-
Heatiator ECO-ADV-WS22 - page 1
www .heatilator .com DO NOT DISCARD THIS MANUAL NOTICE • I m p o r t a n t o p e r a t i n g and maintenance instructionsincluded. • Leavethis manualwith party responsible for useandoperation. • Read, understand and follow theseinstructions for safe installation ...
-
Heatiator ECO-ADV-WS22 - page 2
2 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 SAMPLE OF SERIAL NUMBER / SAFETY LABEL ? ...
-
Heatiator ECO-ADV-WS22 - page 3
3 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 T ABLE OF CONTENTS Safety Alert Key: • DANGER! Indicatesahazardoussituationwhich,ifnotavoided will resultindeathorseriousinjury . • W ARNING! Indicatesahazardoussituationwhich,ifnotavoided ...
-
Heatiator ECO-ADV-WS22 - page 4
4 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 W arranty Policy W arranty Period Heatilator ECO-CHOICE Parts Pellet EP A Wood 1year X X Allpartsandmaterialexceptascoveredby Condition ...
-
Heatiator ECO-ADV-WS22 - page 5
5 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 W ARRANTY COVERAGE: • ThiswarrantyonlycoversHHTappliancesthatarepurchasedthroughanHHT authorizeddealerordistributor . A listof HHTauthorizeddealersisavailableonthHHT brandedweb ...
-
Heatiator ECO-ADV-WS22 - page 6
6 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 1 The ECO-CHOICEby Heatilator wood stove meetsthe U.S. Environmental Protection Agency’s 1990 particulate emis - sionstandards. ...
-
Heatiator ECO-ADV-WS22 - page 7
7 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 2 W ARNING! DO NOT operate appliance before reading and understanding operating instructions. Failuretooperateapplianceaccordingtooperatinginstructionscouldcausere ...
-
Heatiator ECO-ADV-WS22 - page 8
8 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 T o provide reasonable re safety , the following should be givenseriousconsideration: 1. Install at least one smoke detector on each oor of your home? ...
-
Heatiator ECO-ADV-WS22 - page 9
9 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Inrecentyearstherehasbeenanincreasingconcernabout air quality . Much of the blame forpoor air quality has been placedontheburning? ...
-
Heatiator ECO-ADV-WS22 - page 10
10 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 • The air supply enters at the upper front of the ...
-
Heatiator ECO-ADV-WS22 - page 11
1 1 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 CORRECT POSITION INCORRECT POSITIONS Ceramic Blanket and Bafe Board are NOT in contactwiththebackoftherebo ...
-
Heatiator ECO-ADV-WS22 - page 12
12 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Beforelightingyourrstreintheappliance: 1. Conrm the baf e and ceramic blanket are correctly positioned. See fo ...
-
Heatiator ECO-ADV-WS22 - page 13
13 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Moisture Seasoned Wood • Cutlogstosize • Splitto6inches(152mm)orlessindiameter . • Airdrytoamoisturecontentofaround20% - *Softwood-aboutnin ...
-
Heatiator ECO-ADV-WS22 - page 14
14 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 7. Ifyoundthe blowercomingon andoffatundesirable temperatures, reloc ate the snap disc to another location in the designated zone on ...
-
Heatiator ECO-ADV-WS22 - page 15
15 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Opacity is the measure of how cleanly your appliance is burning. Opacityismeasuredinpercent: • 100%opacityiswhenanobjectistotallyobscured? ...
-
Heatiator ECO-ADV-WS22 - page 16
16 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 1 2 3 6 7 FIRST FIRE ITEMS NEEDED: 10PiecesofNewspaper ,10-20PiecesofDryKindling andaFewPiecesofDrySpli ...
-
Heatiator ECO-ADV-WS22 - page 17
17 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 3 When ash is within 1-3/4 inch (44mm) of fireboxlip. Leave 1/4to 1/2inch(6-13mm) ofashinthe? ...
-
Heatiator ECO-ADV-WS22 - page 18
18 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Asdesired Homeowner • Cleanglasswitha non-abrasiveglasscleaner . Abrasive cleanersmayscratchandcauseglasstocrack. • If the deposits? ...
-
Heatiator ECO-ADV-WS22 - page 19
19 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Baffle Blanket Latch Cam Spacing Washers Bafe&Blanket OptionalBlower ChimneySystem Firebrick& AshRemoval Door&Glass Assemblies DoorHandle Frequency MONTHL Y or AfterEvery CordofWood Bafeandbla ...
-
Heatiator ECO-ADV-WS22 - page 20
20 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 4 With proper installation, operation, and maintenance your woodstove will provide years of trouble-free service. If you do experiencea problem,? ...
-
Heatiator ECO-ADV-WS22 - page 21
21 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 5 1 . Ensure that the re is out and the applianc e is co ol to the touch. 2.? ...
-
Heatiator ECO-ADV-WS22 - page 22
22 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Baffle Boards & Blanket even with front tube and resting on tubes Baffle Protection Channel Ceramic Blanket on T op T ube Channels 2 pc Baffle Board Burn Rate Air Control ...
-
Heatiator ECO-ADV-WS22 - page 23
23 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 1. Installwasherondoorhandleshaft. 2. Slidedoorhandlethroughdoor . 3. Installsecondwasher(s)asshownin ...
-
Heatiator ECO-ADV-WS22 - page 24
24 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 1. Removethebafe ...
