page 22

    Page | 22 THERMOSTAT  OPERATION  Thermostat  Operation  Details   The  25 ‐ PAH|55 ‐ SHPAH|55 ‐ TRPAH  was  designed  to  operate  equally  well  in  both  manual  and  thermostat  mode.  While  using  the  control  board  for  heating  control  gives  t ...

  • England's Stove Works 25PAH - page 23

    Page | 23 DAILY  MAINTENANCE  Important  Notes   As  with  any  maintenance  concerning  this  unit,  be  sure  the  unit  is  “OFF”  and  has  completed  the  Shut ‐ Down  cycle  BEFORE  beginning.   Be  aware  that  metal  parts  in  the  f ...

  • England's Stove Works 25PAH - page 24

    Page | 24  Use  a  long  handled  screwdriver  or  putty  knife  to  remove  any  deposits  left  in  the  burnpot,  being  careful  to  remove  them  from  the  burnpot  and  not  allow  them  to  filter  down  into  the  cradle  area.  E ...

  • England's Stove Works 25PAH - page 25

    Page | 25 MONTHLY  MAINTENANCE  Important  Notes   As  with  any  maintenance  concerning  this  unit,  be  sure  the  unit  is  “OFF,”  has  completed  the  Shut ‐ Down  cycle,  and  is  completely  cool  BEFORE  beginning.   Be  aware  that  m ...

  • England's Stove Works 25PAH - page 26

    Page | 26  Using  a  utility  type  vacuum  cleaner,  ,  vacuum  the  fly  ash  out  of  the  exhaust  chamber.  A  short  piece  of  hose  can  be  attached  to  the  end  of  the  utility  vacuum  line  and  can  be  useful  in  re ...

  • England's Stove Works 25PAH - page 27

    Page | 27  YEARLY  MAINTENANCE  Important  Notes   As  with  any  maintenance  concerning  this  unit,  be  sure  the  unit  is  “OFF,”  has  completed  the  Shut ‐ Down  cycle,  and  is  completely  cool  BEFORE  beginning.   Be  aware  that ? ...

  • England's Stove Works 25PAH - page 28

    Page | 28 YEARLY  MAINTENANCE  Exhaust  Blower  Cleaning  Although  the  exhaust  blower  and  blower  housing  were  designed  to  minimize  ash  build ‐ up,  some  fly ‐ ash  will  still  accumulate  there  throughout  the  burning  season.  The  amount ...

  • England's Stove Works 25PAH - page 29

    Page | 29  YEARLY  MAINTENANCE  Convection  Blower  Cleaning  As  always,  be  certain  the  stove  is  cool  and  unplugged  before  servicing  any  components  within  the  unit.  Since  the  convection  blower  does  not  handle  any  by ‐ products ...

  • England's Stove Works 25PAH - page 30

    Page | 30 Trouble ‐ Shooting  Guide  WARNING:  To  avoid  ELECTRICAL  SHOCK  always  disconnect  the  unit  from  the  power  source  BEFORE  attempting  any  repair.  If  this  guide  does  not  correct  the  problem,  call  your  lo cal  dealer  o ...

  • England's Stove Works 25PAH - page 31

    Page | 31 Unit  Shuts  Down  in  15 ‐ 20  minutes  with  an  "E ‐ 2"  code  on  contr ol  board .  1.  Loose  thermal  sensor.  1.  Check  both  sides  of  thermal  sensor  connection  (exhaust  blower  and  control  board).   2.  Contro ...

  • England's Stove Works 25PAH - page 32

    Page | 32 REPLACING  COMPONENTS  Auger  Motor  1. Before  beginning  any  component  replacement,  be  certain  the  unit  is  unplugged  and  thoroughly  cooled  down.  Also,  make  sure  the  hopper  is  empty  before  attempting  to  remove  or  repla ...

  • England's Stove Works 25PAH - page 33

    Page | 33 REPLACING  COMPONENTS  Convection  Blower  1. Before  beginning  any  component  replacement,  be  cert ain  the  unit  is  unplugged  and  thoroughly  cooled  down.  2. Remove  the  back  exhaust  outlet  cover  plate  and  back  panel  from  the ...

  • England's Stove Works 25PAH - page 34

    Page | 34  REPLACING  COMPONENTS  Vacuum  Sensor  1. Before  beginning  any  component  replacement,  be  cert ain  the  unit  is  unplugged  and  thoroughly  cooled  down.  2. Remove  the  exhaust  outlet  cover  plate  and  rear  panel  of  unit.  3. L ...

  • England's Stove Works 25PAH - page 35

    Page | 35 REPLACING  COMPONENTS     Gaskets  1. Door  o This  unit  comes  with  a  5 / 8 ”  rope  gasket  around  the  door  that  should  be  replac ed  at  least  every  two  years.  To  replace  the  door  gasket  (Part  #  AC ‐ DGKNC),  ...

