Français dropdown-ico

Manuel d’utilisation Quadra-Fire CASTILEI-CE-MBK

36 pages 7.07 mb
Télécharger

Aller à la page of 36

Summary
  • Quadra-Fire CASTILEI-CE-MBK - page 1

    R www .quadrare.com October 27, 201 1 CASTILE & SANT A FE PELLET INSERT Owner ’ s Manual Installation and Operation CASTILEI-CE-MBK SANT AFEI-CE-MBK Models: DO NOT DISCARD THIS MANUAL NOTICE • Important operating and maintenance instruc - tionsincluded. • Leave this manual with party responsible f ...

  • Quadra-Fire CASTILEI-CE-MBK - page 2

    Page2 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradition of excellence!InchoosingaQuadra-Fire appliance,youhaveour assurance of commitment to quality , dur ...

  • Quadra-Fire CASTILEI-CE-MBK - page 3

    R October 27, 201 1 Page3 Castile & Santa Fe CE Insert 7069-101B T ABLE OF CONTENTS Safety Alert Key: • DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury . • W ARNING! Indicatesahazardoussituationwhich,ifnotavoidedcouldre ...

  • Quadra-Fire CASTILEI-CE-MBK - page 4

    Page4 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B ...

  • Quadra-Fire CASTILEI-CE-MBK - page 5

    R October 27, 201 1 Page5 Castile & Santa Fe CE Insert 7069-101B ...

  • Quadra-Fire CASTILEI-CE-MBK - page 6

    Page6 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Appliance Certication B. Glass Specications D. Specications This appliance is equipped with 5mm ceramic glass.  Replace glass only with 5mm ceramic glass.  Please contact your dealerforreplacement? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 7

    R October 27, 201 1 Page7 Castile & Santa Fe CE Insert 7069-101B HOT SURF ACES! Glassandothersurfacesarehotduringoperation ANDcooldown. Hot glass will cause burns. • Donottouchglassuntilitiscooled • NEVERallowchildrentotouchglass • Keepchildrenaway ? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 8

    Page8 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Fire Safety T o provide reasonable re safety , the following should be givenseriousconsideration: • Install at least one smoke detector and CO  monitor on each  oorofyourhome. • Loc ...

  • Quadra-Fire CASTILEI-CE-MBK - page 9

    R October 27, 201 1 Page9 Castile & Santa Fe CE Insert 7069-101B D. General Operating Information 1. Thermostat Calls For Heat The appliance is like most modern furnaces; when the thermostat  callsfor heat,your appliancewill automaticallylight anddeliver heat. When the r ...

  • Quadra-Fire CASTILEI-CE-MBK - page 10

    Page10 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Fire Characteristics A properly adjusted re with the heat output control button seton“HIGH”hasashort activeamepatternthatextends outoftherepotapproximately102mm. If the ...

  • Quadra-Fire CASTILEI-CE-MBK - page 11

    R October 27, 201 1 Page1 1 Castile & Santa Fe CE Insert 7069-101B J. Ignition Cycles 1. At the beginningof eachignition cycle, itis normalto see some smoke in the rebox.  The smoke will stop once therestarts. 2. The convection blower will a ...

  • Quadra-Fire CASTILEI-CE-MBK - page 12

    Page12 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 3 Maintaining & Servicing Y our Appliance C. General Maintenance 1. T ypes of Fuel Depending on the type of fuel you are burning will dictate how oftenyouhavetocleanyourrepot. Ifthe fuelyou are? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 13

    R October 27, 201 1 Page13 Castile & Santa Fe CE Insert 7069-101B 5. Disposal of Ashes • Frequency:  Asneeded • By: Homeowner Ashes should be placed in a metal container with a tight-tting lid.  The closed container of ashes should be placedon anon- ...

  • Quadra-Fire CASTILEI-CE-MBK - page 14

    Page14 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B The amount of ash buildup in the repot will be a good guide to determine how often you should clean the heat exchangers. W ARNING Heatexchangercleaningrodsmaybewarm tothetouch.? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 15

    R October 27, 201 1 Page15 Castile & Santa Fe CE Insert 7069-101B 12. Cleaning Combustion Blower - Requires No Lubrication • Frequency: Y earlyorasneeded • By: QualiedServiceT echnician • T ask:  Contact your local dealer  13. Cleaning Convection Blower - Requires No Lubrication • Frequency:  ...

