English dropdown-ico

Manual England's Stove Works 25PAH

46 pages 1.46 mb
Download

Go to site of 46

Summary
  • England's Stove Works 25PAH - page 1

    PELLET  AUXILIARY  HEATER     INSTALLATION  &  OPERATION  MANUAL  25 ‐ PAH/55 ‐ SHPAH/55 ‐ TRPAH             REV.  12/2011     CAUTION Please  read  this  entire  manual  before ...

  • England's Stove Works 25PAH - page 2

    Page | 2   WARNING :   Use  of  outside  combustion  air  is  mandatory  with  this  unit.   Do  not  operate  with  the  hopper  open;  lid  must  be  shut  and  tightly  latched  during  operation.  Retain  for  your  files  Model  Numbe ...

  • England's Stove Works 25PAH - page 3

    Page | 3 TABLE  OF  CONTENTS   Introduction   Introduction  .................................  4  Specifications   Heating  Specifications  ..................  5   Dimensions  ...................................  5   EPA  Compliance  ...........................  5  Installation ...

  • England's Stove Works 25PAH - page 4

    Page | 4 INTRODUCTION   Thank  you  for  purchasing  this  fine  product  from  England’s  Stove  Works!   England’s  Stove  Works  was  started,  and  is  still  owned  by,  a  family  that  believes  strongly  in  a  “Do  It  Yourself”  s ...

  • England's Stove Works 25PAH - page 5

    Page | 5 SPECIFICATIONS   Heating  Specifications   Heat  Output  Range**  ............................................  11,000  BTU/hr  –  25,000  BTU/hr   Approximate  Pellet  Burn  Rate**  ...............................................  1.6  lb/hr  –  4.0  lb/hr   ...

  • England's Stove Works 25PAH - page 6

    Page | 6 INSTALLATION   Installation  Over view  When  choosing  a  loca tion  for  your  new  stove,  there  are  a  multitude  of  factors  that  should  be  taken  into  account  before  beginning  the  installation.   1. Traffic  Patterns  –  To ? ...

  • England's Stove Works 25PAH - page 7

    Page | 7 INSTALLATION   Clearances  to  Combustibles             Unit  to  Side  Wall  Unit  to  Rear  Wall  Unit  to  Corner   Unit  Top  to  Ceiling   Min.  Ceiling  Height  Min.  Alcove  Width  Max.  Alcove  Depth  A ? ...

  • England's Stove Works 25PAH - page 8

    Page | 8 INSTALLATION  Venting  Introduction   This  pellet  stove  operates  on  a  negative  draft  system,  which  pulls  combustion  air  through  the  burn  pot  and  pushes  the  exhaust  air  through  the  vent  pipe  and  out  of  the  buil ...

  • England's Stove Works 25PAH - page 9

    Page | 9 INSTALLATION   Additional  Venting  Information   Do  not  mix  and  match  components  from  different  pipe  manufacturers  when  assembling  your  venting  system  (i.e.  Do  NOT  use  venting  pipe  from  one  manufacturer  and  a  thimble ? ...

  • England's Stove Works 25PAH - page 10

    Page | 10 INSTALLATION   Approved  Venting  Method  1 :  Through  the  Wall    Generally  the  simplest  installation  method,  venting  through  the  wall  using  our  AC ‐ 3000  kit  (or  similar  venting  system)  is  also  the  preferred  venting ? ...

  • England's Stove Works 25PAH - page 11

    Page | 11 INSTALLATION   Approved  Venting  Method  2 :  Through  the  Ceiling    Venting  through  the  ceiling/roof  may  be  the  only  feasible  venting  option  in  some  cases  and  is  a  factory  recommended  installation.   When  installing ? ...

  • England's Stove Works 25PAH - page 12

    Page | 12 INSTALLATION   Approved  Venting  Method  3 :  Exis ting  Chimn ey  System   Using  an  existing  masonry  or  factory  built  chimney  for  venting  is  the  only  other  acceptable  method  for  venting  this  pellet  unit.   Use  Type  ...

