Bedienungsanleitung Middleby Cooking Systems Group PS870 Series

24 Seiten 1.09 mb
Download

Zur Seite of 24

Summary
  • Middleby Cooking Systems Group PS870 Series - page 1

    OWNER'S OPERA TING AND INST ALLA TION MANUAL for domestic and standard export ovens ©2006 Middleby Marshall Inc. is a registered trademark of Middleby Marshall, Inc. All rights reserved. Middleby Cooking Systems Group • 1400 Toastmaster Drive • Elgin, IL 60120 • (847)741-3300 • FAX (847)741-4406 PS870 Series Gas Ovens P/N 59157 August ...

  • Middleby Cooking Systems Group PS870 Series - page 2

    2 ...

  • Middleby Cooking Systems Group PS870 Series - page 3

    3 MIDDLEBY MARSHALL INC. O VEN LIMITED W ARRANTY (Non U .S.A.) The Seller warrants equipment manufactured by it to be free from defects in material and workmanship for which it is responsible. The Seller’s obligation under this warranty shall be limited to replacing or repairing, at Seller’s option, without charge, F.O.B. Seller’s factory, an ...

  • Middleby Cooking Systems Group PS870 Series - page 4

    4 T able of Contents Page SECTION 1 DESCRIPTION .................................................................... 5 I . OVEN USES .................................................................... 5 I I. OVEN COMPONENTS .................................................... 5 A. Conveyor Motor Drive .............................................. ...

  • Middleby Cooking Systems Group PS870 Series - page 5

    5 ...

  • Middleby Cooking Systems Group PS870 Series - page 6

    6 ...

  • Middleby Cooking Systems Group PS870 Series - page 7

    7 ...

  • Middleby Cooking Systems Group PS870 Series - page 8

    8 ITEM QTY P / N D E S C R IPTION 1 1 55028 STOP,BACK SIDE CONV EXT 2 1 55027 STOP,SIDE END CONV EXT 3 1 59026 OWNER'S OPERATING & INSTALLATION MANUAL 4 1 42612 KIT,SUPPLEMENT SVC AGENCY LIST 5 1 33120-0056 PIPE,BLK 1-1/4" X 54" 6 1 22450-0130 BA G ,POLY4MIL 9" X 12"W/MINI-GRIP 7 1 59155 BUSHING,HEYCO SB 1500-18 8 1 590 ...

  • Middleby Cooking Systems Group PS870 Series - page 9

    9 ...

  • Middleby Cooking Systems Group PS870 Series - page 10

    10 D. STANDOFF INSTALLATION 1 Place screw, P/N 19A15144, through counter-bored hole in standoff, P/N 48522, and screw into weld nut on rear shroud. 2. Repeat procedure for both sides. ...

  • Middleby Cooking Systems Group PS870 Series - page 11

    11 CONVEYOR BELT REVERSAL Conveyor belt reversal consists of four steps: 1. Physically reversing the conveyor belt. 2. Moving the lower thermocouple. 3. Resetting direction jumper on the conveyor control board. 4. Switching the photo detector. REVERSING THE CONVEYOR BELT Remove the conveyor from the oven and find the master link location. Remove ma ...

  • Middleby Cooking Systems Group PS870 Series - page 12

    12 Connection Refer to the wiring diagram inside the machinery compart- ment of the oven to determine the correct connections for the electrical supply lines. Connect the supply as indicated on the wiring diagram. CAUTION The terms of the oven's warranty require all start-ups, conver- sions and service work to be performed by a Middleby Marsha ...

  • Middleby Cooking Systems Group PS870 Series - page 13

    13 Certain safety code requirements exist for the installation of gas ovens; refer to the beginning of Section 2 for a list of the installation standards. In addition, because a the oven is equipped with casters, the gas line connection shall be made with a connector that complies with the Standard for Connec- tors for Movable Gas Appliances, ANSI ...

  • Middleby Cooking Systems Group PS870 Series - page 14

    14 SECTION 3 - OPERA TION LOCATION AND DESCRIPTION OF CONTROLS A. Main On/Off Button Turns all oven functions on or off. If the oven is below the set point, it will rise to the set point and turn the conveyor on. If it is turned off and the oven is above 200° F, the blowers will remain on until the oven drops below 200° F. B. Conveyor Time Settin ...

