English dropdown-ico

Manual Quadra-Fire CASTILEI-CE-MBK

36 pages 7.07 mb
Download

Go to site of 36

Summary
  • Quadra-Fire CASTILEI-CE-MBK - page 1

    R www .quadrare.com October 27, 201 1 CASTILE & SANT A FE PELLET INSERT Owner ’ s Manual Installation and Operation CASTILEI-CE-MBK SANT AFEI-CE-MBK Models: DO NOT DISCARD THIS MANUAL NOTICE • Important operating and maintenance instruc - tionsincluded. • Leave this manual with party responsible f ...

  • Quadra-Fire CASTILEI-CE-MBK - page 2

    Page2 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradition of excellence!InchoosingaQuadra-Fire appliance,youhaveour assurance of commitment to quality , dur ...

  • Quadra-Fire CASTILEI-CE-MBK - page 3

    R October 27, 201 1 Page3 Castile & Santa Fe CE Insert 7069-101B T ABLE OF CONTENTS Safety Alert Key: • DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury . • W ARNING! Indicatesahazardoussituationwhich,ifnotavoidedcouldre ...

  • Quadra-Fire CASTILEI-CE-MBK - page 4

    Page4 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B ...

  • Quadra-Fire CASTILEI-CE-MBK - page 5

    R October 27, 201 1 Page5 Castile & Santa Fe CE Insert 7069-101B ...

  • Quadra-Fire CASTILEI-CE-MBK - page 6

    Page6 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Appliance Certication B. Glass Specications D. Specications This appliance is equipped with 5mm ceramic glass.  Replace glass only with 5mm ceramic glass.  Please contact your dealerforreplacement? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 7

    R October 27, 201 1 Page7 Castile & Santa Fe CE Insert 7069-101B HOT SURF ACES! Glassandothersurfacesarehotduringoperation ANDcooldown. Hot glass will cause burns. • Donottouchglassuntilitiscooled • NEVERallowchildrentotouchglass • Keepchildrenaway ? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 8

    Page8 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Fire Safety T o provide reasonable re safety , the following should be givenseriousconsideration: • Install at least one smoke detector and CO  monitor on each  oorofyourhome. • Loc ...

  • Quadra-Fire CASTILEI-CE-MBK - page 9

    R October 27, 201 1 Page9 Castile & Santa Fe CE Insert 7069-101B D. General Operating Information 1. Thermostat Calls For Heat The appliance is like most modern furnaces; when the thermostat  callsfor heat,your appliancewill automaticallylight anddeliver heat. When the r ...

  • Quadra-Fire CASTILEI-CE-MBK - page 10

    Page10 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Fire Characteristics A properly adjusted re with the heat output control button seton“HIGH”hasashort activeamepatternthatextends outoftherepotapproximately102mm. If the ...

  • Quadra-Fire CASTILEI-CE-MBK - page 11

    R October 27, 201 1 Page1 1 Castile & Santa Fe CE Insert 7069-101B J. Ignition Cycles 1. At the beginningof eachignition cycle, itis normalto see some smoke in the rebox.  The smoke will stop once therestarts. 2. The convection blower will a ...

  • Quadra-Fire CASTILEI-CE-MBK - page 12

    Page12 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 3 Maintaining & Servicing Y our Appliance C. General Maintenance 1. T ypes of Fuel Depending on the type of fuel you are burning will dictate how oftenyouhavetocleanyourrepot. Ifthe fuelyou are? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 13

    R October 27, 201 1 Page13 Castile & Santa Fe CE Insert 7069-101B 5. Disposal of Ashes • Frequency:  Asneeded • By: Homeowner Ashes should be placed in a metal container with a tight-tting lid.  The closed container of ashes should be placedon anon- ...

  • Quadra-Fire CASTILEI-CE-MBK - page 14

    Page14 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B The amount of ash buildup in the repot will be a good guide to determine how often you should clean the heat exchangers. W ARNING Heatexchangercleaningrodsmaybewarm tothetouch.? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 15

    R October 27, 201 1 Page15 Castile & Santa Fe CE Insert 7069-101B 12. Cleaning Combustion Blower - Requires No Lubrication • Frequency: Y earlyorasneeded • By: QualiedServiceT echnician • T ask:  Contact your local dealer  13. Cleaning Convection Blower - Requires No Lubrication • Frequency:  ...