  • England's Stove Works 25PAH - page 13

    Page | 13 INSTALLATION  Mobile  Home  Installation   The  England’s  Stove  Works,  Inc.  outside  air  kit  MUST  be  used  for  installation  of  this  unit  in  a  mobile  home.  Please  see  the  “Outside  Air”  section  on  page  14  ...

  • England's Stove Works 25PAH - page 14

    Page | 14 OUTSIDE  AIR  HOOK ‐ UP    The  use  of  outside  combustion  air  is  mandatory  on  this  pellet  stove.   The  outside  air  connection  pipe  protrudes  from  the  lower  rear  center  of  the  stove;  use  the  included  outside ...

  • England's Stove Works 25PAH - page 15

    Page | 15 FLOOR  PROTECTION    This  pellet  stove  requires  a  non ‐ combustible  floor  protector  if  the  stove  is  to  be  installed  on  a  combustible  floor.  If  the  floor  the  stove  is  to  be  installed  on  is  already  non ...

  • England's Stove Works 25PAH - page 16

    Page | 16 DAILY  OPERATION   Getting  Started   Check  to  see  that  the  hopper  is  clean  and  free  from  foreign  materials.  Be  sure  to  connect  this  unit  to  a  working  outlet;  we  recommend  using  a  surge  protector  to  ...

  • England's Stove Works 25PAH - page 17

    Page | 17  Shortly  after  pressing  the  “On”  button,  the  letters  “ S  U ”  will  appear  in  the  heat  range  and  blower  speed  windows  of  the  control  board.  This  indicates  the  stove  has  entered  the  start ‐ up  sequen ...

  • England's Stove Works 25PAH - page 18

    Page | 18 CONTROL  BOARD  SETTINGS  The  control  board  on  this  stove  allows  the  user  to  adjust  the  heat  output  and  convection  blower  speed,  turn  the  unit  on  and  off,  and  test  components  for  function  (more  on  diagnostic ...

  • England's Stove Works 25PAH - page 19

    Page | 19 ERROR  CODES  Error  codes,  or  “E ‐ Codes,”  are  alphanumeric  codes  that  will  appear  in  the  Heat  Range  and  Blower  Speed  windows  of  the  Control  Board  if  the  unit  experiences  an  abnormal  condition.  Error  codes ...

  • England's Stove Works 25PAH - page 20

    Page | 20  POWER  FAILURE  If  the  power  to  the  unit  is  interrupted  for  approximately  three  minutes  or  less,  the  unit  will  resume  operation  when  power  is  restored  according  to  the  following  table:   Unit’s  State  Before ...

  • England's Stove Works 25PAH - page 21

    Page | 21 THERMOSTAT  OPERATION  Thermostat  Installation  1. Unplug  the  unit  and  remove  the  back  panel  of  the  stove.  2. Locate  the  thermostat  connect  block,  labeled  J18,  on  the  rear  of  the  control  board,  near  the  bottom  (See ...

  • England's Stove Works 25PAH - page 22

    Page | 22 THERMOSTAT  OPERATION  Thermostat  Operation  Details   The  25 ‐ PAH|55 ‐ SHPAH|55 ‐ TRPAH  was  designed  to  operate  equally  well  in  both  manual  and  thermostat  mode.  While  using  the  control  board  for  heating  control  gives  t ...

  • England's Stove Works 25PAH - page 23

    Page | 23 DAILY  MAINTENANCE  Important  Notes   As  with  any  maintenance  concerning  this  unit,  be  sure  the  unit  is  “OFF”  and  has  completed  the  Shut ‐ Down  cycle  BEFORE  beginning.   Be  aware  that  metal  parts  in  the  f ...

  • England's Stove Works 25PAH - page 24

    Page | 24  Use  a  long  handled  screwdriver  or  putty  knife  to  remove  any  deposits  left  in  the  burnpot,  being  careful  to  remove  them  from  the  burnpot  and  not  allow  them  to  filter  down  into  the  cradle  area.  E ...

  • England's Stove Works 25PAH - page 25

    Page | 25 MONTHLY  MAINTENANCE  Important  Notes   As  with  any  maintenance  concerning  this  unit,  be  sure  the  unit  is  “OFF,”  has  completed  the  Shut ‐ Down  cycle,  and  is  completely  cool  BEFORE  beginning.   Be  aware  that  m ...