  • Quadra-Fire CASTILEI-CE-MBK - page 16

    Page16 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B D. High Ash Fuel Content Maintenance • Frequency:  Asneeded • By: Homeowner Correct Flame Size, Y ellow/White in Color Correct Figure 16.3 Ash Build Up in Firebox Pellets Back Up In Feed T ube Firepot Overfills T all, Lazy Flame, Orange in Color Incorrect ...

  • Quadra-Fire CASTILEI-CE-MBK - page 17

    R October 27, 201 1 Page17 Castile & Santa Fe CE Insert 7069-101B NOTICE: Odors and vapors are released during initial operation due to the curing of high tem - peraturepaint.Openwindowsforaircirculation.Odorsmaybeirritatingtosensitiveindividuals. 4 T r ...

  • Quadra-Fire CASTILEI-CE-MBK - page 18

    Page18 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 5 Getting Started Installer ’ s Guide A . Design, Installation & Location Considerations W ARNING! Risk of Fire Damaged parts could impair safe operation. Do NOT install damaged, incomplete or substitute components. 1. Applian ...

  • Quadra-Fire CASTILEI-CE-MBK - page 19

    R October 27, 201 1 Page19 Castile & Santa Fe CE Insert 7069-101B B. Thermostat Location The thermostat’s location will have some effect on the  appliance’soperation. When the thermostat is located close to the appliance, it may  require aslightly highert ...

  • Quadra-Fire CASTILEI-CE-MBK - page 20

    Page20 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 6 Dimensions and Clearances A. A ppliance Dimensions Figure 20.3- Front View Figure 20.1 - T op View Figure 20.2 -Side View 819mm 707mm 594mm 203mm 483mm 629mm 249mm 330mm 51mm Overall Size A B MetalSurroundw/CastT rim,STD 1080mm 762mm MetalSurroundw/Cast? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 21

    R October 27, 201 1 Page21 Castile & Santa Fe CE Insert 7069-101B Figure 20.4 - T op View A B C D C. Minimum Opening for Masonry and Factory-Built Fireplaces Inches Millimeters A Insertsidetocombustiblesidewall 16 406 B Inserttoptomantel 12 305 C Inserttoptomaximum.2-1/4inch (57mm)facetrim 4 ...

  • Quadra-Fire CASTILEI-CE-MBK - page 22

    Page22 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Do not terminate vent inanyenclosedorsemi-enclosed areasuchasacarport,garage,attic,crawlspace,undera sundeckorporch,narrowwalkwayorcloselyfencedarea, oranylocationthatcanbuild ...

  • Quadra-Fire CASTILEI-CE-MBK - page 23

    R October 27, 201 1 Page23 Castile & Santa Fe CE Insert 7069-101B V ent Congurations T oreduce probability ofreverse drafting duringshut-down conditions Hearth & Home T echnologies strongly recom - mends:  •  Installing the pellet vent with a minimum vertical ...

  • Quadra-Fire CASTILEI-CE-MBK - page 24

    Page24 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B E. Chimney and Exhaust Connection 1. Chimney & Connector :Use76mmto102mmdiameter type "L" or "PL" venting system.  It can be vented vertically orhorizontally . 2. Residential:  Use 24 ...

  • Quadra-Fire CASTILEI-CE-MBK - page 25

    R October 27, 201 1 Page25 Castile & Santa Fe CE Insert 7069-101B F. P ellet V enting Charts FireRisk. • Only LISTED venting components may be used. • NOOTHER ventcomponentsmaybe used. Substituteordamagedventcomponentsmay impairsafeoperation. W ARNING The maximum? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 26

    Page26 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 8 V enting Systems Figure 28.1 CAUTION Neverdrawoutsidecombustionairfrom: • W all,oororceilingcavity • Enclosedspacesuchasanatticorgarage NOTE: •  Illustrationsreecttypicalinstallationsandar ...

  • Quadra-Fire CASTILEI-CE-MBK - page 27

    R October 27, 201 1 Page27 Castile & Santa Fe CE Insert 7069-101B B. Full Reline With V ertical Outside Air Figure 29.1 Outside Air T ermination at Chimney T op 12” (305mm) min. below 12” (305mm) min. above NOTE; Use metal plate around exhaust vent pipe and seal all edges with non-flammable insulation such as mineral wool or ceramic. ...

