-
Keating Of Chicago 2009 - page 1
1-800-K EA TI NG www .keatingofchicago.com Users Manual CU ST OM P AST A ® S Y S T E M E L EC TRIC SERIES 2 0 0 9 R EAD AN D SA VE TH I S MAN U AL F OR FUTUR E R E FE R E NCE. Keep this manual for training new personnel. S ECTION I: I NTR OD UCTION . . . . . . . . . . .. . . . . . . . . . . . . . 1 SEC T IO N II : INS T A L L A TI O N SH I PM E NT ...
-
Keating Of Chicago 2009 - page 2
i T his operating, inst allation, and service manual should be given to the user . T he operator of the Custom Past a ™ System should be familiar with the functions and operation of the cooker . T his manual must be kept in a prominent, easily reac hable location near the Past a System. P OST T H I S L AB E L I N A P R O M I N E NT LO C A T I O N ...
-
Keating Of Chicago 2009 - page 3
1 I INTRODUCTION Instructions in this manual should be read thoroughly before attempting to operate this Keating Electric Pasta Cooker . All installation and service on Keating Equipment must be performed by qualified, certified, licensed and/or authorized installation or service personnel. Operating information for Keating equipment has been prepa ...
-
Keating Of Chicago 2009 - page 4
SAFETY PRECAUTIONS THIS SYMBOL W ARNS YOU THA T SERIOUS BURNS OR OTHER INJURIES MA Y RESUL T IF SAFETY INSTRUCTIONS ARE NOT FOLLOWED. • This service manual should be retained in a safe place for future reference. The inst allation of your new Pasta System must conform to local codes and with the current National Electrical Codes and regulations a ...
-
Keating Of Chicago 2009 - page 5
3 II INST ALLA TION This Custom Pasta ™ System MUST be installed, inspected, calibrated and serviced by qualified and/or certified and/or licensed service personnel – you may void your Keating warranty if installation is not completed per current local, national and Keating specifications. Contact your dealer for assistance. DAMAGE DURING SHIPM ...
-
Keating Of Chicago 2009 - page 6
4 Push the fryer forward as far as it will go holding the fryer on approximately a 15° angle, and then drop the rear of the past a cooker into its proper position lowering it down gently so you do not deform the table or equipment stand. POSITIONING The past a cooker must be no closer than 6" from any combustible material. When placed under a ...
-
Keating Of Chicago 2009 - page 7
5 In most cases the health department will not allow a direct connection between the cooker drain and the floor receptical. Contact your local health dep artment for specific information in your area. III OPERA TION FILLING NOTE: Before filling the Past a System make certain the vessel is sanitized, dry and the drain valve is completely clo ...
-
Keating Of Chicago 2009 - page 8
6 thermostat calls for additional heat at st art up or occasionally when water is added. Follow cooking procedures below for your model. NOTE : Use of sodium chloride during the cooking process will have a detrimental ef fect on the cooker tank and will void the warranty . OPERA TION OF THIS P AST A SYSTEM SHOULD BE LIMITED TO PERSO ...
-
Keating Of Chicago 2009 - page 9
7 4. Fill Pasta System vessel with water . See page 6 – Filling. UNDER NO CIRCUMST ANCES SHOULD THE P AST A SYSTEM BE LEFT UNA TTENDED DURING BOIL-OUT . TRAINED PERSONNEL MUST BE PRESENT DURING THE PROCEDURE TO PREVENT BOIL OVER OR T O TURN OFF THE POWER IF W A TER DROPS BELOW HEA T TRANSFER TUBES. 5. T urn Pasta System on and bring water to a ge ...
-
Keating Of Chicago 2009 - page 10
8 When the countdown has reached "00:00" the relay output contact s will open, the display will flash, and the audible alarm will sound. T o cancel the audible alarm, press any button. C. P AUSE FEA TURE T o pause a cycle in progress, press any button. The relay output contact s will open, the display will flash, and the countdown will p ...
-
Keating Of Chicago 2009 - page 11
9 every calibration. Position near primary thermostat (center) bulb is recommended. 4. Pre-2000 model: If calibration of thermostat is found to be less than 15°F(9.44°C) off, simply loosen three dial plate retaining screws, rot ate dial plate to match thermometer reading and tighten screws. 2000-model: If calibration is found to be less than 15° ...