  • England's Stove Works 25PAH - page 36

    Page | 36 REPLACING  COMPONENTS  Glass  This  unit  has  a  one  ceramic  glass  panel  (Part  No.  AC ‐ G17)  in  the  viewing  door;  self  adhesive  window  gasket  is  included  with  replacement  windows  purchased  directly  from  England’s  Stove ...

  • England's Stove Works 25PAH - page 37

    Page | 37 REPLACING  COMPONENTS  Control  Board  The  Control  Board  (Part  #  PAH ‐ CB09)  is  a  digital  read ‐ out  board.  This  board  offers  a  wide  variety  of  settings  to  operate  the  unit.  The  right  side  panel  should  be ? ...

  • England's Stove Works 25PAH - page 38

    Page | 38 WIRING  DIAGRAM   Caution  – Shock  Hazard   Press  the  “Off”  button  and  let  the  appliance  completely  cool  BEFORE  unplugging  the  appliance  and  beginning  any  maintenance  or  component  replacement.   Risk  of  shock  if ? ...

  • England's Stove Works 25PAH - page 39

    Page | 39 ILLUSTRATED  PARTS  DIAGRAM     Auger  Motor  Assembly   Door  Assembly      1  2 3  4  5 6 7 8 ? ...

  • England's Stove Works 25PAH - page 40

    Page | 40 REPLACEMENT  PARTS  LIST  Part  Number  Part  Description  Diagram  #  Gaskets  PU ‐ HLG  Hopper  Lid  Gasket  1  AC ‐ DGKNC  5/8”  Door  Gasket  2  AC ‐ GGK  Window  Gasket  Kit  3  PU ‐ CBG  Exhaust  Blower  Gasket  4  AC ? ...

  • England's Stove Works 25PAH - page 41

    Page | 41                            You may write your unit’s Manufacture Date and Serial Number in the blank spaces on this sample tag, for futu re reference. This sample tag also shows the safety info. such as UL te sting standard, etc. for your local officials, o ...

  • England's Stove Works 25PAH - page 42

    Page | 42  LIMITED  FIVE  (5)  YEAR  WARRANTY  From  the  date  of  purchase  to  the  original  owner   The  manufacturer  extends  the  following  warrantie s:  Five  Year  Period:  1. Carbon  steel  and  welded  sea ms  in  the  firebox  are  co ...

  • England's Stove Works 25PAH - page 43

    Page | 43  Procedure   Purchaser  must  give  notice  of  claim  of  defect  within  the  warranty  period  and  pay  transportation  to  and  from  a  service  center  designated  by  the  manufacturer.  The  dealer  from  which  the  unit  was ...

  • England's Stove Works 25PAH - page 44

    Page | 44 ...

  • England's Stove Works 25PAH - page 45

    Page | 45 WARRANTY  REGISTRATION  for  England’s  Stove  Works®  Purchaser  Information  I.  Purchased  By  (Name)  _________________________________________  II.  Address  ____________________________________________________  III.  City_______________________State________Zip  Code  ______ ...

  • England's Stove Works 25PAH - page 46

    Page | 46 Important  Notice  This  registration  informatio n  MUST  be  on  file  for  this  warranty  to  be  valid.  Please  mail  this  information  within  thirty  (30)  days  from  the  original  date  of  purchase.  Use  any  of  these  thre ...

メーカー England's Stove Works カテゴリー Gas Heater

England's Stove Works 25PAHのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 25PAHの取扱説明書
- England's Stove Worksの製品カード
- パンフレット
- またはEngland's Stove Works 25PAHの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、England's Stove Works 25PAHの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、England's Stove Works 25PAHの取り付け説明書、サービスマニュアル、簡易説明書、またはEngland's Stove Works 25PAHのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、England's Stove Works 25PAHの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

England's Stove Works 25PAHデバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがEngland's Stove Works 25PAHを使用するのを助ける技術的文書のことです。説明書は通常、全てのEngland's Stove Works 25PAHユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

England's Stove Worksの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. England's Stove Works 25PAHの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははEngland's Stove Works 25PAHの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。England's Stove Works 25PAHに関してこのドキュメントで見つけることができる全てのヒントの目次
3. England's Stove Works 25PAHデバイスの基本機能を使うにあたってのヒント。 England's Stove Works 25PAHのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。England's Stove Works 25PAHに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるEngland's Stove Works 25PAHのメーカー/サービスへの連絡先に関する情報。

England's Stove Works 25PAHについてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもEngland's Stove Works 25PAHの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがEngland's Stove Works 25PAHで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)