  • Quadra-Fire CASTILEI-CE-MBK - page 16

    Page16 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B D. High Ash Fuel Content Maintenance • Frequency:  Asneeded • By: Homeowner Correct Flame Size, Y ellow/White in Color Correct Figure 16.3 Ash Build Up in Firebox Pellets Back Up In Feed T ube Firepot Overfills T all, Lazy Flame, Orange in Color Incorrect ...

  • Quadra-Fire CASTILEI-CE-MBK - page 17

    R October 27, 201 1 Page17 Castile & Santa Fe CE Insert 7069-101B NOTICE: Odors and vapors are released during initial operation due to the curing of high tem - peraturepaint.Openwindowsforaircirculation.Odorsmaybeirritatingtosensitiveindividuals. 4 T r ...

  • Quadra-Fire CASTILEI-CE-MBK - page 18

    Page18 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 5 Getting Started Installer ’ s Guide A . Design, Installation & Location Considerations W ARNING! Risk of Fire Damaged parts could impair safe operation. Do NOT install damaged, incomplete or substitute components. 1. Applian ...

  • Quadra-Fire CASTILEI-CE-MBK - page 19

    R October 27, 201 1 Page19 Castile & Santa Fe CE Insert 7069-101B B. Thermostat Location The thermostat’s location will have some effect on the  appliance’soperation. When the thermostat is located close to the appliance, it may  require aslightly highert ...

  • Quadra-Fire CASTILEI-CE-MBK - page 20

    Page20 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 6 Dimensions and Clearances A. A ppliance Dimensions Figure 20.3- Front View Figure 20.1 - T op View Figure 20.2 -Side View 819mm 707mm 594mm 203mm 483mm 629mm 249mm 330mm 51mm Overall Size A B MetalSurroundw/CastT rim,STD 1080mm 762mm MetalSurroundw/Cast? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 21

    R October 27, 201 1 Page21 Castile & Santa Fe CE Insert 7069-101B Figure 20.4 - T op View A B C D C. Minimum Opening for Masonry and Factory-Built Fireplaces Inches Millimeters A Insertsidetocombustiblesidewall 16 406 B Inserttoptomantel 12 305 C Inserttoptomaximum.2-1/4inch (57mm)facetrim 4 ...

  • Quadra-Fire CASTILEI-CE-MBK - page 22

    Page22 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Do not terminate vent inanyenclosedorsemi-enclosed areasuchasacarport,garage,attic,crawlspace,undera sundeckorporch,narrowwalkwayorcloselyfencedarea, oranylocationthatcanbuild ...

  • Quadra-Fire CASTILEI-CE-MBK - page 23

    R October 27, 201 1 Page23 Castile & Santa Fe CE Insert 7069-101B V ent Congurations T oreduce probability ofreverse drafting duringshut-down conditions Hearth & Home T echnologies strongly recom - mends:  •  Installing the pellet vent with a minimum vertical ...

  • Quadra-Fire CASTILEI-CE-MBK - page 24

    Page24 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B E. Chimney and Exhaust Connection 1. Chimney & Connector :Use76mmto102mmdiameter type "L" or "PL" venting system.  It can be vented vertically orhorizontally . 2. Residential:  Use 24 ...

  • Quadra-Fire CASTILEI-CE-MBK - page 25

    R October 27, 201 1 Page25 Castile & Santa Fe CE Insert 7069-101B F. P ellet V enting Charts FireRisk. • Only LISTED venting components may be used. • NOOTHER ventcomponentsmaybe used. Substituteordamagedventcomponentsmay impairsafeoperation. W ARNING The maximum? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 26

    Page26 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 8 V enting Systems Figure 28.1 CAUTION Neverdrawoutsidecombustionairfrom: • W all,oororceilingcavity • Enclosedspacesuchasanatticorgarage NOTE: •  Illustrationsreecttypicalinstallationsandar ...

  • Quadra-Fire CASTILEI-CE-MBK - page 27

    R October 27, 201 1 Page27 Castile & Santa Fe CE Insert 7069-101B B. Full Reline With V ertical Outside Air Figure 29.1 Outside Air T ermination at Chimney T op 12” (305mm) min. below 12” (305mm) min. above NOTE; Use metal plate around exhaust vent pipe and seal all edges with non-flammable insulation such as mineral wool or ceramic. ...

  • Quadra-Fire CASTILEI-CE-MBK - page 28

    Page28 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 9 Appliance Set-Up A. Leveling System B. Outside Air Kit Instructions Parts Included in Kit: 1pieceof51mmx914mmex hose,2hoseclamps,1collarassembly ,1terminationcap assembly ,1trimring,fastenersand ...

