English dropdown-ico

Manual Pitco RSCPE14

20 pages 0.89 mb
Download

Go to site of 20

Summary
  • Pitco RSCPE14 - page 1

    Installation & Operation Manual L20-274, rev. 0 (1/06) IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment: Model #: ___________________________ Serial #: ___________________________ Date Purchased: ____________________ ENGLISH CPE14*: Electric Counter Model Pasta Cooker RSCPE14: ...

  • Pitco RSCPE14 - page 2

    TO THE PURCHASER, OWNER AND STORE MANAGER Please review these warnings prior to posting th em in a prominent location for reference. ii WARNING DO NOT store or use gasoline or other flammable vapors and liqu ids in the v icinity of this or a ny other appliance. WARNING Improper installation, alteration, service or maintenance ca n cause property da ...

  • Pitco RSCPE14 - page 3

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER TABLE OF CONTENTS L20-274, rev. 0 (1/06) iii 1. INSTALLATION...................................................................................... 1 1.1. CHECKING YOUR NE W APPLIA NCE .......................................................................................... 1 1.2. INSTALLATION CLEARANCES . ...

  • Pitco RSCPE14 - page 4

    TABLE OF CONTENTS iv 3.2. MONTHLY PREVENTATIVE MAINTEN ANCE ........................................................................... 12 3.2.1. DE LIMING ................................................................................................................. ............ 12 3.3. ANNUAL/PERIODIC PREVENTATIVE MAINTENANCE A ND INSPECTI ON.. ...

  • Pitco RSCPE14 - page 5

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER INSTALLATION L20-274, rev. 0 (1/06) 1 1. INSTALLATION 1.1. CHECKING YOUR NEW APPLIANCE Your new Pitco appliance has b een carefully packe d into one crate. Every effort has bee n made to ensure that it is delivered to you in perfect conditi on. As you unpack your new appliance, inspe ct each of the pieces ...

  • Pitco RSCPE14 - page 6

    INSTALLATION 2 1.3. INSTALLATION TO COUNTER After the appliance is in its permanent location, check the levelne ss. Level the counter as needed. The appliance must be sealed to the counter to co mply with applicable sanitation standards. A bead of silicone sealant, approximately ½ inch wide, is to be applied to the bottom of the unit approximately ...

  • Pitco RSCPE14 - page 7

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER INSTALLATION L20-274, rev. 0 (1/06) 3 1.5. ELECTRICAL CONNECTIONS It is advised that this power supply be plugged into a wall receptacle that is controlled by the ventilation control. This will prevent the appliance from being operated with out the ventilator on. If your appliance require s an electrical c ...

  • Pitco RSCPE14 - page 8

    INSTALLATION 4 1) Probe 2) High Temperature Limit (may be either style) 3) Heating Element 1.6. VENTILATION AND FIRE SAFETY SYSTEMS Your new appliance must have proper ventilation to f unction saf ely and properly. It is very important to install a fire safety system. Your ventilation sy stem should be de signed to allow for easy cleanin g. Frequen ...

  • Pitco RSCPE14 - page 9

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER INSTALLATION L20-274, rev. 0 (1/06) 5 1.8. INITIAL CLEANING When your appliance is shippe d, many of its parts are covered with a thin coat of oil for protection. Before the appliance is ready for cookin g it must be cleaned. This will rem ove the oil coating and any foreign matter that may have accumulate ...

  • Pitco RSCPE14 - page 10

    OPERATION 6 2. OPERATION An operator’s manual for your appliance’s spe cific control type should be inclu ded with this manual. Refer to that manual prior to operating this ap pliance. 2.1. OPERATIONAL FEATURES The diagram below outlines some of the key operati onal comp onents of your appliance. Refer to the following sections of this manual t ...

  • Pitco RSCPE14 - page 11

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER OPERATION L20-274, rev. 0 (1/06) 7 1. Cook Tank 2. Controller (Not on all Models) Controls the water temperature inside the cook tank. Optional timers are located on the controller (if equi pped). Includes button to switch bet ween boil mode and simmer mod e (not on all models). If the controller has an ON ...

  • Pitco RSCPE14 - page 12

    OPERATION 8 Tank Capacity Model Capacity CPE14 7 Gal. (26.5 Liters) 2.2. FILLING THE APPLIANCE 2.2.1. FILLING T HE COOKER TANK It is recommended that the cooker ta nk is filled with hot water. This will greatly decrease the time it takes for the appliance to reach operating tempe rature. Refer to the following procedure to fill the cook tank prior ...

