-
FMI FVFM27NR - page 1
For more information, visit www .fmiproducts.com W ARNING: If the information in this manual is not ...
-
FMI FVFM27NR - page 2
www .fmiproducts.com 121353-01H 2 SAFETY alteration, service or maintenance can cause - ...
-
FMI FVFM27NR - page 3
www .fmiproducts.com 121353-01H 3 Early signs of carbon monoxide poisoning resemble the u, with headac ...
-
FMI FVFM27NR - page 4
www .fmiproducts.com 121353-01H 4 SAFETY Continued 12. This heater needs fresh, outside air ven - tilation to run properly . This heater has an oxyg en deplet ion sens ing (ODS) pilo t light safety system. The ODS shuts down the heater if not enough fresh air is available. See Air for Combustion and V entilation , page 6. If heater keeps shutting o ...
-
FMI FVFM27NR - page 5
www .fmiproducts.com 121353-01H 5 Figure 1 - Product Identication Control Knob Piezo Ignitor Log Set Base Assembly Optional Remote Control Flame Adjustment Knob Optional Selector Switch PRODUCT IDENTIFICA TION UNP ACkING CAUTION: Do not remove the ? ...
-
FMI FVFM27NR - page 6
www .fmiproducts.com 121353-01H 6 REMO TE CONTROL A CCESSORIES you classif y your space and provide adequa te ventilation. Th e a ir t ha t le ak s a rou nd do or s an d w ind ow s may provide enough fresh air for combus - ti on an d ven til at ion . How ever , in ...
-
FMI FVFM27NR - page 7
www .fmiproducts.com 121353-01H 7 DETERMINING FRESH-AIR FLOW FOR HEA TER LOCA TION Use this work sheet to determine if you have a conned or unconned space. Incl udes ...
-
FMI FVFM27NR - page 8
www .fmiproducts.com 121353-01H 8 INST ALLA TION Outlet Air V e ntilated Attic Outlet Air Inlet Air Inlet Air V e ntilated Crawl Space T o Crawl Space T o Attic AIR FOR COMb USTION AND VENTILA TION Continued Figure 2 - V entilation Air from Inside Building Or Remove Door into Adjoining Room, Option 3 V e ntilation Grills Into Adjoining Room, Option ...
-
FMI FVFM27NR - page 9
www .fmiproducts.com 121353-01H 9 W ARNING: Never install the heater unless installed as a vented ...
-
FMI FVFM27NR - page 10
www .fmiproducts.com 121353-01H 10 INST ALLA TION Continued Figure 5 - Heat Resistant Material (Slate, Marble, Tile, etc.) Above Fireplace NOTICE : Manual control heaters If so, you must always run heater ? ...
-
FMI FVFM27NR - page 11
www .fmiproducts.com 121353-01H 11 Figure 6 - Minimum Mantel Clearances Without Using Hood Minimum Noncombustible Material Minimum Noncombustible Material Height Distances to Underside of Mantel T o p of Fireplace Opening Underside of Mantel Shelf Mantel Shelf 12" ( A ) 18" 20" 22" 24" All minimum distances are in inches 2 ...
-
FMI FVFM27NR - page 12
www .fmiproducts.com 121353-01H 12 14" Min. Combustible Material Noncombustible Material MANTEL CLEARANCES In addition to meeting noncombustible mate- rial clearances, you must also meet required clearances between replace openings and mantel shelf on each side of the replace. If you do not meet the clearances listed below , you will nee ...
-
FMI FVFM27NR - page 13
www .fmiproducts.com 121353-01H 13 INST ALLA TION Continued Diameter Area 5" 20 sq. inches 6" 29 sq. inches 7" 39 sq. inches 8" 51 sq. inches Minimum Permanent ? ...
-
FMI FVFM27NR - page 14
www .fmiproducts.com 121353-01H 14 INST ALLA TION Continued 3. Place heater base in replace. 4. Pl ac e log s in the ir pro per pos it io n on he at er base. See Installing Logs , page 17. 5. Cente r heater base and logs front-t o-bac k and side-to-side in replace. 6. Carefully remove logs without moving heater base. 7. Mark screw locations t ...
-
FMI FVFM27NR - page 15
www .fmiproducts.com 121353-01H 15 CAUTION: Use only new , - ? ...
-
FMI FVFM27NR - page 16
www .fmiproducts.com 121353-01H 16 INST ALLA TION Continued PRESSURE TESTING HEA TER GAS CONNECTIONS 1. Open equipment shutoff valve (see Fig - ure 15). 2. Open main gas valve located on or near gas meter for natural gas or open pro - pane/LP supply tank valve. 3. Make sure control knob of heater is in the OFF position. 4. Check all joints from equ ...
-
FMI FVFM27NR - page 17
www .fmiproducts.com 121353-01H 17 INST ALLA TION Continued as illustrated in gure 20. 4. Make sure open areas of logs line up with burner ports (see gure 21). Logs will t securely on chassis. IMPORT ANT : Make sure log does not cover any burner ports. INST ALLING LOGS ...
-
FMI FVFM27NR - page 18
www .fmiproducts.com 121353-01H 18 OPERA TION LIGHTING INSTRUCTIONS W ARNING: ? ...