  • Quadra-Fire CASTILEI-CE-MBK - page 29

    R October 27, 201 1 Page29 Castile & Santa Fe CE Insert 7069-101B C. Door Handle Removal 1. Opentheouterdoor . 2. Unlatchandopenthereboxdoor . 3. Continue to turn handle until it is free from the rebox door . D. Door Removal 1. Opentheouterdoor . 2. ...

  • Quadra-Fire CASTILEI-CE-MBK - page 30

    Page30 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Figure 32.2 1 2 3 4 5 6 7 8 F . Hearth Support For Standard Surround Only Figure 33.1 - Assembled View Item Description 1 Front,76mm 2 Front,127mm 3 CastRing,T op&Bottom,Interchangeable 4 Side,127mm 5 Side,76mm 6 PanelExtension,127mm 7 Pane ...

  • Quadra-Fire CASTILEI-CE-MBK - page 31

    R October 27, 201 1 Page31 Castile & Santa Fe CE Insert 7069-101B Base Plate Only Installation Parts Needed :(1)castring(2)basezeroclearancepanel extensions.Discardbalanceofparts. T ools Needed: Phillipsheadscrewdriver 1. Attachbasezeroclearancepanelextensionstocast? ...

  • Quadra-Fire CASTILEI-CE-MBK - page 32

    Page32 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Surround and Cast T rim Set (CASTILE INSERT) I ncluded in Surround Kit: (2)sidesurrounds,leftand right;(1)surroundtop;(1)fastenerpackage. Included in Cast T rim Kit:  (2)casttrimlegs,leftandright;(1) ca ...

  • Quadra-Fire CASTILEI-CE-MBK - page 33

    R October 27, 201 1 Page33 Castile & Santa Fe CE Insert 7069-101B I. Panel and T rim Set (SANT A FE INSERT) 1. Laypanel topand legs facedown onprotective cov - eringtopreventscratching. 1. Attachthe panellegs tothe toppanel usinga Phillips head screwdriver . ...

  • Quadra-Fire CASTILEI-CE-MBK - page 34

    Page34 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 1. Opendoortoexposetherebox. 2. Install the left log rst and then the right log. Figure 37.1 3. Lean the logs against the cast iron brick in the back of therebox. 4. Pus ...

  • Quadra-Fire CASTILEI-CE-MBK - page 35

    R October 27, 201 1 Page35 Castile & Santa Fe CE Insert 7069-101B 1 . A  12 volt ACthermostat is required to operate this pellet appliance.  Y ou may use the included wall mount thermo - stator purchase an optional programmablethermostat orremotecont ...

  • Quadra-Fire CASTILEI-CE-MBK - page 36

    Page36 R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI CORPORA TION www .quadrare.com CONT ACT INFORMA TION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer visit our website at www .quadrare.com This product may be covere ...

Manufacturer Quadra-Fire Category Indoor Fireplace

Documents that we receive from a manufacturer of a Quadra-Fire CASTILEI-CE-MBK can be divided into several groups. They are, among others:
- Quadra-Fire technical drawings
- CASTILEI-CE-MBK manuals
- Quadra-Fire product data sheets
- information booklets
- or energy labels Quadra-Fire CASTILEI-CE-MBK
All of them are important, but the most important information from the point of view of use of the device are in the user manual Quadra-Fire CASTILEI-CE-MBK.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Quadra-Fire CASTILEI-CE-MBK, service manual, brief instructions and user manuals Quadra-Fire CASTILEI-CE-MBK. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Quadra-Fire CASTILEI-CE-MBK.

Similar manuals

A complete manual for the device Quadra-Fire CASTILEI-CE-MBK, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Quadra-Fire CASTILEI-CE-MBK by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Quadra-Fire CASTILEI-CE-MBK.

A complete Quadra-Fire manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Quadra-Fire CASTILEI-CE-MBK - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Quadra-Fire CASTILEI-CE-MBK, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Quadra-Fire CASTILEI-CE-MBK, that we can find in the current document
3. Tips how to use the basic functions of the device Quadra-Fire CASTILEI-CE-MBK - which should help us in our first steps of using Quadra-Fire CASTILEI-CE-MBK
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Quadra-Fire CASTILEI-CE-MBK
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Quadra-Fire CASTILEI-CE-MBK in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Quadra-Fire CASTILEI-CE-MBK?

Use the form below

If you did not solve your problem by using a manual Quadra-Fire CASTILEI-CE-MBK, ask a question using the form below. If a user had a similar problem with Quadra-Fire CASTILEI-CE-MBK it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)