  • Pitco RSCPE14 - page 13

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER OPERATION L20-274, rev. 0 (1/06) 9 Typi cal Tim er Button s* 2.4. COOKING It is important to keep the cook tank full of wate r to minimize the chance of boiling the appliance dry and to keep the water at a level that will provide opt imum cooking pe rformance. To keep the water at its normal operating temp ...

  • Pitco RSCPE14 - page 14

    OPERATION 10 2.4.5. COOKING TIPS 9 Rinse pasta after cooking only if it is for cold dishes or if the pasta will NOT be served immediately. 9 For best results whe n cooking dry pasta, use at least 1 gallon of water for every 1 lb. of dry pasta. 9 Sticky cooked pasta ca n be avoided by increasi ng the quantity of water per p ound or use of the manual ...

  • Pitco RSCPE14 - page 15

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER PREVENTATIVE MAINTENANCE L20-274, rev. 0 (1/06) 11 WARNING Read the operation section of this manual prior to filling or operating the appliance. 3. PREVENTATIVE MAINTENANCE 3.1. DAILY PREVENTATIVE MAINTENANCE Performing the preventative mainte nance steps belo w on a daily basis will keep your equipment s ...

  • Pitco RSCPE14 - page 16

    PREVENTATIVE MAINTENANCE 12 WARNING The power supply must be disconnected before cleaning and servicing this appliance! 3.2. MONTHLY PREVENTATIVE MAINTENANCE Water can leave mineral depo sits inside the tank. Performing the monthly preventative maintenance steps below will keep your equipme nt safe and at peak performance. If you are prod ucing hig ...

  • Pitco RSCPE14 - page 17

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER PREVENTATIVE MAINTENANCE L20-274, rev. 0 (1/06) 13 3.3.4. CONTROL BOX & ELECTRI CAL COMPONENTS 9 Verify that heating contactors are in good con dit ion. Check for worn or pitted contact s. Verify that wires are tight and in good condition. 9 Verify that all components (transformer, termi nal block, rel ...

  • Pitco RSCPE14 - page 18

    TROUBLESHOOTING 14 High Temperature Reset Button (Not on all models) 4. TROUBLESHOOTING 4.1. POWER FAILURE If electric power is removed for any re ason, the appliance will shut down. To restart the appliance, follow the appliance start up procedure in section 2.2. 4.2. HIGH TEMPERATURE LIMIT This appliance is equipped with a high tem perature lim i ...

  • Pitco RSCPE14 - page 19

    CPE14: ELECTRIC COUNTER MODEL PASTA COOKER TROUBLESHOOTING L20-274, rev. 0 (1/06) 15 4.5. TROUBLESHOOTING CHART 4.6. CONTROLLER W ARNING DISPLAYS If your appliance is equipped with a temperature co nt roller it may display the following warnings on its display. Problem Probable Causes Corrective Actions No power to appliance. Check main building po ...

  • Pitco RSCPE14 - page 20

    L20-274, rev. 0 (1/06) In the event of problems with or questions about your order, please contact the Pitco Frialator factory at: (800) 258-3708 US a nd Canada only or (603) 225-6684 World Wide Website Address: www.pitc o.com In the event of proble ms with or questions ab o ut your equipment, please contact the Pi t co F ri a la to r Authorized Se ...

Manufacturer Pitco Category Pasta Maker

Documents that we receive from a manufacturer of a Pitco RSCPE14 can be divided into several groups. They are, among others:
- Pitco technical drawings
- RSCPE14 manuals
- Pitco product data sheets
- information booklets
- or energy labels Pitco RSCPE14
All of them are important, but the most important information from the point of view of use of the device are in the user manual Pitco RSCPE14.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Pitco RSCPE14, service manual, brief instructions and user manuals Pitco RSCPE14. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Pitco RSCPE14.

Similar manuals

A complete manual for the device Pitco RSCPE14, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Pitco RSCPE14 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Pitco RSCPE14.

A complete Pitco manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Pitco RSCPE14 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Pitco RSCPE14, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Pitco RSCPE14, that we can find in the current document
3. Tips how to use the basic functions of the device Pitco RSCPE14 - which should help us in our first steps of using Pitco RSCPE14
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Pitco RSCPE14
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Pitco RSCPE14 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Pitco RSCPE14?

Use the form below

If you did not solve your problem by using a manual Pitco RSCPE14, ask a question using the form below. If a user had a similar problem with Pitco RSCPE14 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)