Amtrol TD-7ZDWの取扱説明書

16ページ 0.4 mb
ダウンロード

ページに移動 of 16

Summary
  • Amtrol TD-7ZDW - page 1

    BOILER MA TE TM TOP-DOWN INDIRECT -FIRED W A TER HEA TERS WITH TOP-MOUNTED COIL The heat transfer medium should be water . If any product other than water is used, it must be a non-toxic fluid suitable for human ingestion as determined by the FDA Y our AMTROL BOILER MA TE™ has been carefully assembled and factory tested. T o enjoy the full servic ...

  • Amtrol TD-7ZDW - page 2

    -2- 1. GENERAL SAFETY INFORMA TION ...................................................................................... 3 2. PRE-INST ALLA TION CHECKLIST ........................................................................................ 4 Important Steps and Decisions Required Befor e Installation 3. REQUIRED COMPONENTS AND ACCESSORIES CHEC ...

  • Amtrol TD-7ZDW - page 3

    -3- IMPOR T ANT GENERAL SAFETY INFORMA TION - ADDITIONAL SPECIFIC SAFETY ALER TS APPEAR IN THE FOLLOWING INSTRUCTIONS EXPLOSION HAZARD: DO NOT INST ALL TO A HIGH PRESSURE STEAM BOILER (greater than 15 psig). AN EXPLOSION COULD OCCUR. EXPLOSION HAZARD. THE PRESSURE OF THE HEA T TRANSFER MEDIUM MUST BE LIMITED TO A MAXIMUM OF 30 PSIG BY AN APPROVED S ...

  • Amtrol TD-7ZDW - page 4

    -4- j THIS PRODUCT MUST BE INST ALLED AND MAINT AINED BY A LICENSED PROFESSIONAL. IN ADDITION TO THE INSTRUCTIONS IN THIS MANUAL, FOLLOW ALL APPLICABLE LOCAL AND ST A TE CODES OR IN THE ABSENCE OF SUCH CODES, THE CURRENT EDITIONS OF THE NA TIONAL PLUMBING CODE AND THE NA TIONAL ELECTRIC CODE. j DRIP P AN AND DRAIN: T o avoid leaking and/or property ...

  • Amtrol TD-7ZDW - page 5

    -5- TD-7Z, TD-41Z, TD-7ZDW , TD-41ZDW COMPONENTS CHECKLIST The following is a checklist of components requir ed for proper installation of these BOILER MA TE™ models, both Priority and Non-Priority: A. Separate circulator • 1 each - circulator (4-8 gpm) • 1 each - positive shut-of f weighted check valve B. Use of heating system zone cir culat ...

  • Amtrol TD-7ZDW - page 6

    -6- A. General Installation Requir ements 1. Do not "short circuit" the boiler Do not connect boiler supply and return lines to the same section or in the same flow circuit in a boiler , because the boiler water returning from the BOILER MA TE™ will "short circuit" and exit the boiler too cold for pr oper heat transfer . 2. Av ...

  • Amtrol TD-7ZDW - page 7

    -7- B. PIPING PIPING SHOULD BE ACCOMPLISHED WITH UNIONS. Step 1 - Locate the BOILER MA TE™ near boiler . Step 2 - Connect the cold water piping. a. Shut off the cold water supply at the main shut-of f valve. b. Drain existing domestic water system. Open 1 or more system faucets to pr event vacuum. c. When the system is drained, for boilers that h ...

  • Amtrol TD-7ZDW - page 8

    -8- Step 5 - Connect boiler supply pipe. Figure 1. a. Shut off the cold water supply valve to the boiler , and drain it using a hose attached to the drain valve at the boiler . b. When the boiler system piping is drained, cut the piping to accommodate the supply line tee. Install the tee between the boiler supply outlet and any system zone valve or ...