-
FMI FVFM27NR - page 19
www .fmiproducts.com 121353-01H 19 OPERA TION Continued 5. W ait ve (5) minutes to clear out any gas. Then smell for gas, including near the oor . If you smell gas, STOP! Follow “B” in the safety information, page 18. If you don’t smell gas, go to the next step. 6. Press in and turn control knob counter- clockwise to the PIL OT position ...
-
FMI FVFM27NR - page 20
www .fmiproducts.com 121353-01H 20 TO TURN OFF GAS TO APPLIANCE 1. T urn control knob clockwise to the OFF position. 2a. Set selector switch in the OFF position. 2b. Set selector switch in the OFF position to prevent draining battery . 3 ...
-
FMI FVFM27NR - page 21
www .fmiproducts.com 121353-01H 21 THERMOST A T SERIES (MODEL The hand-held remote can be operated using either the manual mode (MANU) or thermo- stati c mode (AUT O) (see Figure 27). T o select Fah ren heit /Ce nti gra de mode displ ay , car efu lly press the ˚C/˚F mode button with the end of a paper clip or similar blunt o ...
-
FMI FVFM27NR - page 22
www .fmiproducts.com 121353-01H 22 Figure 28 - Correct Pilot Flame Pattern (Propane/LP Pilot Shown) Pilot Burner Thermocouple Pilot Burner Thermocouple Figure 29 - Incorrect Pilot Flame Pattern (Propane/LP Pilot Shown) Air is drawn into the burner through the holes in the t ...
-
FMI FVFM27NR - page 23
www .fmiproducts.com 121353-01H 23 W ARNING: T urn off heater - ? ...
-
FMI FVFM27NR - page 24
www .fmiproducts.com 121353-01H 24 AUTO OFF ON Thermopile TROUbLESHOO TING ? ...
-
FMI FVFM27NR - page 25
www .fmiproducts.com 121353-01H 25 ODS/pilot lights but flame goes out when control knob is released Burner does not light after ODS/pilot is lit Delayed ignition burner Burner backring during com - bustion 1 . Control knob not fully pressed in 2. Control ...
-
FMI FVFM27NR - page 26
www .fmiproducts.com 121353-01H 26 TROUbLESHOO TING Continued Slight smoke or odor during initial operation Moisture/condensation no - ticed on windows Heater produces a whistling noise when burner is lit White powder residue forming within burner box or on adja - cent walls or furniture Remote does ...
-
FMI FVFM27NR - page 27
www .fmiproducts.com 121353-01H 27 TROUbLESHOO TING Continued Heater produces unwanted odors Heater shuts off in use (ODS operates) Gas odor even when control knob is in OFF position Gas odor during combustion 1. Heater burning vapors from paint, hair spray ...
-
FMI FVFM27NR - page 28
www .fmiproducts.com 121353-01H 28 SPECIFICA TIONS • Rating (V ariable): 20,000/39,000 Btu/Hr • Gas T ype: Natural Gas • Ignition: Piezo • Manifold Pressure: 3.5" W .C. • Inlet Gas Pressure (in. of water): Maximum - 10.5" W .C., Minimum* - 5" W .C. • Shipping W ...
-
FMI FVFM27NR - page 29
www .fmiproducts.com 121353-01H 29 ACCESSORIES FIREPLACE HOOD Helps deect heat away from mantel or wall above replace. Fits opening 28" to 4" wide. Pe rm ane nt ...
-
FMI FVFM27NR - page 30
www .fmiproducts.com 121353-01H 30 P ARTS MODELS 4 8 2 1 12 11 14 13 17 16 11 11 15 20 11 18 5 7 6 3 10 11 19 9 8 22 21 Note: Part numbers 21 and 22 are for natural gas model only . ...
-
FMI FVFM27NR - page 31
www .fmiproducts.com 121353-01H 31 P ARTS LIST This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 28 of this manual. KEY DESCRIPTION 1 103779-01 ODS Pilot • • 1 103778-01 ODS Pilot • • 1 2 098249-01 O ...
-
FMI FVFM27NR - page 32
www .fmiproducts.com 121353-01H 32 P ARTS MODELS Set With 1/4'' Diameter ? ...
-
FMI FVFM27NR - page 33
www .fmiproducts.com 121353-01H 33 P ARTS LIST This list contains replaceable parts used in your heater . When ordering parts, follow the instructions listed under Replacement Parts on page 28 of this manual. KEY DESCRIPTION 2 122582-01 Log, 5-piece Multi-Sided • • • • 1 2a 122583-01 Front L ...
-
FMI FVFM27NR - page 34
www .fmiproducts.com 121353-01H 34 _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _________________________________________ ...
-
FMI FVFM27NR - page 35
www .fmiproducts.com 121353-01H 35 _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _________________________________________ ...
-
FMI FVFM27NR - page 36
121353-01 Rev . H 02/10 WARRANTY kEEP THIS WARRANTY FMI PRODUCTS, LL C LIMITED WARRANTIES New Products Standard Warranty: FM I PR O D UC TS , LL C w ar ra nt s th i s ne w pr o d u ct an d a n y pa rt s th e r eo f to b e fr ee fr o m de fe ct s i n ma te ri a l a nd w o rk ma ns hi p fo r a p er io d of f ou r ( 4 ) ye ar s fr om t h e d at e o f ...
Do you have a question concerning FMI FVFM27NR?
Use the form below
If you did not solve your problem by using a manual FMI FVFM27NR, ask a question using the form below. If a user had a similar problem with FMI FVFM27NR it is likely that he will want to share the way to solve it.