Middleby Cooking Systems Group PS870 Seriesの取扱説明書

24ページ 1.09 mb
ダウンロード

ページに移動 of 24

Summary
  • Middleby Cooking Systems Group PS870 Series - page 1

    OWNER'S OPERA TING AND INST ALLA TION MANUAL for domestic and standard export ovens ©2006 Middleby Marshall Inc. is a registered trademark of Middleby Marshall, Inc. All rights reserved. Middleby Cooking Systems Group • 1400 Toastmaster Drive • Elgin, IL 60120 • (847)741-3300 • FAX (847)741-4406 PS870 Series Gas Ovens P/N 59157 August ...

  • Middleby Cooking Systems Group PS870 Series - page 2

    2 ...

  • Middleby Cooking Systems Group PS870 Series - page 3

    3 MIDDLEBY MARSHALL INC. O VEN LIMITED W ARRANTY (Non U .S.A.) The Seller warrants equipment manufactured by it to be free from defects in material and workmanship for which it is responsible. The Seller’s obligation under this warranty shall be limited to replacing or repairing, at Seller’s option, without charge, F.O.B. Seller’s factory, an ...

  • Middleby Cooking Systems Group PS870 Series - page 4

    4 T able of Contents Page SECTION 1 DESCRIPTION .................................................................... 5 I . OVEN USES .................................................................... 5 I I. OVEN COMPONENTS .................................................... 5 A. Conveyor Motor Drive .............................................. ...

  • Middleby Cooking Systems Group PS870 Series - page 5

    5 ...

  • Middleby Cooking Systems Group PS870 Series - page 6

    6 ...

  • Middleby Cooking Systems Group PS870 Series - page 7

    7 ...

  • Middleby Cooking Systems Group PS870 Series - page 8

    8 ITEM QTY P / N D E S C R IPTION 1 1 55028 STOP,BACK SIDE CONV EXT 2 1 55027 STOP,SIDE END CONV EXT 3 1 59026 OWNER'S OPERATING & INSTALLATION MANUAL 4 1 42612 KIT,SUPPLEMENT SVC AGENCY LIST 5 1 33120-0056 PIPE,BLK 1-1/4" X 54" 6 1 22450-0130 BA G ,POLY4MIL 9" X 12"W/MINI-GRIP 7 1 59155 BUSHING,HEYCO SB 1500-18 8 1 590 ...

  • Middleby Cooking Systems Group PS870 Series - page 9

    9 ...

  • Middleby Cooking Systems Group PS870 Series - page 10

    10 D. STANDOFF INSTALLATION 1 Place screw, P/N 19A15144, through counter-bored hole in standoff, P/N 48522, and screw into weld nut on rear shroud. 2. Repeat procedure for both sides. ...

  • Middleby Cooking Systems Group PS870 Series - page 11

    11 CONVEYOR BELT REVERSAL Conveyor belt reversal consists of four steps: 1. Physically reversing the conveyor belt. 2. Moving the lower thermocouple. 3. Resetting direction jumper on the conveyor control board. 4. Switching the photo detector. REVERSING THE CONVEYOR BELT Remove the conveyor from the oven and find the master link location. Remove ma ...

  • Middleby Cooking Systems Group PS870 Series - page 12

    12 Connection Refer to the wiring diagram inside the machinery compart- ment of the oven to determine the correct connections for the electrical supply lines. Connect the supply as indicated on the wiring diagram. CAUTION The terms of the oven's warranty require all start-ups, conver- sions and service work to be performed by a Middleby Marsha ...

  • Middleby Cooking Systems Group PS870 Series - page 13

    13 Certain safety code requirements exist for the installation of gas ovens; refer to the beginning of Section 2 for a list of the installation standards. In addition, because a the oven is equipped with casters, the gas line connection shall be made with a connector that complies with the Standard for Connec- tors for Movable Gas Appliances, ANSI ...

  • Middleby Cooking Systems Group PS870 Series - page 14

    14 SECTION 3 - OPERA TION LOCATION AND DESCRIPTION OF CONTROLS A. Main On/Off Button Turns all oven functions on or off. If the oven is below the set point, it will rise to the set point and turn the conveyor on. If it is turned off and the oven is above 200° F, the blowers will remain on until the oven drops below 200° F. B. Conveyor Time Settin ...

