Heat Controller R-410Aの取扱説明書

16ページ 1.97 mb
ダウンロード

ページに移動 of 16

Summary
  • Heat Controller R-410A - page 1

    OUTDOOR SPLIT SYSTEM HEA T PUMP INST ALLA TION INSTR UCTIONS DO NO T DESTRO Y . PLEASE READ CAREFULL Y AND KEEP IN A SAFE PLA CE FOR FUTURE REFERENCE. IMPOR T ANT A TTENTION INST ALLERS: It is your responsibility to kno w this product better than y our customer . This includes being able to install the pr oduct according to strict saf ety guideline ...

  • Heat Controller R-410A - page 2

    2 W ARNING: ELECTRICAL SHOCK, FIRE OR EXPLOSION HAZARD Failure to follow safety warnings exactly could result in serious injury or property damage. Improper servicing could result in dangerous operation, serious injur y , death or property damage. • Before servicing, disconnect all electrical power to the indoor blo wer . • ...

  • Heat Controller R-410A - page 3

    3 HEA T PUMP INST ALLA TION General Information Split system heat pumps are designed only f or outdoor rooftop or ground le v el installations. This unit has been tested f or capacity and efficiency in accordance with AHRI Standards and will provide man y years of saf e and dependable comf or t, providing it is properly installed and maintained. A ...

  • Heat Controller R-410A - page 4

    4 Connecting RefrigerantT ubing Between  the Indoor & Outdoor Unit CA UTION: When servicing, cover or seal openings to minimize the exposure of the refrigerant system to air to prevent accum ulation of moisture and other contaminants. After outdoor and indoor unit placement has been determined, route refr igerant tubing between the ...

  • Heat Controller R-410A - page 5

    5 the line-v oltage leads to the ter minals on the contactor inside the control compar tment. • Use only copper wire for the line voltage power supply to this unit as listed in T able 1. Use proper code agency listed conduit and a conduit connector f or connecting the supply wires to the unit. Use of rain tight co ...

  • Heat Controller R-410A - page 6

    6 • Do not add additional oil to motors unequipped with oil tubes. The compressor is her metically sealed at the f actor y and does not require lubrication. ST ART UP & ADJUSTMENTS Pre-Start Check List √ V er ify the unit is le vel and has sufficient clearances f or unobstructed airflow . √ V erify the o ...

  • Heat Controller R-410A - page 7

    7 ther mostat. NO TE: The blo wer should also stop unless f an s witch is set to the ON position. System Heating (Optional) 1. If heating equipment (fur nace, air handler) is pro vided with the system, lower the thermostat setpoint temperature to the lo west temperature setting and change the ther mostat’ s system mode to HEA T . 2 . Gradually in ...

  • Heat Controller R-410A - page 8

    8 • A high-pressure s witch is f actor y installed and located inter nally on the compressor discharge line of the outdoor unit. If the discharge pressure rises above 650 psig, theswitchwillopenand de-energizetheoutdoorunit.  The s witch will close again after the discharge pressure decreases to 460 psig. NO TE: When ...

  • Heat Controller R-410A - page 9

    9 2 . Measure the liquid refrigerant temperature (in F ahrenheit) at the ser vice valv e. 3. Deter mine the required liquid refrigerant pressure . Ref er to T ables 3-9 (pages 11-13) and Figures 5-11 (pages 13-16). • If the pressure measured in Step 1 is greater than the required liquid refrigerant pressure deter ...

  • Heat Controller R-410A - page 10

    10 Figure 4. Charging Chart for 3 T on Units Liquid T emperature (° F) Liquid Pressure (psig) 250 275 300 325 350 375 400 425 450 475 500 70 75 80 85 90 95 100 10 51 10 115 120 12 5 Remo ve refr igerant when abo ve cur ve Add refrigerant when below cur ve Figure 5. Charging Chart for 4 T on Units Liquid T emperature (° F) Liquid Pressure (psig) 2 ...

