Heat Controller BHD-301-Gの取扱説明書

17ページ 1.05 mb
ダウンロード

ページに移動 of 17

Summary
  • Heat Controller BHD-301-G - page 1

    Heat Controller , Inc. • 1900 Wellworth A ve. • Jackson, MI 49203 • (517)787-2100 • www .heatcontroller .com SER VICE MANU AL Portable Dehumidifer Series with R-410A: BHD-301-G BHD-501-G BHD-651-G ...

  • Heat Controller BHD-301-G - page 2

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 1 T ABLE OF CONTENTS 1. PREF ACE ............................................................................................ 2 1.1 SAFETY PRECAUTIONS ...................................................... 2 1.2 INSULA TION RESIST ANCE TEST .............................. ...

  • Heat Controller BHD-301-G - page 3

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 2 1. PREF ACE This SERVICE MANUAL provides various servicing information for the unit, including the mechanical and electrical parts, etc. This dehumidier was manufactured and assembled under a strict quality control system. The refrigerant is charged at the factory . ...

  • Heat Controller BHD-301-G - page 4

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 3 3. Humidity Set Control The humidity level can be set within a range of 35%RH (Relative Humidity) to 85%RH (Relative Humidity) in 5% increments. For drier air , press the button and set to a lower percent value(%). When the value displays 35%,press the button again wil ...

  • Heat Controller BHD-301-G - page 5

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 4 2. Product Installation Instructions Install the portable dehumidier in a at and spacious location where the air outlets will not be obstructed. Do not install underneath desks or inside cupboards as this will restrict the air ow . Maintain a clearance of at l ...

  • Heat Controller BHD-301-G - page 6

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 5 3.4 OPERA TION WITH CONTINUOUS DRAINAGE On the rear of the unit, remove the rubber plug carefully . Remove the water tank rst, then push the hose onto the connector located inside of the hole. The hose should go down smoothly without bends or kinks. Place the end of ...

  • Heat Controller BHD-301-G - page 7

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 6 4.Electronic function 4.1 POWERING ON THE UNIT When the unit is just powered on or the dropped power is just restored, the unit will immediately perform the self- diagnosis. The check items include the water-full, temperature sensor and humidity sensor . If there is no ...

  • Heat Controller BHD-301-G - page 8

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 7 5.Basic T est Procedures 5.1 DEFECTIVE COMPRESSOR Compressors are single phase, 1 15 volt. All compressor motors are permanent split capacitor type using only a running capacitor across the start and run terminal. All compressors are internally spring mounted and exter ...

  • Heat Controller BHD-301-G - page 9

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 8 5.2 SEALED REFRIGERA TION SYSTEM REP AIRS EQUIPMENT REQUIRED 1. V oltmeter 2. Ammeter 3. Ohmmeter 4. E.P .A. Approved Refrigerant Recovery System. 5. V acuum Pump (capable of 200 microns or less vacuum.) 6. Acetylene Welder 7. Electronic Halogen Leak Detector (G.E. T y ...

  • Heat Controller BHD-301-G - page 10

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 9 1 1. Break vacuum by charging system from the high side with the correct amount of refrigerant specied. This will prevent boiling the oil out of the crankcase. NOTE : If the entire charge will not enter the high side, allow the remainder to enter the low side in sma ...

  • Heat Controller BHD-301-G - page 11

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 10 CAP ACITOR - TEST 1. Remove capacitor from unit. 2. Check for visual damage such as bulges, cracks, or leaks. 3. For dual rated, apply an ohmmeter lead to common (C) terminal and the other probe to the compressor (HERM) terminal. A satisfactory capacitor will cause a ...

  • Heat Controller BHD-301-G - page 12

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 1 1 6. TROUBLESHOOTING GUIDE 6.1 TROUBLESHOOTING GUIDE In general, possible trouble is classied in three kinds. One is called Starting Failure which is caused from an electri - cal defect, another is ineffective Air Conditioning caused by a defect in the refrigeration ...

  • Heat Controller BHD-301-G - page 13

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 12 6.3.3 Humidity sensor check 6.3.4 Fail to start or fail to start motor ...

  • Heat Controller BHD-301-G - page 14

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 13 6.3.5 Abnormal noise 6.3.6 Complaint and remedy Complaint Cause Remedy No display or any button failure. T ransformer (Discharge transformer before testing) Check resistance between the two input/output lines on transformer . Replace the transformer if either of the i ...

  • Heat Controller BHD-301-G - page 15

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 14 Complaint Cause Remedy Fan motor noise Fan Replace the fan if cracked, out of balance, or partially missing. Blower Replace the blower if cracked, out of balance, or partially missing. Loose screws T ighten them. Worn bearings Replace the motor if knocking sounds cont ...

  • Heat Controller BHD-301-G - page 16

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 15 7. Wiring Diagram ...

  • Heat Controller BHD-301-G - page 17

    04/2009 05/2010 ...

メーカー Heat Controller カテゴリー Dehumidifier

Heat Controller BHD-301-Gのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- BHD-301-Gの取扱説明書
- Heat Controllerの製品カード
- パンフレット
- またはHeat Controller BHD-301-Gの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Heat Controller BHD-301-Gの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Heat Controller BHD-301-Gの取り付け説明書、サービスマニュアル、簡易説明書、またはHeat Controller BHD-301-Gのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Heat Controller BHD-301-Gの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Heat Controller BHD-301-Gデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがHeat Controller BHD-301-Gを使用するのを助ける技術的文書のことです。説明書は通常、全てのHeat Controller BHD-301-Gユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Heat Controllerの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Heat Controller BHD-301-Gの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははHeat Controller BHD-301-Gの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Heat Controller BHD-301-Gに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Heat Controller BHD-301-Gデバイスの基本機能を使うにあたってのヒント。 Heat Controller BHD-301-Gのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Heat Controller BHD-301-Gに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるHeat Controller BHD-301-Gのメーカー/サービスへの連絡先に関する情報。

Heat Controller BHD-301-Gについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもHeat Controller BHD-301-Gの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがHeat Controller BHD-301-Gで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)