  • Amtrol TD-7ZDW - page 9

    -9- the service switch). c. Switch of f the branch cir cuit breaker . Step 2 - Remove electrical box cover . Step 3 - Remove existing wir e fr om boiler aquastat terminal C1 and connect to terminal #2 on DPDT relay . Step 4 - Install wire fr om DPDT relay terminal #1 to boiler aquastat terminal C1. Step 5 - Connect terminals of 4 and 6 of DPDT rela ...

  • Amtrol TD-7ZDW - page 10

    -10- ...

  • Amtrol TD-7ZDW - page 11

    - 11 - The BOILER MA TE™ is intended to pr ovide a tank service life of many years. Components, however , may be subject to failur es that requir e service. Failure to use the corr ect procedur es or parts in these circumstances may make the unit unsafe. • DO NOT OPEN DOWN-STREAM FIXTURE IF YOU HA VE LOOSENED THE TOP CONNECTIONS. • DO NOT OVE ...

  • Amtrol TD-7ZDW - page 12

    -12- RESIDENTIAL BOILER MA TE™ CLASSIC (TD-7Z and TD-41Z) ELECTROCUTION HAZARD. THE BOILER MA TE™ MUST BE ELECTRICALL Y GROUNDED. NOTES: 1. THE BOILER MA TE™ MUST BE ELECTRI- CALL Y GROUNDED AND INST ALLED IN ACCORDANCE WITH LOCAL CODES, OR IN THE ABSENCE OF LOCAL CODES, WITH THE NA TIONAL ELECTRIC CODE. 2. HEA T EXCHANGER P ACKAGE INCLUDE IT ...

  • Amtrol TD-7ZDW - page 13

    - 13 - PROBLEM CAUSE SOLUTION 1. No hot water at faucet. 1. Boiler does not operate. 1. a. Press reset button on boiler . b. Check main cut-off switch. c. Check fuse. 2. Circulator does not operate. 2. a. Check power supply . b. Check shaft coupling. c. Check impeller for locking. 3. Improper BOILER MA TE™ 3. Set BOILER MA TE™ temperature to se ...

  • Amtrol TD-7ZDW - page 14

    -14- DA TE SERVICE PERFORMED COMMENTS CONTRACTOR 9. SERVICE RECORD ...

  • Amtrol TD-7ZDW - page 15

    AMTROL ® BOILERMA TE ™ CLASSIC AND TOP-DOWN™ LIMITED PRODUCT WARRANTY This W arranty cannot be transferred - it is extended only to the original Purchaser or First User of the Product. By accepting and keeping this Product you agree to all of the warranty terms and limitations of liability described below . I MPOR T ANT W ARNING: READ CAREFULL ...

  • Amtrol TD-7ZDW - page 16

    West W arwick, Rhode Island 02893 Part #: 9040-628 REV B (7/04) -16- ...

メーカー Amtrol カテゴリー Electric Heater

Amtrol TD-7ZDWのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- TD-7ZDWの取扱説明書
- Amtrolの製品カード
- パンフレット
- またはAmtrol TD-7ZDWの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Amtrol TD-7ZDWの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Amtrol TD-7ZDWの取り付け説明書、サービスマニュアル、簡易説明書、またはAmtrol TD-7ZDWのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Amtrol TD-7ZDWの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Amtrol TD-7ZDWデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがAmtrol TD-7ZDWを使用するのを助ける技術的文書のことです。説明書は通常、全てのAmtrol TD-7ZDWユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Amtrolの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Amtrol TD-7ZDWの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははAmtrol TD-7ZDWの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Amtrol TD-7ZDWに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Amtrol TD-7ZDWデバイスの基本機能を使うにあたってのヒント。 Amtrol TD-7ZDWのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Amtrol TD-7ZDWに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるAmtrol TD-7ZDWのメーカー/サービスへの連絡先に関する情報。

Amtrol TD-7ZDWについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもAmtrol TD-7ZDWの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがAmtrol TD-7ZDWで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)