  • Middleby Cooking Systems Group PS870 Series - page 15

    15 NORMAL OPERATION - STEP-BY-STEP- A. Main Screen 1. When the unit has been “OFF” for more than 1 minute the controller will display the screen saver, as shown in Figure 3-1. To start operation, push the “Enter/ Reset” button. The controller will display the “OFF” screen, as shown in Figure 3-2. 3. To change the temperature, push the ? ...

  • Middleby Cooking Systems Group PS870 Series - page 16

    16 4. To change the conveyor belt speed, push the “TIME” button. The controller will display the screen, shown in Figure 3-5. To change the minute setting, push the “ ← ← ← ← ← ” arrow button. Then push either the “ ↑ ” arrow or “ ↓ ” arrow buttons to increase or decrease the time accord- ingly. To change the second se ...

  • Middleby Cooking Systems Group PS870 Series - page 17

    17 III. QUICK REFERENCE: TROUBLESHOOTING SYMPTOM PROBLEM SOLUTION No electrical power • Check that the circuit breaker/fused disconnect is on. Make sure the emergenct stop button is on. Oven will not turn On. No gas pressure Burner did not light • Make sure main gas is on. • Turn oven off, and restart. If it still does not light, call for ser ...

  • Middleby Cooking Systems Group PS870 Series - page 18

    18 ...

  • Middleby Cooking Systems Group PS870 Series - page 19

    19 ...

  • Middleby Cooking Systems Group PS870 Series - page 20

    20 ...

  • Middleby Cooking Systems Group PS870 Series - page 21

    21 E. Blower Belts 1. To gain access to each blower belt compartment remove the four screws shown in Figure 4-8. Then, lift the rear shroud off its hangers. If access to the blower motors is required, remove the three mounting screws (two on the front of each shroud and one on the rear). Then, lift the end shroud straight up and off its hangers. 2. ...

  • Middleby Cooking Systems Group PS870 Series - page 22

    12 3 4 5 10 15 16, 17, 18 19 ITEM QTY. P/N DESCRIPTION 1 1 59081 DI G ITAL DISPLAY, PROGRAMMED 2 1 58678 MOTOR, CONVEYOR DRIVE 3 1 58679 CONVEYOR CONTROL BOARD 4 2 59168 INVERTER, PROGRAMMED 5 1 M9608 POWER SUPPLY 6 1 59337 KIT, THERMOCOUPLE (6 THERMOCOUPLES) 7 2 M9616 FAN, COOLING 8 2 57288 MOTOR, BLOWER 9 A 1 57141 AI R SWI TCH BURNER/BLOWER MOTO ...

  • Middleby Cooking Systems Group PS870 Series - page 23

    Wiring Diagrams (electrical schematics) Middleby-Marshall Model Number G208-240 volt 50/60 Hz, 1 Phase 54745 Rev. I ...

  • Middleby Cooking Systems Group PS870 Series - page 24

    24 ...

Produzent Middleby Cooking Systems Group Kategorie Oven

Dokumente, die wir vom Produzenten des Geräts Middleby Cooking Systems Group PS870 Series erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Middleby Cooking Systems Group
- Bedienungsanleitungen PS870 Series
- Produktkarten Middleby Cooking Systems Group
- Informationsbroschüren
- oder Energieetiketten Middleby Cooking Systems Group PS870 Series
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Middleby Cooking Systems Group PS870 Series.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Middleby Cooking Systems Group PS870 Series, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Middleby Cooking Systems Group PS870 Series. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Middleby Cooking Systems Group PS870 Series ansehen.

Die komplette Bedienungsanleitung des Geräts Middleby Cooking Systems Group PS870 Series, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Middleby Cooking Systems Group PS870 Series hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Middleby Cooking Systems Group PS870 Series verständlich ist.

Eine gänzliche Bedienungsanleitung von Middleby Cooking Systems Group sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Middleby Cooking Systems Group PS870 Series bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Middleby Cooking Systems Group PS870 Series befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Middleby Cooking Systems Group PS870 Series, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Middleby Cooking Systems Group PS870 Series - die uns die ersten Schritte während der Nutzung von Middleby Cooking Systems Group PS870 Series erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Middleby Cooking Systems Group PS870 Series hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Middleby Cooking Systems Group PS870 Series im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Middleby Cooking Systems Group PS870 Series?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Middleby Cooking Systems Group PS870 Series nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Middleby Cooking Systems Group PS870 Series hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)