English dropdown-ico

Manual Heat Controller BHD-301-G

17 pages 1.05 mb
Download

Go to site of 17

Summary
  • Heat Controller BHD-301-G - page 1

    Heat Controller , Inc. • 1900 Wellworth A ve. • Jackson, MI 49203 • (517)787-2100 • www .heatcontroller .com SER VICE MANU AL Portable Dehumidifer Series with R-410A: BHD-301-G BHD-501-G BHD-651-G ...

  • Heat Controller BHD-301-G - page 2

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 1 T ABLE OF CONTENTS 1. PREF ACE ............................................................................................ 2 1.1 SAFETY PRECAUTIONS ...................................................... 2 1.2 INSULA TION RESIST ANCE TEST .............................. ...

  • Heat Controller BHD-301-G - page 3

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 2 1. PREF ACE This SERVICE MANUAL provides various servicing information for the unit, including the mechanical and electrical parts, etc. This dehumidier was manufactured and assembled under a strict quality control system. The refrigerant is charged at the factory . ...

  • Heat Controller BHD-301-G - page 4

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 3 3. Humidity Set Control The humidity level can be set within a range of 35%RH (Relative Humidity) to 85%RH (Relative Humidity) in 5% increments. For drier air , press the button and set to a lower percent value(%). When the value displays 35%,press the button again wil ...

  • Heat Controller BHD-301-G - page 5

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 4 2. Product Installation Instructions Install the portable dehumidier in a at and spacious location where the air outlets will not be obstructed. Do not install underneath desks or inside cupboards as this will restrict the air ow . Maintain a clearance of at l ...

  • Heat Controller BHD-301-G - page 6

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 5 3.4 OPERA TION WITH CONTINUOUS DRAINAGE On the rear of the unit, remove the rubber plug carefully . Remove the water tank rst, then push the hose onto the connector located inside of the hole. The hose should go down smoothly without bends or kinks. Place the end of ...

  • Heat Controller BHD-301-G - page 7

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 6 4.Electronic function 4.1 POWERING ON THE UNIT When the unit is just powered on or the dropped power is just restored, the unit will immediately perform the self- diagnosis. The check items include the water-full, temperature sensor and humidity sensor . If there is no ...

  • Heat Controller BHD-301-G - page 8

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 7 5.Basic T est Procedures 5.1 DEFECTIVE COMPRESSOR Compressors are single phase, 1 15 volt. All compressor motors are permanent split capacitor type using only a running capacitor across the start and run terminal. All compressors are internally spring mounted and exter ...

  • Heat Controller BHD-301-G - page 9

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 8 5.2 SEALED REFRIGERA TION SYSTEM REP AIRS EQUIPMENT REQUIRED 1. V oltmeter 2. Ammeter 3. Ohmmeter 4. E.P .A. Approved Refrigerant Recovery System. 5. V acuum Pump (capable of 200 microns or less vacuum.) 6. Acetylene Welder 7. Electronic Halogen Leak Detector (G.E. T y ...

  • Heat Controller BHD-301-G - page 10

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 9 1 1. Break vacuum by charging system from the high side with the correct amount of refrigerant specied. This will prevent boiling the oil out of the crankcase. NOTE : If the entire charge will not enter the high side, allow the remainder to enter the low side in sma ...

  • Heat Controller BHD-301-G - page 11

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 10 CAP ACITOR - TEST 1. Remove capacitor from unit. 2. Check for visual damage such as bulges, cracks, or leaks. 3. For dual rated, apply an ohmmeter lead to common (C) terminal and the other probe to the compressor (HERM) terminal. A satisfactory capacitor will cause a ...

  • Heat Controller BHD-301-G - page 12

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 1 1 6. TROUBLESHOOTING GUIDE 6.1 TROUBLESHOOTING GUIDE In general, possible trouble is classied in three kinds. One is called Starting Failure which is caused from an electri - cal defect, another is ineffective Air Conditioning caused by a defect in the refrigeration ...

  • Heat Controller BHD-301-G - page 13

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 12 6.3.3 Humidity sensor check 6.3.4 Fail to start or fail to start motor ...

  • Heat Controller BHD-301-G - page 14

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 13 6.3.5 Abnormal noise 6.3.6 Complaint and remedy Complaint Cause Remedy No display or any button failure. T ransformer (Discharge transformer before testing) Check resistance between the two input/output lines on transformer . Replace the transformer if either of the i ...

  • Heat Controller BHD-301-G - page 15

    Heat Controller , Inc. Portable Dehumidier with R-410A BHD-G Service Manual 14 Complaint Cause Remedy Fan motor noise Fan Replace the fan if cracked, out of balance, or partially missing. Blower Replace the blower if cracked, out of balance, or partially missing. Loose screws T ighten them. Worn bearings Replace the motor if knocking sounds cont ...

  • Heat Controller BHD-301-G - page 16

    BHD-G Service Manual Portable Dehumidier with R-410A Heat Controller , Inc. 15 7. Wiring Diagram ...

  • Heat Controller BHD-301-G - page 17

    04/2009 05/2010 ...

Manufacturer Heat Controller Category Dehumidifier

Documents that we receive from a manufacturer of a Heat Controller BHD-301-G can be divided into several groups. They are, among others:
- Heat Controller technical drawings
- BHD-301-G manuals
- Heat Controller product data sheets
- information booklets
- or energy labels Heat Controller BHD-301-G
All of them are important, but the most important information from the point of view of use of the device are in the user manual Heat Controller BHD-301-G.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Heat Controller BHD-301-G, service manual, brief instructions and user manuals Heat Controller BHD-301-G. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Heat Controller BHD-301-G.

Similar manuals

A complete manual for the device Heat Controller BHD-301-G, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Heat Controller BHD-301-G by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Heat Controller BHD-301-G.

A complete Heat Controller manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Heat Controller BHD-301-G - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Heat Controller BHD-301-G, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Heat Controller BHD-301-G, that we can find in the current document
3. Tips how to use the basic functions of the device Heat Controller BHD-301-G - which should help us in our first steps of using Heat Controller BHD-301-G
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Heat Controller BHD-301-G
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Heat Controller BHD-301-G in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Heat Controller BHD-301-G?

Use the form below

If you did not solve your problem by using a manual Heat Controller BHD-301-G, ask a question using the form below. If a user had a similar problem with Heat Controller BHD-301-G it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)