  • England's Stove Works 25PAH - page 26

    Page | 26  Using  a  utility  type  vacuum  cleaner,  ,  vacuum  the  fly  ash  out  of  the  exhaust  chamber.  A  short  piece  of  hose  can  be  attached  to  the  end  of  the  utility  vacuum  line  and  can  be  useful  in  re ...

  • England's Stove Works 25PAH - page 27

    Page | 27  YEARLY  MAINTENANCE  Important  Notes   As  with  any  maintenance  concerning  this  unit,  be  sure  the  unit  is  “OFF,”  has  completed  the  Shut ‐ Down  cycle,  and  is  completely  cool  BEFORE  beginning.   Be  aware  that ? ...

  • England's Stove Works 25PAH - page 28

    Page | 28 YEARLY  MAINTENANCE  Exhaust  Blower  Cleaning  Although  the  exhaust  blower  and  blower  housing  were  designed  to  minimize  ash  build ‐ up,  some  fly ‐ ash  will  still  accumulate  there  throughout  the  burning  season.  The  amount ...

  • England's Stove Works 25PAH - page 29

    Page | 29  YEARLY  MAINTENANCE  Convection  Blower  Cleaning  As  always,  be  certain  the  stove  is  cool  and  unplugged  before  servicing  any  components  within  the  unit.  Since  the  convection  blower  does  not  handle  any  by ‐ products ...

  • England's Stove Works 25PAH - page 30

    Page | 30 Trouble ‐ Shooting  Guide  WARNING:  To  avoid  ELECTRICAL  SHOCK  always  disconnect  the  unit  from  the  power  source  BEFORE  attempting  any  repair.  If  this  guide  does  not  correct  the  problem,  call  your  lo cal  dealer  o ...

  • England's Stove Works 25PAH - page 31

    Page | 31 Unit  Shuts  Down  in  15 ‐ 20  minutes  with  an  "E ‐ 2"  code  on  contr ol  board .  1.  Loose  thermal  sensor.  1.  Check  both  sides  of  thermal  sensor  connection  (exhaust  blower  and  control  board).   2.  Contro ...

  • England's Stove Works 25PAH - page 32

    Page | 32 REPLACING  COMPONENTS  Auger  Motor  1. Before  beginning  any  component  replacement,  be  certain  the  unit  is  unplugged  and  thoroughly  cooled  down.  Also,  make  sure  the  hopper  is  empty  before  attempting  to  remove  or  repla ...

  • England's Stove Works 25PAH - page 33

    Page | 33 REPLACING  COMPONENTS  Convection  Blower  1. Before  beginning  any  component  replacement,  be  cert ain  the  unit  is  unplugged  and  thoroughly  cooled  down.  2. Remove  the  back  exhaust  outlet  cover  plate  and  back  panel  from  the ...

  • England's Stove Works 25PAH - page 34

    Page | 34  REPLACING  COMPONENTS  Vacuum  Sensor  1. Before  beginning  any  component  replacement,  be  cert ain  the  unit  is  unplugged  and  thoroughly  cooled  down.  2. Remove  the  exhaust  outlet  cover  plate  and  rear  panel  of  unit.  3. L ...

  • England's Stove Works 25PAH - page 35

    Page | 35 REPLACING  COMPONENTS     Gaskets  1. Door  o This  unit  comes  with  a  5 / 8 ”  rope  gasket  around  the  door  that  should  be  replac ed  at  least  every  two  years.  To  replace  the  door  gasket  (Part  #  AC ‐ DGKNC),  ...

  • England's Stove Works 25PAH - page 36

    Page | 36 REPLACING  COMPONENTS  Glass  This  unit  has  a  one  ceramic  glass  panel  (Part  No.  AC ‐ G17)  in  the  viewing  door;  self  adhesive  window  gasket  is  included  with  replacement  windows  purchased  directly  from  England’s  Stove ...

  • England's Stove Works 25PAH - page 37

    Page | 37 REPLACING  COMPONENTS  Control  Board  The  Control  Board  (Part  #  PAH ‐ CB09)  is  a  digital  read ‐ out  board.  This  board  offers  a  wide  variety  of  settings  to  operate  the  unit.  The  right  side  panel  should  be ? ...