  • Middleby Cooking Systems Group PS870 Series - page 15

    15 NORMAL OPERATION - STEP-BY-STEP- A. Main Screen 1. When the unit has been “OFF” for more than 1 minute the controller will display the screen saver, as shown in Figure 3-1. To start operation, push the “Enter/ Reset” button. The controller will display the “OFF” screen, as shown in Figure 3-2. 3. To change the temperature, push the ? ...

  • Middleby Cooking Systems Group PS870 Series - page 16

    16 4. To change the conveyor belt speed, push the “TIME” button. The controller will display the screen, shown in Figure 3-5. To change the minute setting, push the “ ← ← ← ← ← ” arrow button. Then push either the “ ↑ ” arrow or “ ↓ ” arrow buttons to increase or decrease the time accord- ingly. To change the second se ...

  • Middleby Cooking Systems Group PS870 Series - page 17

    17 III. QUICK REFERENCE: TROUBLESHOOTING SYMPTOM PROBLEM SOLUTION No electrical power • Check that the circuit breaker/fused disconnect is on. Make sure the emergenct stop button is on. Oven will not turn On. No gas pressure Burner did not light • Make sure main gas is on. • Turn oven off, and restart. If it still does not light, call for ser ...

  • Middleby Cooking Systems Group PS870 Series - page 18

    18 ...

  • Middleby Cooking Systems Group PS870 Series - page 19

    19 ...

  • Middleby Cooking Systems Group PS870 Series - page 20

    20 ...

  • Middleby Cooking Systems Group PS870 Series - page 21

    21 E. Blower Belts 1. To gain access to each blower belt compartment remove the four screws shown in Figure 4-8. Then, lift the rear shroud off its hangers. If access to the blower motors is required, remove the three mounting screws (two on the front of each shroud and one on the rear). Then, lift the end shroud straight up and off its hangers. 2. ...

  • Middleby Cooking Systems Group PS870 Series - page 22

    12 3 4 5 10 15 16, 17, 18 19 ITEM QTY. P/N DESCRIPTION 1 1 59081 DI G ITAL DISPLAY, PROGRAMMED 2 1 58678 MOTOR, CONVEYOR DRIVE 3 1 58679 CONVEYOR CONTROL BOARD 4 2 59168 INVERTER, PROGRAMMED 5 1 M9608 POWER SUPPLY 6 1 59337 KIT, THERMOCOUPLE (6 THERMOCOUPLES) 7 2 M9616 FAN, COOLING 8 2 57288 MOTOR, BLOWER 9 A 1 57141 AI R SWI TCH BURNER/BLOWER MOTO ...

  • Middleby Cooking Systems Group PS870 Series - page 23

    Wiring Diagrams (electrical schematics) Middleby-Marshall Model Number G208-240 volt 50/60 Hz, 1 Phase 54745 Rev. I ...

  • Middleby Cooking Systems Group PS870 Series - page 24

    24 ...

メーカー Middleby Cooking Systems Group カテゴリー Oven

Middleby Cooking Systems Group PS870 Seriesのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- PS870 Seriesの取扱説明書
- Middleby Cooking Systems Groupの製品カード
- パンフレット
- またはMiddleby Cooking Systems Group PS870 Seriesの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Middleby Cooking Systems Group PS870 Seriesの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Middleby Cooking Systems Group PS870 Seriesの取り付け説明書、サービスマニュアル、簡易説明書、またはMiddleby Cooking Systems Group PS870 Seriesのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Middleby Cooking Systems Group PS870 Seriesの製品を使用するにあたって最も人気のある説明書を閲覧できます。

Middleby Cooking Systems Group PS870 Seriesデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがMiddleby Cooking Systems Group PS870 Seriesを使用するのを助ける技術的文書のことです。説明書は通常、全てのMiddleby Cooking Systems Group PS870 Seriesユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Middleby Cooking Systems Groupの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Middleby Cooking Systems Group PS870 Seriesの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははMiddleby Cooking Systems Group PS870 Seriesの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Middleby Cooking Systems Group PS870 Seriesに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Middleby Cooking Systems Group PS870 Seriesデバイスの基本機能を使うにあたってのヒント。 Middleby Cooking Systems Group PS870 Seriesのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Middleby Cooking Systems Group PS870 Seriesに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるMiddleby Cooking Systems Group PS870 Seriesのメーカー/サービスへの連絡先に関する情報。

Middleby Cooking Systems Group PS870 Seriesについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもMiddleby Cooking Systems Group PS870 Seriesの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがMiddleby Cooking Systems Group PS870 Seriesで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)