-
Cornelius TRIAD-150 - page 1
ICE/BEVERAGE DISPENSER MODEL: TRIAD–150 IMI CORNELIUS INC www .cornelius.com Operator ’ s Manual PRINTED IN U.S.A IMI CORNELIUS INC; 1998-2005 © Part No. 62091 1 101 May , 1998 Revised: December 19, 2005 Revision: C THIS DOCUMENT CONT AINS IMPORT ANT INFORMA TION This Manual must be read and understood before installing or operating this equip ...
-
Cornelius TRIAD-150 - page 2
i 62091 1 101 Rev A May , 1998 T ABLE OF CONTENTS Page MAINTENANCE 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DAIL Y (OR AS REQUIRED) 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WEEKL Y (OR AS REQUIRED) 1 . . . . . . . . . . ...
-
Cornelius TRIAD-150 - page 3
1 62091 1 101 MAINTENANCE The following dispenser maintenance should be performed at the intervals indicated: DAIL Y (or as required) Remove foreign material from vending area drip tray to prevent drain blockage. WEEKL Y (or as required) Clean vending area. Check for proper water drainage from the vending area drip tray . MONTHL Y Clean and sanitiz ...
-
Cornelius TRIAD-150 - page 4
2 62091 1 101 DISPENSER 1. CLEANING EXTERIOR SURF ACES Important: Perform the following daily . A. Remove the cup rest from drip tray . B. W ash the drip tray with soap solution. Rinse with clean water and allow solution to run down the drain. C. W ash cup rest with soap solution and rinse in clean water . Install the cup rest into the drip tray . ...
-
Cornelius TRIAD-150 - page 5
3 62091 1 101 BEVERAGE SYSTEM (IF APPLICABLE) W ARNING: Disconnect Power Before Cleaning! Do not use metal scrapers, sharp objects or abrasives on the ice storage hopper , top cover and the agitator disk, as damage may result. Do not use solvents or other cleaning agents, as they may attack the plastic material. Soap solution - Use a mixture of mil ...
-
Cornelius TRIAD-150 - page 6
4 62091 1 101 n. Discard the tank of sanitizing solution and reconnect the product (syrup or pre-mix) tanks. Oper- ate the valves until all sanitizer has been flushed from the system and only product (syrup or pre- mix) is flowing. B. Sanitize syrup lines, B-I-B Systems a. Remove all the quick disconnects from all the B-I-B containers. b. Fill a su ...
-
Cornelius TRIAD-150 - page 7
5 62091 1 101 W ARNING: If repairs are to be made to a product system, remove quick disconnects from the applicable product tank, then relieve the system pressure before proceeding. If repairs are to be made to the CO 2 system, stop dispensing, shut off the CO 2 supply , then relieve the system pressure before proceeding. If repairs are to be made ...
-
Cornelius TRIAD-150 - page 8
6 62091 1 101 T rouble Probable Cause BEVERAGES NOT SWEET ENOUGH. A. Empty syrup tank. B. Faucet brix requires adjusting. BEVERAGES NOT COLD (UNITS WITH BUIL T -IN COLD PLA TE). A. Unit standing with no ice in hopper – no ice in cold plate cabinet. Contact your local syrup or beverage equipment distributor for additional information and troublesh ...
-
Cornelius TRIAD-150 - page 9
7 62091 1 101 P ARTS LIST / EXPLODED VIEW ...
-
Cornelius TRIAD-150 - page 10
8 62091 1 101 BEV P ANEL PEPSI BEV P ANEL PEPSI 1 2 3 4 5 6 7 8 9 10 10 11 12 13 14 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 51 52 52 52 52 52 53 54 54 54 54 57 57 58 59 60 61 61 63 64 64 64 66 67 68 69 72 FIGURE 1. CABINST SECTION EXPLODED VIEW ...
-
Cornelius TRIAD-150 - page 11
9 62091 1 101 CABINET SECTION P ARTS LIST Index No. Part N o. Name 1 21491 Gate Slide 2 22081 Gate Restrictor 3 29303R Pla te, Mo tor Mounting 4 15346 Agitator Assy 5 29483 Cover , Rear W rapper 6 Contact Sales Lower Panel Assy 7 620019001 Electrical Box 8 29313 W rapper 9 Contact Sales Panel C/P Faucet Assy 10 27107 Bracket, Depressor Mtg. 1 1 101 ...
-
Cornelius TRIAD-150 - page 12
10 62091 1 101 CABINET SECTION P ARTS LIST (CONT’D) 51 70456 3/16 Pop Rivet 52 70171 # 8-32 x 3/8 Phil. T russ 53 70178 # 8-32 x 1/2 Phil. T russ 54 70204 # 8 x 1/2 A S.S. Phil. T russ 55 71089 Shoulder Screw 56 70250 1/4-20 T russ HD Phil Screw SS 57 15501 15500 Push Lever , Ice Dispense Lever Ass’y (Cup Activated) 58 70260 1/4-20 x 1 Phil RD ...
-
Cornelius TRIAD-150 - page 13
11 62091 1 101 1 13 4 18 17 16 15 22 7 11 19 11 19 6 9 22 22 10 3 2 5 22 8 19 FIGURE 2. ELECTRICAL BOX ASSEMBL Y EXPLODED VIEW ELECTRICAL BOX ASSEMBL Y Item No. Part No. Name 1 620303301 620302001 620302301 620303302 E-Box Ass’y , 1 15V (Ice only) E-Box Ass’y , 1 15V (B and BC Models) E-Box Ass’y , 220V (B and BC Models) E-Box Ass’y , 220V ...
-
Cornelius TRIAD-150 - page 14
12 62091 1 101 SOLENOID ASSEMBL Y 1 2 3 4 5 6 7 9 10 11 12 13 14 4 8 FIGURE 3. SOLENOID ASSEMBL Y Item No. Part No. Name 32954 Gate Solenoid Ass’y , 120 V olt 33397 Gate Solenoid Ass’y , 240 V olt 1 28172 Plate, Solenoid Mounting 2 28173 Arm, Gate Lift 3 32957 Solenoid 4 50752 Isolator 5 50754 B earing, Gate Arm 6 70162 Screw , No. 8-32 By 1/4- ...
-
Cornelius TRIAD-150 - page 15
13 62091 1 101 DRAIN 1 1 1 1 2 3 3 4 5 FIGURE 4. DRAIN FOR Z STYLE UNITS Item No. Part No. Name 1 70750 Hose Clamp 2 53170 Drain T ube 3 51280 Elbow 4 53293 Coupler 5 Contact Factory Lower Front Panel ...
-
Cornelius TRIAD-150 - page 16
14 62091 1 101 W ARRANTY IMI Cornelius Inc. warrants that all equipment and parts are free from defects in material and workman- ship under normal use and service. For a copy of the warranty applicable to your Cornelius, Remcor or W ilshire product, in your country , please write, fax or telephone the IMI Cornelius office nearest you. Please provid ...
-
Cornelius TRIAD-150 - page 17
www .cornelius.com IMI CORNELIUS INC. ...
Do you have a question concerning Cornelius TRIAD-150?
Use the form below
If you did not solve your problem by using a manual Cornelius TRIAD-150, ask a question using the form below. If a user had a similar problem with Cornelius TRIAD-150 it is likely that he will want to share the way to solve it.