-
Heatiator ECO-ADV-WS22 - page 25
25 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 6 Installer ’ s Guide A Beforeinstalling,determinethefollowing: • T ypeofch ...
-
Heatiator ECO-ADV-WS22 - page 26
26 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Marginal Location: • Below peak Location NOT recommended: • Not the highest point of the roof • Wind loading possible Multi-level Roofs Windward Leeward Recommended: Outside Air Intake on windward side NOT recommended: Outside Air Intake on leeward side Recomme ...
-
Heatiator ECO-ADV-WS22 - page 27
27 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 ...
-
Heatiator ECO-ADV-WS22 - page 28
28 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 T o provide reasonable re safety , the following should be givenseriousconsideration: 1. Instal ...
-
Heatiator ECO-ADV-WS22 - page 29
29 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 7 Dimensions and Clearances NOTE: Flue Collar size ...
-
Heatiator ECO-ADV-WS22 - page 30
30 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 A B C D E F G H INST ALLA TION: Full V ertical OR Horizontal with 2 foot (609mm) minimum vertical Off Stove T op SINGLE W ALL PIPE 10 (254) 8.25 (210) 21 (533) 1 1 (279) 3.5 (89) 12.5 (318) 49 (1245) * DOUBLE W ALL PIPE 9 (229) 7 (178) 19.5 (495) 9 (229) 3 (76) 12 (3 ...
-
Heatiator ECO-ADV-WS22 - page 31
31 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 FLOOR PROTECTION: • Mustbenon-combustiblematerial. • Extend beneath heater and to the front, sides and rear? ...
-
Heatiator ECO-ADV-WS22 - page 32
32 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Thekvaluein ...
-
Heatiator ECO-ADV-WS22 - page 33
33 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 8 Thechimneyconnectorjoinsthestovetothechimney . • It must be a 6 inch ( ...
-
Heatiator ECO-ADV-WS22 - page 34
34 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 • Must be a mini mum 6 inc h (152mm) diameter (ID) high temperature chimney listedto UL 103 HT (2100 o F) or ULCS629M. • Must use components required by the manufacturer for? ...
-
Heatiator ECO-ADV-WS22 - page 35
35 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Floor Protector Thimble, 12 in. (305mm) Of Brick Ceiling Joist Combustible W all Airtight Cleanout Door Fireclay Flue Liner With Air Space Sheathing Eave 1 in. (25mm) Clearance With ...
-
Heatiator ECO-ADV-WS22 - page 36
36 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Thimble Assembly: 12 in. (305mm) of brick separation between clay liner and combustibles. Fireclay liner 5/8 in. (16mm) Minimum or Equivalent. Sill support Header Wood Stud 2 in. (51mm) Clear ...
-
Heatiator ECO-ADV-WS22 - page 37
37 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 T rim Collar Chimney Section with 2 inch (51mm) Clearance to Combustibles Chimney Connector Fire Clay Flue Liner with Airspace Masonry Chimney W all Band to Secure ...
-
Heatiator ECO-ADV-WS22 - page 38
38 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Chimney Flue Liner Fireclay Liner or Equivalent Masonry Chimney Constructed to NFP A 21 1 W all Spacer W all Band T rim Collar Chimney Connector 1 inch (25mm) Air Space to Chimney Section Min. Clearance 2 inch (51mm) Min. Chimney Clearance to W all Spacer and Combust ...
-
Heatiator ECO-ADV-WS22 - page 39
39 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Instructions 1. Rear : Re move t he acces s cov er on the back of the pedest al anddiscard. ...
-
Heatiator ECO-ADV-WS22 - page 40
40 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 10. Burn wood only . Other types of fuels may generate poisonousgases(e.g.,carbonmonoxide). 1 1. If unit burns poorly while an exhaust blower is on in home,(i.e.,rangehood), ...
-
Heatiator ECO-ADV-WS22 - page 41
41 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 1. Alignholesin mountingangeof blowerwithbolt holesin appliance. Blowershould be positioned at bottom of ...
-
Heatiator ECO-ADV-WS22 - page 42
42 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 10 Reference Materials Service Parts 05/10 Part number list on following p ...
-
Heatiator ECO-ADV-WS22 - page 43
43 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 T oordertheentireassembly ,orderthetoplinepartnumberonly . T oorderanindividualpartfromanassembly ,orderthe? ...
-
Heatiator ECO-ADV-WS22 - page 44
44 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 T oordertheentireassembly ,orderthetoplinepartnumberonly . T oorderanindividualpartfroman? ...
-
Heatiator ECO-ADV-WS22 - page 45
45 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Performed By ...
-
Heatiator ECO-ADV-WS22 - page 46
46 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Performed By ...
-
Heatiator ECO-ADV-WS22 - page 47
47 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Homeowner ’ s Notes ...
-
Heatiator ECO-ADV-WS22 - page 48
48 Heatilator•ECO-ADV -WS22•7057-128C• August13,2010 Datepurchased/installed: SerialNumber: Locationonappliance: Dealershippurchasedfrom: Dealerphone: Notes: ? ...
Do you have a question concerning Heatiator ECO-ADV-WS22?
Use the form below
If you did not solve your problem by using a manual Heatiator ECO-ADV-WS22, ask a question using the form below. If a user had a similar problem with Heatiator ECO-ADV-WS22 it is likely that he will want to share the way to solve it.