English dropdown-ico

Manual Carrier WEATHERMAKER ZONEKIT2ZCAR

16 pages 0.13 mb
Download

Go to site of 16

Summary
  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 1

    ZONEKIT2ZCAR WeatherMaker® Two-Zone Installation and Start-Up Instructions NOTE: Read the entire instruction manual before starting the installation. This symbol → indicates a change since the last issue. TABLE OF CONTENTS PAGE Safety Considerations .....................................................................1 Installation Consideration ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 2

    Step 2—Wiring To prevent personal injury or possible equipment damage, disconnect the power supply before routing wire. All wiring must comply with local, state, and national codes. NOTE: Use No. 18 AWG color-coded, insulated (35°C min) wire. If thermostats are to be located more than 100 ft from the WeatherMaker Two-Zone Center as measured alon ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 3

    2. Properly seal joint using duct tape, mastic, or other approved method. Do not allow mastic to come in contact with actuator. 3. Insulate damper using 1-1/2-in. to 2-in. insulation. (Check your local codes.) (See Fig. 7.) NOTE: All zone dampers and ductwork must be properly sup- ported according to local codes or SMACNA standards. NOTE: There sho ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 4

    Step 5—Install Barometric Bypass Damper NOTE: The barometric bypass damper is a critical part of the WeatherMaker Two-Zone System for control of minimum airflow and noise reduction. It is recommended that the bypass be installed. The bypass should be installed according to local codes and SMACNA standards. Be sure the bypass is properly supported ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 5

    In automatic changeover, the zoning system works on a first come first serve basis. If 1 zone is calling for heating and the other for cooling, the zone which sent its demand to the I/O center first will operate the equipment in that mode until that zone is satisfied. Step 5—Duct Temperature Optimizer (DTO) For Monitoring Leaving Air Temperature ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 6

    Fig. 12—WeatherMaker Two-Zone Circuit Board with Standard Thermostat Wiring A97293 3 Thermostat Zone 2 Y 2 Y 1 R W 1 W 2 C G Thermostat Zone 1 Y 2 Y 1 R W 1 W 2 C Sensors HP Duct Equipment R c B O Y 2 Y 1 W 1 W 2 G R h 24 VAC Power 24 v CL OP C Zone 1  Damper Zone 2  Damper CL OP C G B D 4 F A E C K J I H L M N 2 3 1 ZONE 1? ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 7

    NOTE: An HP temperature sensor must be used with a heat pump application using electric strip heat. This is necessary in case the DTO is set to the Off position. Timeguard The WeatherMaker Two-Zone provides equipment protection with an internal 5-minute timeguard delay. This delay is present upon initial power up. There is also a 5-minute timeguard ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 8

    timer will start counting down 15, 14, 13...0 minutes. Once the timer expires the control will allow a new mode to restart the equipment. The internal time, as well as the cooling 5-minute timeguard can be cleared by using the comprotec override feature. CARE AND MAINTENANCE For continuing optimum performance and to minimize possible equipment fail ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 9

    TROUBLESHOOTING This section contains information to assist you in troubleshooting problems and errors associated with the WeatherMaker Two-Zone system. See Table 2. Step 1—System Diagram, Jumpers, and Switches NOTE: For correct control board operation, it must have either a sensor attached or a 10k resistor in place at the duct and HP inputs. 1 ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 10

    I Red LED—Displays ON when fan is energized. J Red LED—Displays ON when first-stage cooling is energized. K Red LED—Displays ON when second-stage cooling is energized. L Red LED—Displays ON when reversing valve is ener- gized. M Red LED—Displays ON when first-stage heat is energized. N Red LED—Displays ON when second-stage heat is energ ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 11

    Table 3 shows a temperature/ohm/voltage relationship to help aid in troubleshooting the WeatherMaker Two-Zone System. This table will evaluate both the Duct/HP temperature sensor operation. Use a digital multimeter to perform the following: To verify a sensor is good, disconnect both leads from the I/O board and measure the resistance through the s ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 12

    → Fig. 17—Typical Fan Coil With Single-Speed Air Conditioner A97298 SINGLE-SPEED AIR CONDITIONER TYPICAL FAN COIL C Y G W2 W3 C R Y/Y2 O L E RH G W2 W1 Y1 Y2 O B RC TWO-ZONE SYSTEM See notes 1 and 3 * * * * * Y1 * * → Fig. 15—Single-Stage Furnace With Single-Speed Air Conditioner A97296 SINGLE-SPEED AIR COND ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 13

