Carrier INDUCED COUSTION 58YAVの取扱説明書

12ページ 0.18 mb
ダウンロード

ページに移動 of 12

Summary
  • Carrier INDUCED COUSTION 58YAV - page 1

    58YAV Induced-Combustion Furnaces Service and Maintenance Instructions For Sizes 070-155, Series 110 and 120 NOTE: Read the entire instruction manual before starting the installation. TABLE OF CONTENTS SAFETY CONSIDERATIONS .....................................................1 INTRODUCTION .......................................................... ...

  • Carrier INDUCED COUSTION 58YAV - page 2

    ELECTROSTATIC DISCHARGE (ESD) PRECAUTIONS PROCEDURE Electrostatic discharge can affect electronic components. Take precautions during furnace installation and servicing to protect the furnace electronic control. Precautions will pre- vent electrostatic discharges from personnel and hand tools which are held during the procedure. These precautions w ...

  • Carrier INDUCED COUSTION 58YAV - page 3

    d. If equipped with permanent, washable filter, clean filter by spraying cold tap water through filter in opposite direction of airflow. Rinse filter and let dry. Oiling or coating of the filter is not recommended. e. If equipped with factory-specified disposable media filter, replace only with media filter having the same part number and size. f. ...

  • Carrier INDUCED COUSTION 58YAV - page 4

    14. If furnace is operating properly, REMOVE TAPE TO RE- LEASE BLOWER ACCESS DOOR SWITCH, replace blower access door. Step 3—Cleaning Heat Exchanger The following steps should be performed by a qualified service technician: NOTE: If the heat exchangers get a heavy accumulation of soot and carbon, they should be replaced rather than trying to clea ...

  • Carrier INDUCED COUSTION 58YAV - page 5

    10. Clean flame sensor with fine steel wool 11. Remove old sealant from center panel and collector box flange and apply new sealant to collector box flange and reinstall on center panel, making sure all 8 screws are secure. NOTE: A releasing agent such as PAM cooking spray or equiva- lent (must not contain corn or canola oil, aromatic or halogenate ...

  • Carrier INDUCED COUSTION 58YAV - page 6

    Fig. 6—Unit Wiring Diagram A00304 PCB BLOWER OFF DELAY SELECTION CHART 90 SEC 135 SEC 180 SEC 225 SEC GVR H I/LO RELA Y SEC-1 SEC-2 PL1 3 2 1 6 5 4 9 87 LED TEST/TWIN BLOWER OFF DELAY G R Y W C HUM HSI R I DR BLWR BLOWER SPEED SELECT FU1 COOL HEA T L2 PL3 PL2 VAC 120 L1 PR1 1 2 1 2 3 PR2 24 VAC -3A FUSE SP AR E-2 SP ARE-1 EAC-1 EAC-2 C 1.5 AMP 12 ...

  • Carrier INDUCED COUSTION 58YAV - page 7

    through the sight glass or window on the blower access door. The control indicates status with the LED on continuously, rapid flashing, or a code composed of 2 digits. (The first digit is the number of short flashes, the second is the number of longs flashes.) For an explanation of status codes, refer to service label (See Fig. 8) located on blower ...

  • Carrier INDUCED COUSTION 58YAV - page 8

    Fig. 8—Service Label A99233 SER VICE G R Y W Com HUM TEST LED LED CODE ST A TUS 24V 11 12 13 14 21 22 23 24 31 33 34 * 9 8 6 5 32 1 4 7 COMPONENT TEST NO PREVIOUS CODE - Stored status codes are erased when pow er (115V AC or 24V AC) to control is interrupted or 48 hours after each f ault is cleared. BLO WER ON AFTER PO WER UP (115V A C or 24 V A ...

  • Carrier INDUCED COUSTION 58YAV - page 9

    Blower access door switch opens 115-v power to control. No component operation can occur. Caution must be taken when manually closing this switch for service purposes. Failure to follow this warning could result in personal injury or death. d. BRIEFLY short (jumper) TEST, 3/16 in. quick connect terminal on control (adjacent to LED status light), an ...

  • Carrier INDUCED COUSTION 58YAV - page 10

    Troubleshooting Guide A99123a Is circuit breaker closed? Close door switch and go to start. Is red LED status light on? Is door switch closed? Is red LED status light blinking rapidly without a pause? Is there 1 15v going to switch? Replace door switch. Replace control center . Replace transformer . Is red LED status light blinking ON/OFF slowly wi ...

  • Carrier INDUCED COUSTION 58YAV - page 11

    A99123b 11 NO PREVIOUS F A UL T - Faults are erased after 48 hrs or whenever power (1 15v or 24v) is interrupted. Run system through a heating or cooling cycle to check system. 12 BLO WER ON AFTER PO WER UP (115V OR 24V) - Normal operation. Blower will run for 90 sec when furnace power is interrupted during a call for heat, R-W closed. 13 LIMIT OR ...

  • Carrier INDUCED COUSTION 58YAV - page 12

    Copyright 2000 CARRIER Corp. • 7310 W. Morris St. • Indianapolis, IN 46231 58yav3sm Manufacturer reserves the right to discontinue, or change at any time, specifications or designs without notice and without incurring obligations. Book 1 4 Tab 6a 8a PC 101 Catalog No. 535-771 Printed in U.S.A. Form 58YAV–3SM Pg 12 10-00 Replaces: 58YAV–2SM ...

メーカー Carrier カテゴリー Furnace

Carrier INDUCED COUSTION 58YAVのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- INDUCED COUSTION 58YAVの取扱説明書
- Carrierの製品カード
- パンフレット
- またはCarrier INDUCED COUSTION 58YAVの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Carrier INDUCED COUSTION 58YAVの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Carrier INDUCED COUSTION 58YAVの取り付け説明書、サービスマニュアル、簡易説明書、またはCarrier INDUCED COUSTION 58YAVのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Carrier INDUCED COUSTION 58YAVの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Carrier INDUCED COUSTION 58YAVデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがCarrier INDUCED COUSTION 58YAVを使用するのを助ける技術的文書のことです。説明書は通常、全てのCarrier INDUCED COUSTION 58YAVユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Carrierの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Carrier INDUCED COUSTION 58YAVの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははCarrier INDUCED COUSTION 58YAVの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Carrier INDUCED COUSTION 58YAVに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Carrier INDUCED COUSTION 58YAVデバイスの基本機能を使うにあたってのヒント。 Carrier INDUCED COUSTION 58YAVのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Carrier INDUCED COUSTION 58YAVに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるCarrier INDUCED COUSTION 58YAVのメーカー/サービスへの連絡先に関する情報。

Carrier INDUCED COUSTION 58YAVについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもCarrier INDUCED COUSTION 58YAVの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがCarrier INDUCED COUSTION 58YAVで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)