  • Heat Controller R-410A - page 11

    11 Figure 6. Charging Chart for 5 T on Units Liquid T emperature (° F) Liquid Pressure (psig) 250 275 300 325 350 375 400 425 450 475 500 70 75 80 85 90 95 100 105 110 11 51 20 125 Remo ve refr igerant when abo ve cur ve Add refrigerant when below cur ve Figure 7. Heating Charging Chart Liquid T emperature (° F) Liquid Pressure (psig) 20 0 22 5 2 ...

  • Heat Controller R-410A - page 12

    12 HPS W2 OU T LP S Y OU T Y2 OU T Y2 W2 IN L COI L C Y O R AMB DF 1D F2 RV OUTDOOR FA N MO TO R T1 T2 L1 L2 RIGHT COMPRESSOR HPS LPS RV COIL C R S CCH BLACK YELLOW RED C H C TO THERMOST AT AMB SENSOR OD SENSOR CAP ACIT OR CONT AC TO R LEFT DEFROST BOARD C GRN DL 1L 2 SINGLE PHASE FIELD SUPPL Y GROUNDING SCREW F BLACK ORANGE S R BLUE C S R H C F 20 ...

  • Heat Controller R-410A - page 13

    13 AMB HP S W2 OU T LP S Y OU T Y2 OU T Y2 W2 IN L COIL C Y O R DF1 DF2 RV BLACK RED OUTDOOR F AN MO TO R T1 T2 L1 L2 COMPRESSOR HPS LPS RV COIL CCH BLACK RED BLUE ORANGE H F C R S TO THERMOST AT AMB SENSOR OD SENSOR CONT AC TO R DEFROST BOARD LFT RT S L H C NC NO COM GRND GROUNDING SCREW FA N RELA Y CA PA CITOR L1 L2 YELLOW C TERMINAL BLOCK D RED ...

  • Heat Controller R-410A - page 14

    14 HPS W2 OU T LP S Y OUT Y2 OUT Y2 W2 IN L COIL C Y O R AMB DF 1D F2 RV OUTDOOR F AN MO TO R COMPRESSOR HPS LPS RV COIL CCH WHITE YELLOW H C TO THERMOST AT AMB SENSOR OD SENSOR BR OW N BLACK CONT AC TO R T1 T2 L1 L2 LEFT RIGHT Y1 C Y2 ECM L2 L1 DEFROST BOARD RED BLACK YELLOW GRND GROUNDING SCREW L1 L2 C R S BLUE C TERMINAL BLOCK D 6 BLUE BLACK YEL ...

  • Heat Controller R-410A - page 15

    15 ...

  • Heat Controller R-410A - page 16

    INST ALLA TION / PERFORMANCE CHECK LIST REFRIGERA TION SYSTEM W as unit given 24 hr w arm up per iod for cr ankcase heaters? YES NO Stage-1 Liquid Pressure (high side) ________________________ Stage-1 Suction Pressure (low side) ________________________ ELECTRICAL SYSTEM Electrical connections tight? YES NO Line voltage polarity correct? YES NO Rat ...

メーカー Heat Controller カテゴリー Heat Pump

Heat Controller R-410Aのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- R-410Aの取扱説明書
- Heat Controllerの製品カード
- パンフレット
- またはHeat Controller R-410Aの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Heat Controller R-410Aの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Heat Controller R-410Aの取り付け説明書、サービスマニュアル、簡易説明書、またはHeat Controller R-410Aのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Heat Controller R-410Aの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Heat Controller R-410Aデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがHeat Controller R-410Aを使用するのを助ける技術的文書のことです。説明書は通常、全てのHeat Controller R-410Aユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Heat Controllerの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Heat Controller R-410Aの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははHeat Controller R-410Aの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Heat Controller R-410Aに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Heat Controller R-410Aデバイスの基本機能を使うにあたってのヒント。 Heat Controller R-410Aのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Heat Controller R-410Aに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるHeat Controller R-410Aのメーカー/サービスへの連絡先に関する情報。

Heat Controller R-410Aについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもHeat Controller R-410Aの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがHeat Controller R-410Aで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)