  • England's Stove Works 25PAH - page 38

    Page | 38 WIRING  DIAGRAM   Caution  – Shock  Hazard   Press  the  “Off”  button  and  let  the  appliance  completely  cool  BEFORE  unplugging  the  appliance  and  beginning  any  maintenance  or  component  replacement.   Risk  of  shock  if ? ...

  • England's Stove Works 25PAH - page 39

    Page | 39 ILLUSTRATED  PARTS  DIAGRAM     Auger  Motor  Assembly   Door  Assembly      1  2 3  4  5 6 7 8 ? ...

  • England's Stove Works 25PAH - page 40

    Page | 40 REPLACEMENT  PARTS  LIST  Part  Number  Part  Description  Diagram  #  Gaskets  PU ‐ HLG  Hopper  Lid  Gasket  1  AC ‐ DGKNC  5/8”  Door  Gasket  2  AC ‐ GGK  Window  Gasket  Kit  3  PU ‐ CBG  Exhaust  Blower  Gasket  4  AC ? ...

  • England's Stove Works 25PAH - page 41

    Page | 41                            You may write your unit’s Manufacture Date and Serial Number in the blank spaces on this sample tag, for futu re reference. This sample tag also shows the safety info. such as UL te sting standard, etc. for your local officials, o ...

  • England's Stove Works 25PAH - page 42

    Page | 42  LIMITED  FIVE  (5)  YEAR  WARRANTY  From  the  date  of  purchase  to  the  original  owner   The  manufacturer  extends  the  following  warrantie s:  Five  Year  Period:  1. Carbon  steel  and  welded  sea ms  in  the  firebox  are  co ...

  • England's Stove Works 25PAH - page 43

    Page | 43  Procedure   Purchaser  must  give  notice  of  claim  of  defect  within  the  warranty  period  and  pay  transportation  to  and  from  a  service  center  designated  by  the  manufacturer.  The  dealer  from  which  the  unit  was ...

  • England's Stove Works 25PAH - page 44

    Page | 44 ...

  • England's Stove Works 25PAH - page 45

    Page | 45 WARRANTY  REGISTRATION  for  England’s  Stove  Works®  Purchaser  Information  I.  Purchased  By  (Name)  _________________________________________  II.  Address  ____________________________________________________  III.  City_______________________State________Zip  Code  ______ ...

  • England's Stove Works 25PAH - page 46

    Page | 46 Important  Notice  This  registration  informatio n  MUST  be  on  file  for  this  warranty  to  be  valid.  Please  mail  this  information  within  thirty  (30)  days  from  the  original  date  of  purchase.  Use  any  of  these  thre ...

Manufacturer England's Stove Works Category Gas Heater

Documents that we receive from a manufacturer of a England's Stove Works 25PAH can be divided into several groups. They are, among others:
- England's Stove Works technical drawings
- 25PAH manuals
- England's Stove Works product data sheets
- information booklets
- or energy labels England's Stove Works 25PAH
All of them are important, but the most important information from the point of view of use of the device are in the user manual England's Stove Works 25PAH.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals England's Stove Works 25PAH, service manual, brief instructions and user manuals England's Stove Works 25PAH. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product England's Stove Works 25PAH.

Similar manuals

A complete manual for the device England's Stove Works 25PAH, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use England's Stove Works 25PAH by users. Manuals are usually written by a technical writer, but in a language understandable to all users of England's Stove Works 25PAH.

A complete England's Stove Works manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual England's Stove Works 25PAH - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the England's Stove Works 25PAH, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the England's Stove Works 25PAH, that we can find in the current document
3. Tips how to use the basic functions of the device England's Stove Works 25PAH - which should help us in our first steps of using England's Stove Works 25PAH
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with England's Stove Works 25PAH
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of England's Stove Works 25PAH in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning England's Stove Works 25PAH?

Use the form below

If you did not solve your problem by using a manual England's Stove Works 25PAH, ask a question using the form below. If a user had a similar problem with England's Stove Works 25PAH it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)