-
Keating Of Chicago 2009 - page 12
V SER VICE DIAGNOSIS THE COOKER MUST BE DISCONNECTED FROM ITS POWER SOURCE OR SHUT DOWN A T THE BREAKER PRIOR TO SER VICE. AUTO-FILL SYSTEM The auto-fill system allows the automatic addition of water to the past a cooker during cooking or idle function. The system is controlled by the on/of f switch explained in CLEANING . If the system should fail ...
-
Keating Of Chicago 2009 - page 13
11 COMMON PROBLEMS SOLUTIONS (FOLLOW IN SEQUENCE) W ater always filling 1. Clean sensors thoroughly with brush and vinegar . 2. Adjust the sensitivity of the B Board (for the top sensor) fully clockwise. 3. If filling persists, ground out the top sensor (if filling stops, replace sensor – Part #010212). 4. If filling persists after grounding the ...
-
Keating Of Chicago 2009 - page 14
PROBLEM PROBABLE CAUSE SOLUTION Pasta Cooker has poor recovery or runs cold. a. Over-filling baskets. b.Thermostat out of calibration. c. Element is faulty . d. Thermostat is faulty . e. Contactor is faulty . a. Don’t overfill baskets. b. Calibrate thermostat. See pages 9-10 - Calibration. c. Replace element. d. Replace thermostat. e. Replace con ...
-
Keating Of Chicago 2009 - page 15
VI P ARTS LIST 13 ITEM # DESCRIPTION QTY P ART # 1 INDICA TING LIGHT , AMBER - POWER ON 1 031624 2 TOGGLE SWITCH - MAIN ON-OFF 2 004499 3 INDICA TING LIGHT , GREEN - THERMOST A T HEA TING 2 009375 4 INDICA TING LIGHT , BLUE - WA TER AUTOMA TIC FILLING 1 009256 5 MANUAL WA TER FILL BUTTON 1 004304 NUT WITH BOOT 1 009389 6 DIGIT AL TIMERS 2 056921 14 ...
-
Keating Of Chicago 2009 - page 16
14 P ARTS LIST FOR CUSTOM P AST A SYSTEM ™ ITEM DESCRIPTION MODELS P ART # 14 18 20 24 1 HEA TING ELEMENT 220V 6500W 14" ONL Y 018668 2 1 HEA TING ELEMENT 220V 6000W 18" & 20" ONL Y 004353 3 3 1 HEA TING ELEMENT 220V 6000W 24” ONL Y 004355 4 (SEE DET AIL - QUANTITIES ARE PER ELEMENT ) B. W ASHER FLA T #10 059502 2222 C. W ASH ...
-
Keating Of Chicago 2009 - page 17
15 VII WIRING DIAGRAMS 14" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS) (2) ...
-
Keating Of Chicago 2009 - page 18
14" ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM 16 ...
-
Keating Of Chicago 2009 - page 19
17 14" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL) ...
-
Keating Of Chicago 2009 - page 20
18 14” ELECTRIC P AST A WITH BASKET -LIFT AND DIGIT AL TIMERS WIRING DIAGRAM ...
-
Keating Of Chicago 2009 - page 21
19 18" & 20" ELECTRIC P AST A WITH 138 TIMERS WIRING DIAGRAM (PRE-2000 SERIES) BLACK DIAL TIMER (NOT DIGIT AL) ...
-
Keating Of Chicago 2009 - page 22
20 18" ELECTRIC P AST A 2-THERMOST A T WIRING DIAGRAM (WITHOUT TIMERS) ...
-
Keating Of Chicago 2009 - page 23
21 24” ELECTRIC P AST A WITH DIGIT AL TIMERS WIRING DIAGRAM ...
-
Keating Of Chicago 2009 - page 24
...
-
Keating Of Chicago 2009 - page 25
K EA TI N G LI M ITE D WAR RANTY C AR D PLEASE C OM P LETE AN D MAIL A T ON CE–W AR RANTY IS N O T I N E FF ECT U NTI L C AR D IS R ETU R N E D. W AR RANTY CARD I S ALSO A V AI LAB LE T O C OM P LETE ON LI N E A T Y O U R CO NVE NIENCE . CO M P ANY: __________________________________________________________________________________________________ ...
У вас вопрос, касающийся Keating Of Chicago 2009?
Воспользуйтесь формуляром, находящимся ниже
Если с помощью найденной инструкции Вы не решили свою проблему с Keating Of Chicago 2009, задайте вопрос, заполнив следующий формуляр. Если у какого то из пользователей была похожая проблема с Keating Of Chicago 2009 со всей вероятностью он захочет поделиться методом ее решения.