    → Fig. 21—Typical Fan Coil With 2-Speed Air Conditioner A97302 2-SPEED AIR CONDITIONER TYPICAL FAN COIL R G R C W2 Y/Y2 E W3 L O Y1 C Y2 Y1 RH G W2 W1 Y1 Y2 O B RC TWO-ZONE SYSTEM See notes 1, 2, and 3 * * * * * → Fig. 19—Single-Stage Furnace With 2-Speed Air Conditioner A97300 2-SPEED AIR CONDITIONER SINGLE ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 14

    → Fig. 23—Single-Stage Furnace With Single-Speed Heat Pump A97304 SINGLE-STAGE FURNACE TWO-ZONE SYSTEM INTERFACE CONTROL R GF RF WF R GT E HP O HP OT Y HP C W2 Y O RH G W2 W1 Y1 Y2 O B RC G R W C SINGLE-SPEED HEAT PUMP YT E T C  Y 2 1 3  OUTDOOR THERMOST A T (KHAO T0301FST) See notes 4, 5, 6, a ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 15

    → Fig. 27—Single-Stage Furnace With 2-Speed Heat Pump A97308 2-SPEED HEAT PUMP SINGLE-STAGE FURNACE R G R C W Y C Y2 W3 RH G W2 W1 Y1 Y2 O B RC TWO-ZONE SYSTEM W2 Y1 O See notes 2, 5, 6, 7, 9, 10, and 11 → Fig. 25—Typical Fan Coil With Single-Speed Heat Pump A97306 SINGLE-SPEED HEAT PUMP TWO-ZONE SYSTEM TYPI ...

  • Carrier WEATHERMAKER ZONEKIT2ZCAR - page 16

    → Fig. 29—Typical Fan Coil With 2-Speed Heat Pump A97310 RH G W2 W1 Y1 Y2 O B RC 2-SPEED HEAT PUMP TYPICAL FAN COIL C G W2 Y/Y2 R C W3 L E Y1 R W2 O W3 Y1 Y2 O TWO-ZONE SYSTEM See notes 1, 2, 3, 9, and 11 * * * * * → Fig. 30—FK4C Fan Coil With 2-Speed Heat Pump A97311 FK4C FAN COIL R R G W1 C DH W2 Y1 Y/Y2 O ...

Manufacturer Carrier Category Air Conditioner

Documents that we receive from a manufacturer of a Carrier WEATHERMAKER ZONEKIT2ZCAR can be divided into several groups. They are, among others:
- Carrier technical drawings
- WEATHERMAKER ZONEKIT2ZCAR manuals
- Carrier product data sheets
- information booklets
- or energy labels Carrier WEATHERMAKER ZONEKIT2ZCAR
All of them are important, but the most important information from the point of view of use of the device are in the user manual Carrier WEATHERMAKER ZONEKIT2ZCAR.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Carrier WEATHERMAKER ZONEKIT2ZCAR, service manual, brief instructions and user manuals Carrier WEATHERMAKER ZONEKIT2ZCAR. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Carrier WEATHERMAKER ZONEKIT2ZCAR.

Similar manuals

A complete manual for the device Carrier WEATHERMAKER ZONEKIT2ZCAR, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Carrier WEATHERMAKER ZONEKIT2ZCAR by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Carrier WEATHERMAKER ZONEKIT2ZCAR.

A complete Carrier manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Carrier WEATHERMAKER ZONEKIT2ZCAR - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Carrier WEATHERMAKER ZONEKIT2ZCAR, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Carrier WEATHERMAKER ZONEKIT2ZCAR, that we can find in the current document
3. Tips how to use the basic functions of the device Carrier WEATHERMAKER ZONEKIT2ZCAR - which should help us in our first steps of using Carrier WEATHERMAKER ZONEKIT2ZCAR
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Carrier WEATHERMAKER ZONEKIT2ZCAR
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Carrier WEATHERMAKER ZONEKIT2ZCAR in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Carrier WEATHERMAKER ZONEKIT2ZCAR?

Use the form below

If you did not solve your problem by using a manual Carrier WEATHERMAKER ZONEKIT2ZCAR, ask a question using the form below. If a user had a similar problem with Carrier WEATHERMAKER ZONEKIT2ZCAR it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)