  • Quadra-Fire CASTILEI-CE-MBK - page 28

    Page28 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 9 Appliance Set-Up A. Leveling System B. Outside Air Kit Instructions Parts Included in Kit: 1pieceof51mmx914mmex hose,2hoseclamps,1collarassembly ,1terminationcap assembly ,1trimring,fastenersand ...

  • Quadra-Fire CASTILEI-CE-MBK - page 29

    R October 27, 201 1 Page29 Castile & Santa Fe CE Insert 7069-101B C. Door Handle Removal 1. Opentheouterdoor . 2. Unlatchandopenthereboxdoor . 3. Continue to turn handle until it is free from the rebox door . D. Door Removal 1. Opentheouterdoor . 2. ...

  • Quadra-Fire CASTILEI-CE-MBK - page 30

    Page30 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Figure 32.2 1 2 3 4 5 6 7 8 F . Hearth Support For Standard Surround Only Figure 33.1 - Assembled View Item Description 1 Front,76mm 2 Front,127mm 3 CastRing,T op&Bottom,Interchangeable 4 Side,127mm 5 Side,76mm 6 PanelExtension,127mm 7 Pane ...

  • Quadra-Fire CASTILEI-CE-MBK - page 31

    R October 27, 201 1 Page31 Castile & Santa Fe CE Insert 7069-101B Base Plate Only Installation Parts Needed :(1)castring(2)basezeroclearancepanel extensions.Discardbalanceofparts. T ools Needed: Phillipsheadscrewdriver 1. Attachbasezeroclearancepanelextensionstocast? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 32

    Page32 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Surround and Cast T rim Set (CASTILE INSERT) I ncluded in Surround Kit: (2)sidesurrounds,leftand right;(1)surroundtop;(1)fastenerpackage. Included in Cast T rim Kit:  (2)casttrimlegs,leftandright;(1) ca ...

  • Quadra-Fire CASTILEI-CE-MBK - page 33

    R October 27, 201 1 Page33 Castile & Santa Fe CE Insert 7069-101B I. Panel and T rim Set (SANT A FE INSERT) 1. Laypanel topand legs facedown onprotective cov - eringtopreventscratching. 1. Attachthe panellegs tothe toppanel usinga Phillips head screwdriver . ...

  • Quadra-Fire CASTILEI-CE-MBK - page 34

    Page34 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 1. Opendoortoexposetherebox. 2. Install the left log rst and then the right log. Figure 37.1 3. Lean the logs against the cast iron brick in the back of therebox. 4. Pus ...

  • Quadra-Fire CASTILEI-CE-MBK - page 35

    R October 27, 201 1 Page35 Castile & Santa Fe CE Insert 7069-101B 1 . A  12 volt ACthermostat is required to operate this pellet appliance.  Y ou may use the included wall mount thermo - stator purchase an optional programmablethermostat orremotecont ...

  • Quadra-Fire CASTILEI-CE-MBK - page 36

    Page36 R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI CORPORA TION www .quadrare.com CONT ACT INFORMA TION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer visit our website at www .quadrare.com This product may be covere ...

Fabricant Quadra-Fire Catégorie Indoor Fireplace

Les documents que nous recevons du fabricant de l'appareilQuadra-Fire CASTILEI-CE-MBK peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Quadra-Fire
- manuels d’utilisations CASTILEI-CE-MBK
- fiches produit Quadra-Fire
- dépliants
- ou étiquettes-énergie Quadra-Fire CASTILEI-CE-MBK
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Quadra-Fire CASTILEI-CE-MBK.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Quadra-Fire CASTILEI-CE-MBK, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Quadra-Fire CASTILEI-CE-MBK. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Quadra-Fire CASTILEI-CE-MBK.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Quadra-Fire CASTILEI-CE-MBK, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Quadra-Fire CASTILEI-CE-MBK par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Quadra-Fire CASTILEI-CE-MBK.

Le manuel d’utilisation complet Quadra-Fire, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Quadra-Fire CASTILEI-CE-MBK - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Quadra-Fire CASTILEI-CE-MBK, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lQuadra-Fire CASTILEI-CE-MBK qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Quadra-Fire CASTILEI-CE-MBK - qui devraient nous aider dans les premières étapes lors de l'utilisation Quadra-Fire CASTILEI-CE-MBK
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Quadra-Fire CASTILEI-CE-MBK
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Quadra-Fire CASTILEI-CE-MBK dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Quadra-Fire CASTILEI-CE-MBK?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Quadra-Fire CASTILEI-CE-MBK, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Quadra-Fire CASTILEI-CE-MBK il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)